Professional Documents
Culture Documents
Fox515 Technical Data PDF
Fox515 Technical Data PDF
SUBLA/EXLAN ITU-T coding A-law acc. G.711 NEMCA ITU-T coding A-law G.711 Relevant ITU-T recommendations G.702, G.703, G.704, G.706, G.711
Analogue subscriber- Characteristics of 2 wire NF interfaces with Characteristics of voice G.712-G.715, G.732, G.735, G.736,
and exchange interfaces voice channels Q.552 E&M signaling channels G.712-G.715 G.737, G.742, G.821, G.823, G.826,
Number of interfaces 12 Number of interfaces 8 Q.920, Q.921, Q.922
Nominal impedance Complex Module width 1 DXC 1/1 and 1/0 function Modular non blocking cross connect
Signaling, basic functions Seizure, ringing, ringing off, from 8 x 2 Mbit/s up to128 x 2 Mbit/s
transmission of flash pul- RIGEN Ringing frequency 25 Hz Cross connections at 64 kBit/s,
ses, pulse dialing, DTMF Ringer Generator Ringing voltage 70 Vrms n x 64 kBit/s and 2 Mbit/s
without accompanying Module width 2 Tributary channels Supports up to 240 channels as
signal, earth key, charging tributary from FOX-U modules
using 12/16 kHz pulses 1+1 Path protection (n x 64 kBit/s) With NEMCA, SIFOX, GECOD,
Module width 1 SULIC, UNIDA, TEBIT
www.abb.com/utilitycommunications
FOX 515 OVERVIEW
COBUX
Traffic
Interfaces
Control
64k
2 w a, b
SUBLx/SUBUK COBUX
8 x 2 Mbit/s
Subscr. line IF (64k) ZS16
12 ports
UBUS access
Synchronization
RIGEN MIB
70V 25Hz Alarm IF
Ringer Generator
Management communication
8 x 2 Mbit/s
64k
PAX 2 w a, b EXLAx
Exchange line IF (64k) ZS16
12 ports
2048 kHz
2/4 w a, b 64k Ext. clock input (2)
PAX NEMCA
Clock output (3)
E&M Voice freq. IF (64k) ZS16 high/low
8 ports Ext. alarm input (4)
(E'&M') open/close
Alarm relay output (2)
64k 115 kbit/s
}
GECOD F-interface (RS232)
64k
DTE 64 kbit data IF (64k) ZS16
G.703 Q1-interface
8 ports
10Base T
Qx-interface
UCST
SIFOX 64k UNEM
64k
DTE Data IF / EOC (64k) ZS16
X.24/V.11
4 ports
4 x V.24/V.28
(RS232)
UNIDA 431
4 x V.35 n x 64k
UNIDA 432
4 x X.24/V.11
DTE UNIDA 433
2 x V.36 RS449 (64k) ZS16
UNIDA 434
4 x V.36 RS449 8 x 2 Mbit/s PHL C1
UNIDA 435 2 w a, b
Subscr. line IF
60 ports
128k/64k 64k
X.21/V.11 SULIC
2 w a, b
DTE V.35 NTU Data IF for NTU 64k
V.24/V.28 144k 8 ports
0,6-38,4k 2B1Q
64k
SULIS
S0 2 w a, b ISDN-U (2B1Q) 64k (16K)
ISDN NT-1 144k Subscr. line IF
8 ports 64k
2B1Q PCONV
8 x 2 Mbit/s V.5x Protocol conv.
64k 2 x 2 Mbit/s G.703/G.704
ISBUQ (V5) 2 Mbit/s IF
S0 2 w a, b ISDN-U (2B1Q) 64k (16K) 2 ports
ISDN NT-1 Subscr. line IF
144k 64k
2B1Q 8 ports
64k
EXBAT
PAX 2 w a, b ISDN-U (4B3T) 64k (16K)
4B3T Exchange line IF
64k
SDH Transmission
Interfaces
8 ports
}
64k
SUBAT 8 x 2 Mbit/s
S0 2 w a, b ISDN-U (4B3T) 64k (16K)
ISDN NT-1 SYNAC
144k Subscr. line IF 8 x VC12
4 ports 64k
4B3T 8 x VC12
SBUS 2 x VC4
2 w a, b
UMUX 500 RT LECO 3 64k
2 w a, b STM1 Opt.
U5AP1 (PSTN) UMUX 500 RT (64k) ZS16 SYNIO
S0 2 w a, b 10 ports 3 ports
NT-1 STM1 Opt.
Synchronous interfaces
24 input ALCAR
el. 24 Alarm Inputs
EXT. ALARMS 8 output 4 Contact Outputs
el. 4 Serial Ports
STM1 Opt.
1 x optical n x 64k SYNIO
OPTICAL INTERFACE OTERM
- FOX 20/6+ (n=1...20) STM1 Opt.
- NSD 70D
- REL 316 F / 561 / 551 / 511
- prDIN EN 60 870
PDH
Transmission
Interfaces
Electrical IF Optical IF
2 Mbit/s G.703/G.704 2 ports 2 ports 8 Mbit/s optical
8 Mbit/s optical
8 Mbit/s G.703 TUNEL TUNOS V.11 OHC
4 x 2 Mbit/s 8 Mbit/s optical
4 x 2 Mbit/s Optical/el. IF V.11 OHC
Electrical IF 2 opt. ports 2 Mbit/s G.703/G.704
8 Mbit/s G.703 2 ports 2 el. ports
2 Mbit/s G.703/G.704
}
2/4 w a, b
2 Mbit/s G.703/G.704 LECA 2 TUNOL
HDSL/CAP 8 Mbit/s optical 2)
4 x 2 Mbit/s
4 x 2 Mbit/s TUNOR G.703/G.704
LECA 2 Optical/el. IF
2 Mbit/s G.703 1) 1 opt. ports
2/4 w a, b 2/4 w a, b 2 x 2 Mbit/s 4 el. ports 4 x 2 Mbit/s
or LECAR
n x 64 kbit/s G.703/G.704 G.703/G.704
HDSL/CAP HDSL/CAP
X.21/V.11 or V.35 or V.36 Electrical IF
or 10BaseT 1 port
2 w a, b 5 VDC POSUS
4 x 10BaseT SOHO Power supply –48 VDC
HDSL/CAP
1)
Either LECA2 or LECAR or SOHO
2) Either remote TUNOR or TUNOL
www.abb.com/utilitycommunications