Professional Documents
Culture Documents
General Petroleum Company Exam PDF
General Petroleum Company Exam PDF
1
A large scale map shows greater detail because the scale is a
larger fraction than a small scale map.
Large scale maps have a scale of 1:50,000 or greater (1:24,000,
1:10,000, ...).Maps with scales from 1:50,000 to 1:250,000 are
considered intermediate.Small scale maps are those with scales
smaller than 1:250,000. A map of the world that fits on two
pages of letter sized paper would be very small scale with a
scale of around 1:100,00,000.
Here are 3 views of the same location on maps with different
scales:
2
3- Draw the following in a simplified form:
- Gulf of Suez Stratigraphic Column.
- Western Desert Stratigraphic Column.
- Nile Delta Stratigraphic Column.
3
4- Give a brief note about:
- Lag Time
.It is the time between a chip being cut by the bit and the time
it reaches to the surface where it is then examined by the
wellsite geologist or mudlogger.
• The time taken for cuttings sample to reach the surface. The
term is also used in place of cycle time.
- Mud Circulation
4
it is the center of quick and comprehensive interpretation and
evaluation of oil and gas on well-site. The system can discover
and evaluate oil and gas reservoirs quickly, monitor drilling
engineering parameters and toxic gases such as H2S and CO2,
thus to ensure drilling safety, enhance drilling efficiency and
reduce operation cost. The mud logging unit has served in
domestic oilfields.
5
3- What is the daily oil production of Egypt?
a) About 100,000 bbls/day
b) About 250,000 bbls/day
c) About 550,000 bbls/day
d) About 1000,000 bbls/day
4- What is the current approximate price of one barrel oil?
a) US $70.
b) US $90.
c) About US $110.
d) US $50.
5- Shoaab Ali oil Field present: in
a) Western Desert.
b) Nile Delta.
c) Gulf of Suez.
6- Most of the gold mines in Egypt exist in
a) Western Desert.
b) Eastern Desert.
c) Sinai.
7-Which Oasis has iron ore?
a) El Kharga Oasis.
b) El Bahariya Oasis.
c) Siwa Oasis.
d) Farafra Oasis.
8- Where is the known phosphate mining in Egypt?
a) Edfo.
b) Ras El Dip.
c) Abu Tartoor.
d) Badracheen.
9- Where is the oil shale Present in Egypt?
a) Ras Shukeir.
b) Gebel El Zeit.
c) Abu Tartoor Plateau.
d) Alexandria.
10- Nearly the whole land surface of earth was covered by huge
sheet of ice during
6
a) Cambrian.
b) Precambrian.
c) Cretaceous.
d) Pleistocene.
e) Jurassic.
11- The Dead Sea is located in
a) Rift valley.
b) Canyon.
c) Between chains of mountains.
d) Intermountain plain.
12- The age of economic coal bearing rocks in Egypt is
a) Cretaceous.
b) Carboniferous.
c) Triassic.
d) Jurassic.
13- First vertebrates (Fishes) appeared in
a) Paleocene.
b) Devonian.
c) Ordovician.
d) Cambrian.
14- Outcrop of strata shown in geological map as parallel
contours indicates
a) Horizontal Strata.
b) Vertical Strata.
c) Inclined Strata.
d) Strata inclined 45°.
15- On a map, which of the following scales is considered the
largest
a) 1:100,000.
b) 1:50,000.
c) 1:10,000.
d) 1:200,000.
16- The Tethys sea evaporated completely during
a) Eocene.
b) Middle Miocene.
7
c) Pliocene.
d) Oligocene.
17- In which period the Red Sea was opened?
a) Eocene.
b) Tertiary.
c) Mesozoic.
d) Proterozoic.
18- Time rock units are defined as
a) Lithologic characteristics.
b) Lithologic characteristics and time boundaries.
c) Lithologic characteristics and fossil content.
d) Lithologic characteristics and index fossils.
19- Syrian arc structures in Egypt date back to
a) Paleozoic time.
b) Miocene time.
c) Cretaceous.
d) Jurassic time.
20- Strike slip movement shows
a) Right Lateral.
b) Left Lateral.
c) Clock wise.
d) Anti clock wise.
21- Cross beds are produced when
a) The Flow direction of current changes gradually.
b) The Flow direction of current changes suddenly.
c) Velocity of current decrease suddenly.
d) Ripples migrate from one place to another.
22- Arrange the following environmental zones sea-ward
a) Bathyal.
b) Neritic.
c) Abyssal.
d) Littoral.
8
23- What type of log do we use for porosity calculation?
a) Density / Neutron.
b) Resistivity.
c) Gamma Ray.
24- What type of log do we use for Lithology identification?
a) Microspherical.
b) Density.
c) Caliper.
25- How can we differentiate between heavy and light oil
response on resistivity curves?
a) Deep & Shallow readings are the same.
b) Separation between Deep & Shallow readings in good
permeable reservoirs.
c) We can't differentiate.
26- Caliper log helps to determine
a) Oil zones.
b) Hole size.
c) Hole inclination.
9
27- Dipmeter tool measures
a) Oil bearing reservoirs.
b) Bed dips.
c) TWT.
28- We measure shaliness (VSH) from
a) VSP.
b) Sonic.
c) GR.
29- Resistivity is inversely proportional to
a) Tightness.
b) Oil presence.
c) Formation water salinity.
30- Petrophysical Computation is performed on
a) Any data.
b) Raw data.
c) Data after Environmental Correction
10
The thickness of mudcake is also a critical factor in many drilling
and reservoir engineering problems. Muds producing soft and
thick cakes increase the potential of differential sticking and
thus are not desirable for geological formations highly prone to
differential sticking (Amanullah and Tan1). Mud related
borehole problems such as tight hole, differential sticking,
torque and drag usually have their root to the static phase of
drilling and hence static mudcake thickness is a valuable piece
of information in selecting a mud system. In addition, fluid loss
and cake building properties of a mud system play an important
role in making a logging programme successful. The decrease in
effective hole size with increasing mudcake thickness makes
the openhole logging more and more difficult. According to
Dewan and Chenevert2, predictions of logging simulators have
been hampered by a lack of knowledge of mud cake flow
resistance, thickness, permeability and their variation with
time.
11
• Rt: observed bulk resistivity
• a: a constant (often taken to be 1)
• m: cementation factor (varies around 2)
• n: saturation exponent (generally 2)
12