Professional Documents
Culture Documents
COM
Chevrolet Venture 2001
Installation type: Remote start / security / GPS
Wire/Function Colour Location / Description Polarity
PASSIVE ANTI-THEFT YES TRANSPONDER - PASSKEY III SEE NOTES
12 VOLTS Red Ignition harness +
IGNITION Pink Ignition harness +
IGNITION 2 White Ignition harness +
ACCESSORY Orange Ignition harness +
STARTER Yellow Ignition harness +
TACH White At ignition control module* AC
FUEL INJECTOR Opposite from Pink At any injector on engine AC
LOCK Blue In driver's kickpanel** -
UNLOCK White In driver's kickpanel** -
DRIVER LOCK MOTOR Gray In driver's kickpanel +
DRIVER UNLOCK MOTOR Tan In driver's kickpanel +
PASSENGER UNLOCK MOTOR Tan In passenger kickpanel +
DOORPIN Gray/black At Body Control Module*** -
TRUNK PIN Orange At Body Control Module*** -
LEFT SLIDING DOOR CONTROL Blue At switch in roof console assembly**** -
RIGHT SLIDING DOOR CONTROL Blue At switch in roof console assembly**** -
SUN ROOF OPEN Dk.blue At sun roof module***** REV POL
SUN ROOF CLOSE Dk.green At sun roof module***** REV POL
FACTORY ARM Red/black In driver's kickpanel** -
FACTORY DISARM Orange/black In driver's kickpanel** -
BRAKESWITCH White At switch above brake pedal +
PARKLIGHTS Brown In driver's kickpanel +
HAND BRAKE Lt.blue On park brake bracket -
HORN Black At steering column harness****** -
DRIVER WINDOW UP Dk.blue At switch in driver's door REV POL
DRIVER WINDOW DOWN Brown At switch in driver's door REV POL
PASSENGER WINDOW UP Blue or Blue/white At switch in driver's door REV POL
PASSENGER WINDOW DOWN Tan At switch in driver's door REV POL
HEADLIGHTS Yellow At light switch harness +
REVERSE LIGHTS Lt.green At steering column harness +
DIMMER Gray At dimmer switch harness +
VSS WIRE Dk.green At Body Control Module*** 8000ppm
KEY SENSE Lt.green At steering column harness****** -
Vehicle note: PLEASE NOTE: This vehicle is equipped with GM's PASSKEY III immobilizer. See our SECURITY diagram before installing any
remote start product.
* The ignition Control module is located at the back of the engine and is difficult to access. You can find the WHITE wire in the large
loom passing over the top of the engine. See the exploded view.
** These wires can also be found at the BCM. If you are using the factory security wires (red/black & orange/black) you do not need to
Note: The information on this sheet is provided to you on an as is basis with no representation or warranty of accuracy whatsoever. It is the sole responsibility of the installer to check and verify any circuit
before connecting to it. Only a computer safe logic probe or digital multimeter should be used. Wiremagic.com Corporation and/or any associated or unassociated individual or corporation who furnishes this
document and/or software assumes absolutely no liability or responsibility whatsoever pertaining to the accuracy or currency of the information supplied. The installation in each and every case is the sole
responsibility of the installer performing the work and Wiremagic.com Corporation and/or any associated or unassociated individual or corporation assumes no liability or responsibility whatsoever resulting
from any type of installation, whether performed properly, improperly, or in any other way. The information supplied is a guide only. © Copyright 1998-2001 Wiremagic.com Corporation. All rights reserved.
Note: The information on this sheet is provided to you on an as is basis with no representation or warranty of accuracy whatsoever. It is the sole responsibility of the installer to check and verify any circuit
before connecting to it. Only a computer safe logic probe or digital multimeter should be used. Wiremagic.com Corporation and/or any associated or unassociated individual or corporation who furnishes this
document and/or software assumes absolutely no liability or responsibility whatsoever pertaining to the accuracy or currency of the information supplied. The installation in each and every case is the sole
responsibility of the installer performing the work and Wiremagic.com Corporation and/or any associated or unassociated individual or corporation assumes no liability or responsibility whatsoever resulting
from any type of installation, whether performed properly, improperly, or in any other way. The information supplied is a guide only. © Copyright 1998-2001 Wiremagic.com Corporation. All rights reserved.