Professional Documents
Culture Documents
4
5 There are two dp transmitters(Tx) namely DPT1 & DPT2 to get Furnace to WB dp.Any one of the Tx is selected for co
If deviation between two Tx are higher than a preset value an annunciation will appear & control will go to manual.
6
Actual damper position is just the reverse of the power cylinder
7 in case ofie.dp>240
position mmwcl,
If power theiscontrol
cylinder will godamper
fully closed, to mannual
is fully open & POST PURGE TRIP
8 vice versa. • All aux. air dampers modula
• All PA fans off.
After 5 minute counting perio
expires, the “Post Purge Fan Tr
memory is set, if
very high or very low furnace
pressure exists, the post purge
trip command is
issued (for tripping FD&ID fan
. When any LO valve is op
DFHFHGF
Mills & As sgdfdfdfdf fff
• Five Mill operation did not result in loss of
HJGH draught margins observed in Tri sector air
heater based units.
• Auxiliary Power consumption of fans was on
lower side in spite of individual PA fans
dedicated for each mill.
• Mill capability has not been affected by
deterioration in Air temperature which occurs
with deterioration in AH performance.
• Mills need to be purged very often to avoid
increase of Mill pressure drop due to sand pi
ONTROL (i.e. ON LOGIC OVERRIDE) TO MAINTAIN THE DESIRED D.P. BETWEEN WIND BOX TO FURNACE.
JBKK
. VCGFNGFB CBBVC
LKL'
GHHG ;