Professional Documents
Culture Documents
Method Statement For GD TOLERENCE
Method Statement For GD TOLERENCE
BHD
1.0 Purpose
To achieve the PIN center point at both site at the desired center. This is to ensure the
turning process at CNC works base on the same center point at both side.
Center point
Process 1
Process 2
- CNC follows the M.Lathe CP to turning one side & Set a new CP at another site before
turning another side.
3.1. When the Center Point marked by at different process there are possibilities of
mismatch of center point at both site. This will lead to uneven turning and effect the surface
OD.
4.2. CNC shall follow the true center point as a turning reference for both site.
-Add another process after cnc turning to ensure the roundness and straightness is in within
the tolerance before goes to Hardening.
- The add on process will be Circular & Straightness Measurement. The process is add on, to
check the run out and straightness of the part after cnc 1st machining. The selection of that
process is to ensure the operation of turning is perfectly made with true center.