Professional Documents
Culture Documents
FXCB/FXDB/FXEB/FXFC
Output power Antenna Port per sector 80W 80W 80W 80W
MCPA Concurrent mode(s) - 5G+1U/1L(5MHz) - 5G+1U/1L(5MHz) - - 5G+1U/1L(5MHz) - 5G+1U/1L(5MHz)
Max supported by HW: - 4G+2U/1L(10MHz) - 4G+2U/1L(10MHz) - 4G+2U/1L(10MHz) - 4G+2U/1L(10MHz)
-2U+1L(10MHz) -2U+1L(10MHz) -2U+1L(10MHz) -2U+1L(10MHz)
-2G+1L(20MHz) -2G+1L(20MHz) -2G+1L(20MHz) -2G+1L(20MHz)
GSM/LTE, GSM/WCDMA -- 2G+1U+1L(10MHz) -- 2G+1U+1L(10MHz) -- 2G+1U+1L(10MHz) -- 2G+1U+1L(10MHz)
GSM/WCDMA/LTE -2U+1L(10MHz) -2U+1L(10MHz) -2U+1L(10MHz) -2U+1L(10MHz)
WCDMA/LTE - 8G+2x2L(15MHz) MIMO with 2 - 8G+2x2L(15MHz) MIMO with 2 - 8G+2x2L(15MHz) MIMO with 2 - 8G+2x2L(15MHz) MIMO with 2
MCPAs (RFMs) MCPAs (RFMs) MCPAs (RFMs) MCPAs (RFMs)
-- 8G+2x2L(20MHz) MIMO with 2 -- 8G+2x2L(20MHz) MIMO with 2 -- 8G+2x2L(20MHz) MIMO with 2 -- 8G+2x2L(20MHz) MIMO with 2
RFMs (without Rx cross cabling RFMs (without Rx cross cabling RFMs (without Rx cross cabling RFMs (without Rx cross cabling
upto 60MHz) upto 60MHz) upto 60MHz) upto 60MHz)
System Module
Option 2: FPCC DC cable multibeam-open 2m (6.6 ft) ” 472823A”
• Check table in next slide for use of single cable. Up to 4 RFMs can be connected with System
Module when single power cable is used.
3x90W RFM
To minimize potential site work, consider future expansion when selecting DC cables.
Note : Check the power consumption. If power demand exceeds 30A, as may happen with low operating voltages with 3x90W RF Modules operating in full power
mode, it is recommended to use bigger fuses in the DC feed lines. If you use a integrated power distribution unit (PDU), system module with 30A output capability,
then it is recommended to use the dual power cable FPCA 472806A
Sectors
– per branch if more output power is needed 1 0 1 2 3
11 0 2 4 6
111 0 3 6 9
Power Licenses
# of Power licenses
Duplexer
TX
MCPA
2 way diversity, 6 antenna ports/module LNA
RX main RXMC
1 x Pol antenna per sector
RX
LNA
RX div X
Output Power
Duplexer
TX
1/1/1 @ 80W per TRX MCPA
LNA
RX main
2/2/2 @ 40W per TRX RXMC
RX
LNA
3/3/3 @ 26.6W per TRX RX div X
4/4/4 @ 20W per TRX
Duplexer
TX
MCPA
5/5/5@16W per TRX RX main RXMC
LNA
RX
LNA
RX div
Duplexer RX
TX
MCPA
LNA
1 x XPol antenna per sector** RP3 RX main RXMC
Duplexer RX
TX
MCPA
6/6/6 @ 26.6W per TRX RP3
RX main RXMC
LNA
65W
55W
Duplexer RX
TX MCPA FXxA
• IBW of Both Radio should be same for Antenna LNA
RP3 RX main RXMC
optimized configuration
LNA
• Output for should be common for FXxA and FXxB RX div
Radio Module X
• FXxA Chaining with FXxB RM2
Duplexer RX
TX MCPA
• Configuration Example Below RP3 LNA
RX main RXMC
LNA
3x70W RFM 3x90W RFM RX div
FXxB
max Output max Output
Configuration Power Configuration Power Max Configuration
1/1/1 60W 1/1/1 60W 2/2/2@60W
2/2/2 30W 2/2/2 30W 4/4/4@30W
3/3/3 20W 4/4/4 20W 7/7/7@20W
4/4/4 15W 5/5/5 15W 9/9/9@15W
5/5/5 12W 5/5/5 12W 10/10/10@12W
6/6/6 10W 6/6/6 10W 12/12/12@10/12*W
Note : Radio Module and Remote Radio head can not be shared in one sector but RRH can be used with Triple RFM for Sector Addition
*12 W support will come with EX5.0 EP1
10 © Nokia Siemens Networks Flexi Multiradio BTS / Flexi RFM 90W
Single RAT power Levels, GSM
RF Branch 1 Tx1/Rx1
35 MHz
35 MHz
RF Branch 2
RF Branch 2 Tx2/Rx2 Rx main Tx main
diversity for branch 1
via branch 2 Rx main Tx main
35 MHz 35 MHz