Professional Documents
Culture Documents
Replacing sub-
sub-frame bushings
Special tools: 999 5457
Note! Cars with SRS. When replacing any of the
rear bushings in the sub-
sub-frame the following
applies;
Turn the steering wheel so that the steering shaft
joint is in the position as illustrated in paragraph
Release the steering wheel lock . Lock the
steering wheel by removing the ignition key. The
steering wheel should not be moved after this.
Tool 999 5457 consists of:
Counterhold (1), Threaded plate (2), Cutting
sleeve (3), Drift (4), Spacer sleeve (5), Screw and
nut (6).
Caution! The front left bushing is slightly oval in
the hole. It cannot be used on the front right
hand side.
Front
Note! The bushings must be changed one at a
time.
Raise the car
underneath.
Remove counterhold.
Install threaded plate (2), spacer (5) and screw
(6)
Installing bushing
Position the counterhold on the upper side of the
frame (not illustrated)
Rear
Caution! The bushings must be changed one at a
time.
Remove the screw for upper engine torque rod
Remove anti-
anti-roll bar link from anti-
anti-roll bar
Remove:
without SRS: .