Professional Documents
Culture Documents
Unit Overview
EER @ IEER @
Unit Function Tonnage Net Capacity @ AHRI System Power Elevation
AHRI AHRI
Digit 2 Digits 3,4,5 O O O O I
Dimensions
Installed Weight
Height Width Overall Length Footprint Length
O O O O O
Unit Features
Double-wall foam
injected panels
Panel (doors, base and roof)
with thermal
resistance of R-9
Unit Electrical
Unit Mounted Power
Power Supply/Circuit Voltage/Phase/Frequency SCCR Rating
Connection
Digit 44 Digit 8 Digit 45 Rules tied to digit 45
Condensing Section
Refrigeration System Digit 9 Refrigerant Charge Circuit 1 O
Compressor Count O Refrigerant Charge Circuit 2 O
Compressor Stages O Service Valves Digit 42
Unit Capacity Steps (%) O Design Ambient Temperature I
Condenser Coil Type O Ambient Control Digit 39
Condenser Coil Coating Digit 40 Condenser Fan Count O
Condenser Coil Face Area O Condenser Fan VFD Count O
Condenser Coil Rows O Condenser Fan Size O
Condenser Fan HP (each) O
Heating Section
Function Digit 2 Gas Heat Steady State Efficiency O
Heat Type & Capacity Digit 6 Output Heating Capacity (MBh) O
Heat Performance Digit 7 Output Heating Capacity w/ Fan (MBh) O
Stages or Turndown Ratio O Heating EAT (F) I
Gas Pipe Connection Size O Heating LAT (F) O
Min Gas Inlet Pressure (in WC) O Heating DT (F) O
Max Gas Inlet Pressure (in WC) O
COMcheck Inputs
Design Air Volume BHP at System
Fan ID Fan Type Fan Control
(CFM) Design Conditions
Supply Fan 1 Supply Digit 14 O O
Supply Fan 2 Supply Digit 14 O O
Max. Motor
Fan ID Maximum BHP Motor Nameplate HP Fan Efficiency
Nameplate HP
Supply Fan 1 O O (Digit 17 divided by 2) O O
Supply Fan 2 O O (Digit 17 divided by 2) O O
Expected Output
Method Proposed Max. Allowed
Motor Nameplate HP O O
Brake HP (BHP) - Recommended O O
Notes:
1. Trane recommends using Brake HP method for ASHRAE 90.1 compliance. Motor Nameplate HP method is not intended
for large multi-fan systems that are available in IntelliPak rooftop units.
2. Select pressure drop credit when applicable (Ex. unit has high efficiency filters or sound attenuation section)
3. Is the relief fan running when the supply is delivering its highest supply airflow rate (ex. at Fan System Design Condition)?
* If yes, input into COMcheck the relief fan airflow and BHP when it is operating at the Fan System Design Condition.
* If not, do not input the relief fan into the COMcheck calculation.
4. Applies to fans internal to the unit only. Other fans in the system must be accounted for separately.
5. IntelliPak relief fans are EC motors. COMcheck will only give maximum nameplate Hp requirements for integral horsepower motors.
To check for compliance with ASHRAE 90.1-2016, use two available nameplate motors per fan (6 Hp and 8 Hp).
Filter Status I
Acoustics
63 125 250 500 1K 2K 4K 8K
Supply Duct
Return Duct Outputs
Outdoor Noise
Weights
Total Installed Weight O Installed Point Load Weight 1 O
Installed Point Load Weight 2 O
Unit Configuration Selection 1 piece Installed Point Load Weight 3 O
Installed Point Load X1 Location O Installed Point Load Weight 4 O
Installed Point Load X2 Location O Installed Point Load Weight 5 O
Installed Point Load X3 Location O Installed Point Load Weight 6 O
Installed Point Load X4 Location O Installed Point Load Weight 7 O
Installed Point Load X5 Location O Installed Point Load Weight 8 O
Installed Point Load Weight 9 O
Installed Point Load Weight 10 O
Controls
Communication Protocol Digit 46 Power Monitor Digit 47
Unit Tag From Lynx or TOPSS Controls Expansion Hardware Digit 48
Address I Rapid Restart Digit 49
Baud Rate I Ventilation Override Mode Digit 23
AHRI Certification
Packaged Rooftop units cooling, heating capacities and efficiencies are rated within the scope of the Air-Conditioning, Heating &
Refrigeration Institute (AHRI) Certification Program and display the AHRI Certified® mark as a visual confirmation of conformance to the
certification sections of AHRI Standard 340-360 (I-P) and ANSIZ21.47 and 10 CFR Part 431 pertaining to Commercial Warm Air Furnaces.
Certified units may be found in the AHRI directory at www.ahridirectory.org
Warranty
Unit/Parts I
Compressor I
Heat Exchanger I