Professional Documents
Culture Documents
SQR General Assembly Steps
SQR General Assembly Steps
20142017
24” X 48” Super Quad Roll Crusher
2
Install Movable Rolls
• Remove corrosion
protection
• Wear plate
• Bearing Housing
• Toggle/Connecting
Bar Pins
• Install secondary stage roll
assembly
• Align Connecting
Bar and install pin
• Align Toggle
Spacer and install
pin
• Install primary stage roll
assembly
• Align Connecting
Bar and install pin
• Align Toggle
Spacer and install
pin
• Tension toggle springs
Tools Required: Snap‐Ring Pliers, Large Adjustable Wrench for Spring Rod Nuts
3
Install Movable Roll Cutouts
• Install cutouts
• Drilled and tapped
holes go towards
the stationary roll
(for dust covers)
Tools Required: Wrenches for bolted connections
4
Install Movable Roll Slide Plates
• Orient slide plates per the
roll shaft assembly
drawings
Tools Required: Wrenches for bolted connections
5
Install Side Liners
Tools Required: Wrenches for bolted connections
6
Install Stationary Rolls
Tools Required: Wrenches for bolted connections
7
Install Tie Bars
• Remove corrosion
protection
• Tye Bar
Tools Required: Wrenches for bolted connections
8
Install Stationary Roll Cutouts
Tools Required: Wrenches for bolted connections
9
Install Stationary Roll Seal Plates
• Adjust seal plates so they
are not contacting the roll
shaft
Tools Required: Wrenches for bolted connections
10
Install Roll Scrapers
• Remove the Roll Scraper
installed and replace with
the new one with the
parts that were shipped.
The new one goes on the
top of the Frame not
underneath. Adjust the
new Roll Scraper so that it
does not contact the Roll
teeth when the Moving
Roll is fully open in a
tramp event.
Tools Required: Wrenches for bolted connections
11
Install Bottom End Plate
Tools Required: Wrenches for bolted connections
12
Install Top End Plate
Tools Required: Wrenches for bolted connections
13
Install Interstage Assemblies
• Remove corrosion
protection
• Shafts
• Bore of interstage
drive pulleys
• Keys
• Pulley grooves
Tools Required: Wrenches for bolted connections, Torque wrench for locking assembly
14
Install Flywheels
• Remove corrosion
protection
• Shafts
• Bore of interstage
flywheels
• Keys
• Flywheel grooves
Tools Required: Torque wrench for locking assembly
15
Install Guards
Tools Required: Wrenches for bolted connections
16