Professional Documents
Culture Documents
1) Must be logged into WINDOWS with a USER ACCOUNT that has ADMINISTRATIVE
PRIVELAGES prior to installing software.
2) Verify Windows Version: Requires Windows XP or later.
3) Run Windows Update – Insure PC has the latest drivers and operating system updates.
4) Do not connect controller until all software is completely installed.
5) The controller must be ON and in STOP MODE before making configuration changes.
Go to www.deepseaplc.com
Click Register in the upper right hand corner if not already registered.
Click Product Software link at the bottom of the page under the SUPPORT section.
Software Installation:
Deep Sea Configuration Suite Installer link can be found on the Controller Product Page by clicking
on PC Software . EX. DSE-7310 MKII Product Page
Installation Notes:
1. Microsoft .NET 4.0 Framework”: Most Windows PC’s already have this installed, either from
the factory or through Windows Updates. It’s required for Deep Sea Config Suite software to
work correctly. Check with your IT department or search the internet for “How to determine
.Net version” if you are in question.
2. DSE Configuration Suite Software Installer. (see picture above): Download and extract
the.zip file. Open the folder that the file was extracted to. Right click on the configuration-suite-
installer.exe file and click “Run as Administrator”. This helps insure you are installing with
admin privileges.
**64 bit versions of Windows require digitally signed drivers. Generally clicking “Allow”
as stated above is sufficient. It is possible to disable that requirement temporarily to
help insure correct installation or if re-installing due to a problem installation.
The method varies by Windows version. Check with your IT department or search
Windows Help for “Disable Driver Signature Enforcement” if needed.
SEE FOLLOWING PAGES FOR INSTALL SCREEN CAPTURES
A full guide “DSE Configuration Suite PC Software Installation & Operation Manual” Document
057-151 can be found on Deep Sea’s Website.