SERVICE DATA
FILE NO. 050-365
28-SYSTEM
-TOSHIBA
COLOUR TELEVISION
2806XH
SPECIFICATIONS
Input Power Rating:
[eral Input Impedance
Receiving Channels:
Intermediate Frequencies:
Picture Tube:
‘Sound Output
Speakers:
Dimensions
Specifications are subject to change without notice.
143 watts (nominal, AC 110~248 vols, $0/ 60 He
75.0nm unbalanced type VHF and UME
PALB/ G, SECAMB /'G system
alee
cata Par
BERS sccamers E befie ow
fae
Niscm
Peture LF earrerfequency deomne
Sound -F carrie trequency 335/925 /220/ 21.5 Mme
28 inches, ASSKHPSEX {66 cm measured on clagonal of viewable picture areal,
Ho" Beliecton
Main: 7.0 watts x2
Main: 70mm x 130 mm 2 pes
Height s19mm
Death 523mm
375g
Cieamness tube, VIDEO and AUDIO input/output terminals, S-VIDEO input terminal,
SSvtoumd aura system, OM umer, Remote Contra!
Printed in Japan Nov. 1990 (SBSAFETY INSTRUCTIONS
WARNING. BEFORE SERVICING THIS CHASSIS, READ THE "X-RAY RADIATION PRECAUTION™ , "SAFETY
PRECAUTION” ANO "PRODUCT SAFETY NOTICE” DESCRIBED BELOW.
X-RAY RADIATION PRECAUTION
1. Excessive high voltage can produce potentially 2. The only source of X-RAY RADIATION in this TV
hazardous X-RAY RADIATION. To avoid such receiver is the picture tube. For continued X-RAY
hazards. the high vollage must not be above the RADIATION protection, the replacement tube must
specified limit, The nominal value of the high bbe exactly the same type tube as specified in the
voltage of this receiver is 30.4kV at zero beam paris list.
current (minimum baghiness) under 110 ~ 245V 3. Some parts in this receiver have special salely-
‘AC power source. The high voltage must not, related characteristics lor X-RAY RADIATION
under any circumsiances, exceed 32kV. protection. For continued safety, paris replacement
Each time a receiver requires servicing, the high should be undertaken only alter relerring to the
voltage should be checked following the HIGH PRODUCT SAFETY NOTICE below.
VOLTAGE CHECK procedure in this manual, itis
recommended the reading of the high voltage be
recorded as a part of the service record. It is
important to use an accurate and reliable high
voltage meter.
SAFETY PRECAUTION
1, Potentials as high as 27KV are prasent when this receiver is operating. Operation of the receiver outside the
Cabinet or with Back board removed involves a shock hazard from the receiver.
1. Servicing should not be attempted by anyone who is not thoroughly familiar with the precautions necessary
when working on high-vollage equipment.
2. Alway discharge the picture tube anode to the receiver chassis lo keep olf the shock hazard belore removing
the anode cap.
3. Perlectly discharge the high potential of he picture tube belore handling the tube. The picture tube is highly
evacuated and if broken, glass lragments will be violently expelled
It any Fuse in this TV receiver is blown, replace it with the Fuse specified in the chassis parts list,
When replacing paris or circuit boards, wind the lead wires around terminals belore soldering,
When replacing a high wattage resistor (oxide metal film resistor) in cifcuil board, keep the resisior 10mm away
from circuit board.
5, Keep wires away Irom high voltage or high temperature components.
6, This receiver can be operated usder AC 110 ~ 245 volts, SO/60H2. NEVER connect to DC supply or any other
power
PRODUCT SAFETY NOTICE
‘Many electrical and mechanical parts in this chassis have special salely-related characteristics. These
Characteristics are often passed unnoliced by a visual inspection and the X-RAY RADIATION protection allorded
by them cannot necessarily be obiained by using replacement components rated for higher voltage, wattage.
elc. Replacement parts which have these special salety characteristics are identilied in this manuat and ils,
supplements, electrical components having such features are identilied by the international hazard symbols on
tne schematic diagram and the pars lst
Belore replacing any o these components, read the parts list in this manual carefully. The use of substitute
replacement parts which do not have the same salety characteristics as specified in the parts list may create
X-RAY RADIATION.LOCATION OF CONTROLS
FRONT
CHANNEL POSITION INDICATION
(0 To 23),
COLOUR SYSTEM INDICATION
ANALOGUE INDICATION (UP/DOWN-15 STEPS)
‘@coLour 2 VOLUME
‘OcoNTRAST > eass
OBRIGHT 4 TREBLE
eaTINT 4 BALANCE
OFF TIMER INDICATOR (Green)
SURROUND INDICATOR (Yellow)
POWER INDICATOR (Red)
MAIN ON/OFF SWITCH
PUSH HERE
TO OPEN THE OOOR
mi BACK
t
VIDEO INPUT
Tv OUTPUT
Ls.vipeo INPUT SOCKET
EXTERNAL SPEAKER TERMINAL
AERIAL SOCKET
SURROUND SPEAKER SW