Professional Documents
Culture Documents
Oscilloscope
Mexe-3201
sreatop@yahoo.com
Abstract
The main objective of this session was to understand and become familiar with
the use of two devices: the oscilloscope and the function generator. To do this, a set of signals
were configured in both devices to see how it was reproduced. The signal generator substituted
the mains as source to be able to reproduce waveforms and finally the modes of operation of the
oscilloscope were tested.
Objectives
Introduction
-What is an oscilloscope?
The main objective of this session
was to learn how to use an oscilloscope. An -Draw and identify the parts of an
oscilloscope is a device used to analyze oscilloscope. Label each part with their
waves, which are introduced in the device
functions.
through a cable. The oscilloscope used can
analyze up to 2 waves, each inputted via two -What are the different kinds of
channels, and afterwards displayed in the alternating waves? Familiarize yourself.
screen. As it can be seen, the oscilloscope
has two input channels, a green phosphorus Materials and Method
screen, and several knobs. The most used
knobs are the voltage division and time -Oscilloscope
division knobs. They control the y and x
axis of the graph, respectively.
-Function Generator 2. Turn on the function Generator and
Oscilloscope.
Turning up
Turning down
When you turn the frequency control
Tuning down
Turning up
Reference:
https://www.coursehero.com/file/7082436/L
ab-1/
Information:
Age:22
Born: August 11,1996