Section VII
Technical SpecificationsTECHNICAL SPECIFICATIONS
PART 1
TS-1.0 PROJECT HIGHLIGHTS
TS- 1.1 GENERAL
This project provides the governor system of Agus 7 Hydroelectric Power Plant
generating unit no. 1 with an upgraded governor controller that shall improve its
efficiency and enhance the quality of performance.
TS- 1.2 PROJECT LOCATION
The project is located in Agus 7 Hydroelectric Power Plant, Fuentes, Maria Cristina,
lligan City.
TS- 1.3 SCOPE OF WORK
The works and services to be performed by the Contractor for this undertaking shall
essentially consist of, but not limited to the following
Supply and delivery of all items and materials needed for the project;
Removal of old equipment:
Installation works;
Testing and commissioning works; and
Technology Transfer — intensive training on the operation and maintenance of
the system, and programming/system tuning and diagnostic tool/software.
eeaoc8
TS- 1.4 CONTRACT PERIOD
The contractor shall complete the works within one hundred twenty (120) calendar
days. The contract period shall be reckoned from the date of contract effectivity as
specified in the Notice to Proceed
TS-1.5 CODES AND STANDARDS
The Supplier shall bear full responsibility that the material has been designed and
fabricated in accordance with all codes, standards, and applicable governmental
regulations and performs under the conditions and to the standards specified herein.
4. American National Standards Institute ANSI
2. Institute of Electrical & Electronic Engineers IEEE
3. American Society for Testing and Materials ASTM
4. National Electrical Manufacturers Association NEMA
5, Underwriters Laboratories, Inc. UL
6. Intemational Electro-Technical Commission lec
7, International Standards Organization 180
8. National Electric Code NEC
9. National Electrical Safety Code NESC
10. Philippine Electrical Code PEC
68These codes and standards set forth the minimum requirements which may be
exceeded by the Supplier, if, in the Supplier's judgment and with NPC's acceptance,
superior or more economical.
TS-1.6 WORKMANSHIP
a. General
Workmanship shall be of first-class quality and in accordance with the best
modern engineering practice for the manufacture, assembly, installation.
testing and commissioning of governor controller for hydroelectric power plant
governor system. All on-site inspection, installation, wiring and setting works
must be performed by qualified technical personnel
TS- 1.7 SPECIFICATIONS
This specification covers the features and technical requirements for the supply,
delivery, installation, testing and commissioning of governor controller for Agus 7
Hydroelectric Power Plant governor system.
Handle, ship, and store material in a manner that will prevent distortion or other
damage. Store material in a clean and properly drained location and out of contact
with the ground. Replace all damaged material with new material or repair the
damaged material in an approved manner at no additional cost to the NPC.
TS- 1.9 DATA AND DOCUMENTATION REQUIREMENTS
Bidders’ furnished data and information shall be the guaranteed performance data,
predicted performance, interface requirements and construction features of the
equipment to be furnished. The accuracy of such information and its compatibility
with overall performance requirements specified by NPC are the sole responsibility
of the Supplier.
All information submitted as part of proposal Data will become part of the contract
data for successful bidder. Any deviation from such requires NPC's approval.
The Supplier shall furnish with his proposal the following
a. Completely Filled-out Technical Data Sheets;
b. Original copy of the brochure in full color or original CD of the manufacturer. If
this is not available, downloaded brochures will be allowed, but the original
copy of the brochure will still be submitted during post-qualification.
c. Site Inspection Certificate to be signed by NPC's authorized plant personnel.
Suppliers representative who shall conduct on-site inspection shall be
technically knowledgeable on this project, and
Work Plan/Schedule (Bar Chart) that include manpower requirements
BIR Tax Clearance Certificate that is valid as of date of the bid opening
oa