Professional Documents
Culture Documents
1. In process control the basic objective is to _________ the value of some quantity.
a] Regulate b]Control c]Both a&b
3. __________ refers to the time for the processcontrol loop to make necessary adjustments to the
final control element
a] Control lag b] Process c]manipulated variable
4. ________ is the elapsed time between the instant deviation occurs and when the corrective action
first occurs.
a] Controlled variable b] Process c] Dead time.
6. The two position control mode is best adapted to large scale system with relatively slow process
rates.
a] small b] large c]medium
8. A controller operates with __________ when an increasing value of the controlled variable causes
an increasing value of the controller output.
a] Direct action b] reverse Action c]manipulated variable
9. A controller operates with ____________ when an increasing value of the controlled variable
causes an decrease in value of the controller output.
a] Direct action b] on off control c]reverse action
10. floating control the specific output of the controller is not uniquely determined by the error.
A] Multiposition Control b] on off control c]floating control