Professional Documents
Culture Documents
First of all, turn on the display on PC and run the software for centrifugal
pump.
After you have started the PC turn on the switch which is at the back side it
will turn on the power meter.
Set the points at the speed of your desire by means of speed regulator and
note value of your desired speed.
For series operation, the butterfly valve V2 and V4 is closed while V3 is
closed.
We know that as the flow increases the speed of pump also increases so the
pump must be adjusted to speed of your desire using speed regulator.
Plot the measuring point when the measured values are stable enough.
Follow the above procedure again and note the readings at different points.
Safety
Make sure that the pump is not dry and is filled with water.
Only connect the sensors with the cables which are mentioned in the user
guide.
Wear goggles and gloves
Do not supply voltage to sensors from external sources.
Perform the experiment in the room where there is no flammable gas and
dirt and it should be dry.
Pump should be operated at required voltage which is mentioned in the user
guide. It should not either exceed or decrease.
For head protection wear helmet.
Do not remove hoses from the sensors.