Professional Documents
Culture Documents
Dissertation - Synopsis: Dr. J. Rishiraj Postgraduate Student Department of Prosthodontics BATCH 2011-2012
Dissertation - Synopsis: Dr. J. Rishiraj Postgraduate Student Department of Prosthodontics BATCH 2011-2012
DR. J. RISHIRAJ
POSTGRADUATE STUDENT
DEPARTMENT OF PROSTHODONTICS
BATCH 2011-2012
MANGALORE
Bangalore
ANNEXURE II
6.2Review of literature
4. Lang NP, Kiel RA and Andhalden K (1983)4 studied the clinical and
microbiological effects of subgingival restoration with overhanging or
clinically perfect margins and they found that overhanging subgingival
restoration leads to increase in the potential mechanism for initiation of
periodontal disease.
5. Holmes JR, Bayne SC, Holland GA, Sulik WD (1989)5 studied the
considerations in the measurement of marginal fit and they presented the
significance and difference in the magnitude of misfit at different location
between the tooth and a restoration and found that the absolute marginal
discrepancy would always be the largest measurement of error at the margin and
would reflect the total misfit at that point.
7.1Source of data
Methodology
Prior to the fabrication of each sample from Group I, the stainless steel die will be
coated with Die spacer (Han Dae Chemical Co. Ltd.). One coat will be painted with
a paint brush. Die spacer will be applied on all tooth preparation surfaces, 1mm
short of the finish line. Resin pattern (light polymerized acrylic resin) will be made
and the pattern will be read by the technician-guided sensor and the copings will be
milled out of the Zirconia blocks. For group II, copings will be virtually designed
based on scanned die and the data regarding the virtually designed coping will be
transmitted to the decentralized manufacturing center of the CAD/CAM (3 Shape
dental system) where the zirconia copings will be manufactured.
The marginal discrepancy of the test specimens will be measured using an
translating toolmaker microscope and using software analysis for both group I and
group II.
Investigation design
30 samples of zirconia copings
will be prepared using 2
systems
Group I (15 SAMPLES) Group II (15 SAMPLES)
NO
7.4Has ethical clearance been obtained from your institution, if yes for
7.3
Not applicable.
8. List of references
11.4 Signature