PROL.NO, 4683-020 Pace: tots
| Entra stn asso, 0 on-MoouLe Rear Weeaeaeriaes
| USNS Fa SRR rere
PRESSURE DIFFERENTIAL TRANSMITTERS - ELECTRONIC SPECIFICATION
1.0 GENERAL
4.1 Vendor shall provide protection adequate for shipment and slorage of instnuments
‘Allopenings and exposed parts shat be protected, so a8 to prevent debris Fam entering
‘All fanges and threaded cannecions shal be protected against damage Using WODd,
‘tal, anor plastic protectors.
1.2 Vendo shal early state any, and all exceptions ina separate section of quote labeled
"Exoeplone & Clenifcabone” Faure todo 20 shall imply vendor hes no exceptions,
13. Inthe event a model number ghen contct with other data provided, the model number
shallbe ignored, andthe data provided wl govern. Netly Ventech prior making any
changes,
1.4. Uniess note othenvse a electrical accessoras shall be approved for wean a
outdoor Class 1 Dison 2 Greuns C&D location,
415. Vendor dsta shal be provided in tet accordance with Aached "Vendor Data Recuiemens"
Sheet
1.8. To speed up delivery, VEt shall perform transmits calitvation Le. Tag No. and service Kenticaion
as wel as Soniguration of specie cabration range. Howover, vendor shall aneure ful inchonalty
fhe device and tha! model proved is sullable for species range
1.7 Each device shall be supplied complete wah a permanently affued, stamped tainies soe!
rametog containing tne complete device tag Aumber.
1.8 Transmitters sha be wih 12° NPT screwed process coonactions.
1.9. Alltansmitrs shal have adjustable 220 and span,
440 For diferent flow transmiters, the square rot flow signals fom the fed shal b nearized in tow
lransmiters and notin DCS, unless otherwise spectied
411 in services that are corrosive to avaible tranemitar internals, where plugsing may oscuro ish
viscosly fds ae encountered, diphragm seals compatie withthe process ud shall be used to
Isolate the tranertor internals om te process AU,
112'The ranemitor electronics shal be capable of monitoring Hs performance during normal operation,
The dlagnostics shall be abe to dalect ansmtter electronics (e3, CPU) fare. Over renge signal
{sitter ew 0° righ miliamps) shai be tansmitea bythe davies tote host sytem to nceale
foarones Falure,
1.13 Al electronic transmits shat be 2¢VDC Ioop powored amar ype with fo 20mA with dal
‘communication protocol superimposed (HART) unless othenwise speetied
1.14 Al electronic transmits enclosures shall be NEMA 4X oP 55 as minimum,
1.48 1V2NPT electrical connection f preferred,
4.16 A ransmiters and remote indicators shall be furished wih a universal mounting brscket for 2" ioe
or yoke
1.17 Al electronic ansmitrs shall 2 provided wit an integral dal ype Inestr unless otherwise
‘specited.
1:18 Wneneverspecifiod onthe datasheets, inatnments must mest NACE MR-175 requirements
1.19 At wetted parts to bo 316 SS.
a
=
way Vena Ener estos Cap. Alcoomens of ts oan anak eps tee cpa ot Vert Enghaess Feematonal Co.PRESSURE DiFERENTAC TRANSMITTERS” [GREET To ——
TLECTROM SPEC HO TREY
Nosy bare [REVISION] st a
npn twee [puncmse] comRacT DATE
VENIET To Se ieee mew eeeaso [tyzon
7 — {Se ea evo nee
5 {Sart | eviston| 669.0051. 008
oY TRF
sip ay |
Tananed | | Gato | wows | Bonar
utvatSpan| rua | range” | Seae | Pres | Design
roanumer |"eres | 86 | onto, | name | kere | rene santo notes
maoorton | caus [oasmin| 257 | esc [oesurunzeoreco
wooorraa | ceseo | 05° [eae | 7re [evan oFrens 7
B200-FT-0314 - 0-2540 |o25 mim} 13:36 66°C STRIPPER REFLUX 4
weoortae | - ozo [oamiw| 21@ | 70 StasuuzeR ree “
wecortaszs | caso | SS [vase | ore _smupvenomans
er aT DESPRE
peooroaos | ae | S| SAS | wrcon | vas | cove EUROTDESUCFUR i
sxooiracor | me fosse| 77 T oroom | roa | zee [ever best 2A
; a =e Re OAT
sera [we [oslo | ore [4 [ ase ectner 2A
saooracce | er | SZ] 8° | orcom | tas | aise [Bae STRIPPER Ba
szeororoaee | Dakgone [oargen’| 188 | eso [OFF 3
NOTES: 1, THESE TAGS REQUIRE THREADED REMOTE SEALS WI3} CAPILLARY ON HIGH SIDE & 9 CAPILLARY ON LOW SIDE.
2. THESE TAGS REQUIRE THREADED REMOTE SEALS W/’' CAPILLARY ON HIGH SIDE & 8' CAPILLARY ON LOW SIDE,
5, THESE TAGS REQUIRE THREADED REMOTE SEALS W8' CAPILLARY ON HIGH SIDE & § CAPILLARY ON LOW SIDE,
4. THESE TAGS REQUIRE WETTED PARTS TO MEET NACE MR-O1-75 REQUIRMENTS
t‘PRESSURE DIFFERENTIAL TRANSMITTERS: | SHEET 3 OF 5
ELECTRONIC ‘SPEC. NO, REV
NO, BY_| DATE [REVISION] Lostic | 3
° SIE PURCHASE] CONTRACT | DATE
i Su [73012070 | REVISION] 4053-030, 11132041
3/2 | 172ara9r0 REVISION] REG
2 SUP | 11132011 | REVISION | 4859-030-0511-008,
ey APPR.
sup.
‘Assumed Galtraton | Meter | Design
Level Span] Fhid | Range | Scala | Press. | Design
xarcwe | Temp..c sonics NOTES.
Tagumber | retes) | 6. | um20) | Range.
|
|
[ress | src [roctorsens TosHn
|
sooorroane| | - | eas | Sa
wanrrome] | - | eave | O82 | om | eo frecwansroanen
wonrtome] - | - | camo | S82 | em | eo [rmtcwansroanon
‘B200-FE6308 - - | 4 2 ah Delete
oa RSE OFERSTOST
BOO FTA055 ~ [vee | [we | wo SS
ccoorton| - | - | vase [ozomon| 2 | evo [SUSUBRUQUDTORT-
; ase SOS STRSTR
soot] ae [owe] C22 | ovoom | moa | ove SRST
i
|
|
NOTES: + THESE TAGS REQUIRE THREADED REMOTE SEALS & 20" CAPILLARY (high & lw side)
2. THESE TAGS REQUIRE THREADED REMOTE SEALS Wi 10’ capillary on low side & 40’ capilary on high sie.
3. THESE TAGS REQUIRE THREADED REMOTE SEALS WY 30'cepilary on high side & 40" capillary on low side.
4. THESE TAGS REQUIRE WETTED PARTS TO MEET NACE MR-01-73 REQUIRMENTS
5 DELETE:
6. THESE TAGS REQUIRE SIL-2 RATING FOR SHUTDOWN PURPOSES,