Professional Documents
Culture Documents
GCV401 - Structural Analysis - Chapter II - Statically Determinate Analysis
GCV401 - Structural Analysis - Chapter II - Statically Determinate Analysis
Chapter II :
Analysis
of
TDM
Statically Determinate
Structures
Subjects:
Chapter II: Statically Determinate
1. Load Values
TDM
2. Point of applied loads Suj I
1
II.1 Idealized Structure
Suj I
TDM
Suj I
TDM
Suj I
2
II.1 Idealized Structure
Suj I
TDM
Suj I
Tributary Area:
1. Transmission of loads to the various structural elements used for their
support.
2. Based on the structural Systems, the load transmission will be
TDM
occurred:
Suj I
a. Geometric
b. Materials
c. Construction Methods
3. Two ways for slab load transmission:
1. One Way System
2. Two Way System
9
3
II.1 Idealized Structure
Suj I
10
TDM
Suj I
11
https://www.youtube.com/watch?v=F-C6fCBy99w
One Way Slab:
1. Case when the girders and beams (joists)
are in the same level.
2. Reinforcement in one direction also
TDM
defined the system direction.
Suj I
3. Report of L1/L2:
Greater than 2 one way system
Less than 2 Two way System
12
4
II.1 Idealized Structure
13
Example 2.1:
The floor of a classroom is to be supported by the bar joists as shown. Each
joist is 15 ft long and they are spaced 2.5 ft on centers. The floor itself is to be
made from lightweight concrete that is 4 in thick. Neglect the weight of the
TDM
joists and the corrugated metal deck, and determine the load that acts along
Suj I
each joist.
14
Suj I
15
5
II.1 Idealized Structure
16
TDM
Suj I
17
18
6
II.1 Idealized Structure
TDM
Suj I
19
displacements. Suj I
Suj I
Internal Forces calculation – M, V, P & T – Equilibrium
– Section Method
21
7
II.4 Determinacy and Stability
Example 2.4:
Classify each of the beams shown hereunder as statically
determinate or statically indeterminate. If statically indeterminate,
report the number of degrees of indeterminacy. The beams are
subjected to external loadings that are assumed to be known and can
TDM
act anywhere on the beams.
Suj I
23
Solution
TDM
Suj I
24
8
II.4 Determinacy and Stability
25
Solution:
TDM
Suj I
26
Example 2.6:
Classify each of the frames shown here under as statically
determinate or statically indeterminate. If statically indeterminate,
report the number of degrees of indeterminacy. The frames are
subjected to external loadings that are assumed to be known and can
TDM
act anywhere on the frames.
Suj I
27
9
II.4 Determinacy and Stability
TDM
Suj I
28
TDM
Suj I
30
10
II.4 Determinacy and Stability
Suj I
31
TDM
Suj I
32
TDM
Suj I
33
11
II.4 Determinacy and Stability
TDM
Suj I
34
35
12