Professional Documents
Culture Documents
Trends of CEBoard-Exam PDF
Trends of CEBoard-Exam PDF
REVIEW CENTER 1
BOARD SUBJECTS
in
CIVIL ENGINEERING
2
A.) Mathematics - 35% (8:00 am - 1:00 pm)
1. Algebra
2. Geometry
3. Plane and Spherical Trigonometry
4. Analytic Geometry
5. Differential Calculus
6. Integral Calculus
7. Engineering Economics
8. Plane and Higher Surveying
9. Curves and Earthworks
10. Transportation Engineering
11. Engineering Mechanics
12. Vectors
3
B.) Hydraulics and Geotechnical
Engineering - 30% (2:00 pm - 6:00 pm
pm))
1. Properties of Fluids
2. Measurements of Pressure
3. Hydrostatic Forces on Plane
and Curve Surfaces
4. Buoyancy
5. Rotating Vessels
6. Bernoulli’s Energy Equation
7. Viscosity of Liquids
8. Pipes Series and Parallel
9. 3 Reservoir Problems
10. Water Hammer
4
Continue…
11. Orifice
12. Open Channels (Uniform Flow)
13. Open Channels (Non-
(Non-Uniform Flow)
14. Hydrodynamics
15. Water supply
5
Geotechnical Engineering:
1. Soil Composition
2. Atterberg Limits
3. Classification of Soils
4. Soil Compaction
5. Permeability or Hydraulic Conductivity
6. Effective Stresses in Soils
7. Seepage in Soils
8. Compressibility of Soils
9. Shear Strength of Soils (Direct Shear Tests)
10. Shear Strength of Soils (Tri-
(Tri-Axial Shear Test)
11. Rankines Theory of Active and Passive Pressure
12. Coulombs Theory of Active and Passive Pressure
13. Anchored bulkhead
14. Terzaghis General Bearing Capacity Theory
15. Stability of Slopes
6
16. Braced Sheetings
Continue…
7
C.) Structural Design - 35%
(8:00 am - 1:00 pm)
1. Engineering Mechanics
2. Strength of Materials
3. Theory of Structures
4. Timber Design
5. Concrete Design
6. Steel Design
7. Earthquake Analysis
8
HOW TO APPLY FOR THE EXAM
STEP 1. Secure Online
Online Application System from the PRC website
www.prc.gov.ph make sure you have an updated CEDULA
before filling out form.
STEP 2. Accomplish one page-
page-application form by filling out all the blank
fields in the application form. Fields marked with a red asterisk (*( *)
are required. Submission will not be successful until all required
fields are properly accomplished.
STEP 3. When the encoding is completed, click the save button, and then
OK. A notification message will appear on the screen confirming
that you have successfully submitted your application. A similar
notification will be sent to your email ( if you provided your email
address).
STEP 4. Proceed to the nearest PRC Office and present all the
documentary requirements for assessment, payment of
prescribed fees and issuance of Notice of Admission (NOA)9
BEFORE the deadline for application.
DOCUMENTARY REQUIREMENTS:
• Original and photocopies of Transcript of Records with Special Order and
Date of Graduation, and with scanned pictures with remark “ FOR BOARD
EXAMINATION PURPOSES ONLY”. Graduates of government schools
and institutions/programs accredited by recognized accredited agencies
under the FAAP are exempted from SO. Graduates of new Schools/Degree
Programs must submit School Recognition and/or Permit to operate.
• Original and photocopies of NSO-
NSO-Issued Birth Certificate (if NSO is not
clear, bring copy from the Local Civil Registrar)
• For Married Females, original and photocopies of NSO-
NSO-Issued Marriage
Contract (if NSO is not clear, bring copy from the Local Civil Registrar)
• Two (2) passport-
passport-size colored pictures with white background and complete
nametag.
• Current Community Tax Certificate (CEDULA)
(CEDULA)
• Other specific requirements as required by the Commission or the
Professional Regulatory Board.
NOTE::
NOTE Secure the following from the processor upon approval of your
application:
• Computerized Application Form (CAF)
• Permanent Examination and Registration Record card (PERRC)
(for first
first--timers
timers)) 10
• Notice of Admission (NOA)
STEP 5. Pay examination fee at any of the Cashier Windows. Get Official
Receipt.
• Baccalaureate Degree - P 900.00
• Non-
Non-Baccalaureate Degree - P 400.00
• Removal - P 300.00
STEP 6. Pay for metered documentary stamps and mailing envelope with
metered documentary stamps at the CSC.
STEP 7. Accomplish the CAF, PERRC, and NOA. Indicate the Official
Receipt number, date, and amount on the CAF.
STEP 8. Proceed to any of the Issuance Windows (Window 9, 10, 11, 12)
for final review of qualifications and documents and issuance of
NOA, Applicant’s Stub, Program of Examination, Examinee’s
Guide and Self-
Self-Instruction Sheet.
STEP 9. Keep the Notice of Admission, Official Receipt, and the Applicant’s
Stub. Bring these with you on the first day of the examination.
For further information, read the General Instructions at the back
page of the Notice of Admission, Program of Examination,
Examinee’s guide and Self-
Self-Instruction Sheet.
11
STEP 10. Bring your NOA when you verify with the PRC your school and
building assignment which will be posted at the PRC premises
two (2) three (3) working days before the examination date.
CIVIL ENGINEER
Your application for the ____________________________________ licensure examination has
been CONDITIONALLY APPROVED PENDING FINAL REVIEW AND VERIFICATION of your documents and
qualifications..
qualifications
You may also be allowed to take the examination, PROVIDED, that if later found out that you are
disqualified due to misrepresentations, submission of fraudulent/spurious documents, or discrepancies in
entries in the Transcript of Records and Birth Certificate, your examination shall be CANCELLED after
observance of due process.
process.
Your school/building assignment will be posted at the PRC Office premises one or two days
before the examination date.
date. Bring this Notice of Admission when you verify your school/building
assignment.. The Program of Examination will be available at the PRC Customer Service Center one
assignment 13 week
before the examination date.
date.
Please report to your officially assigned school/building/room before 6:30 a.m.
every examination day.
day. Present this NOTICE to the Security Officer at the entrance gate
or at the test center and to your Room Watcher for IDENTIFICATION.
IDENTIFICATION.
Please read the GENERAL INSTRUCTIONS at the back page.
page.
KEEP THIS NOTICE FOR FUTURE REFERENCE/CERTIFICATION.
Very truly yours,
By Authority of the Board:
16
PROHIBITED ACTS
1. Accepting or receiving anything, including food, from any person
while the examination is in progress
progress..
18
7. Bringing inside the examination rooms the following:
following: books, notes
notes,,
review materials and other printed materials containing principles
or excerpts thereof, coded data/information/formula which are
relevant to or connected with the examination subject,
programmable calculators, cellular phones, beepers, portable
personal computers or other similar gadgets / devices.
devices. The act
shall be considered cheating and/or act of dishonesty and shall
be a ground for the cancellation of your examination papers and
suspension of debarment from future licensure examinations.
examinations.
(PRC Resolution NoNo.. 463 dated November 27,
27, 1996
1996)).
20
DATE AND TIME SUBJECTS RELATIVE
WEIGHT
SAT.. NOV. 23, 2013
SAT
7:00 A.M.-
A.M.-7:45 A.M. General Instruction and filling up of forms
8:00 A.M.-
A.M.-1:00 P.M. MATHEMATICS, SURVEYING AND
TRANSPORTATION ENGINEERING
Algebra, plane and spherical trigonometry Analytics,
descriptive and solid geometry differential and integral
calculus, highway and railroad surveying, plane 35%
topographic and hydrographic surveying, advanced
surveying, design and construction of highways and
railroads, piers, ports and wharves.
wharves.
2:00 P.M. - 6:00 P.M. HYDRAULIC AND GEOTECHNICAL ENGINEERING
Aqueducts, sanitary engineering works, Hydrology,
water supply systems, dikes, Dams, irrigation and
drainage canals, soil mechanics and foundations 30%
SUN. NOV. 24, 2013
8:00 A.M.-
A.M.- 1:00 P.M. STRUCTURAL ENGINEERING AND CONSTRUCTION
Rational and applied mechanics, steel Timber and
35%
reinforced concrete structures 21
100%
THIS EXAMINATION WILL BE COMPUTERIZED
1. Your school/building assignments will be posted at the PRC premises two to three
working days before the examination.
examination. Bring your NOTICE OF ADMISSION when you
verify your school/building assignment.
assignment. Visit your school/building assignment prior to
the day of the examination.
examination.
2. Report to the school/building assignments before 6:30 a.m. on the first day of the
examination to verify your room and seat number
number.. Be punctual, late examinees will
not be admitted.
admitted. Examination fee of ABSENT examinees will be forfeited
forfeited..
3. Examinees are required to wear the following attire every examination day day::
Male examinees - White polo shirt of t-shirts with collar, tucked
tucked--in
Female examinees - White blouses or t-shirts with collar
collar..
4. Bring the following on the days of the examination:
examination:
a. Notice of Admission ((Note:
Note: Read the General Instruction at the back of the
Notice of Admission)
b. Official Receipt
c. One (1) piece metered stamped Window Mailing Envelope
d. Two or more pencils (No. 2)
e. Ballpen with BLACK INK only
f. One (1) piece Long Brown Envelope
g. One (1) piece Long Transparent (non-
(non-colored) plastic envelope (for keeping your
valuables and other allowed Items)
Items)
h. NON-
NON-PROGRAMMABLE CALCULATORS ( REFER TO LIST ON THE EXAMINEES 22
GUIDE ).
5. The following are prohibited inside the examination premises/rooms.
a. Books, notes, review materials, other printed materials containing coded data /
information/formula
b. PROGRAMMABLE CALCULATORS
c. CELLULAR PHONES, beepers, portable computers or similar gadgets / device
d. Bags or any kind (ladies bag, shoulder bags, attached case, backpacks, etc.)
e. Other examination aides not stated on this program shall not be brought inside
the examination building.
NOTE: PRC WILL NOT BE ANSWERABLE FOR PROHIBITED ITEMS THAT WILL BE LOST.
6. Read carefully and follow the instructions only your Notice of Admission and Examinees
Guide.
Manila, Philippines
April 03, 2012
APPROVED:
CERTIFIED CORRECT:
EXAMINEE'S SELF-
SELF-INSTRUCTION SHEET
The following are the instructions or procedures to be followed by the examinee. It is
understood that the Room Watchers/Proctors will only assist in the writing of
samples on the blackboard, distribution and collection of examination forms, test
question sets, refer clarifications on the test question to the Floor Supervisor and
ensure that the procedures are followed by the examinees. However, you may also
ask for clarification/assistance from the Room Watchers.
Upon receipt of this sheet, please read and do the following instructions:
Put a mark when done.
done.
1. Upon arrival in your assigned room:
room:
a) Place you bags, books, reviewers and other printed materials OUTSIDE
the room.
room. The Room Watchers shall not be held liable for lost items.
items.
b) Put your Notice of Admission, Application Stub, Official Receipt,
Cellular Phone (turned-
(turned-off) and other valuables inside your
transparent plastic envelope and place in FRONT of the room room.. All
food and bottled mineral water with their labels removed may be
placed in front of your seat.
seat. 24
2. Get your ID/AS sets from your Room Watcher.
Watcher. Go back to your seat and
do the following:
following:
a) Check if the serial numbers of the set are the same in all pages, if
not ask for replacement.
replacement.
b) Check if the PRC seal is intact, and number of pages are complete, if
not ask for replacement.
replacement. Ask for the number of pages from your Room
Watcher..
Watcher
3. FILLING-UP OF THE IDENTIFICATION (ID) SHEET
FILLING-
a) Read instruction printed on the ID sheet.
sheet. Refer to the NAMEGRID
sample printed on the blackboard and on the ID sheet.
sheet.
b) Start printing your name always on the first box using BLACK BALL
PEN and then mark the corresponding letters below with pencil (see
sample of markings on the board and ID sheet).
sheet).
c) Accomplish back portion of ID sheet, using black ball pen.
pen. Fill
Fill--in all
boxes..
boxes
4. DETACHING OF ANSWER SHEET
a) On your brown envelope print your name on the upper left hand
corner.. Print your seat number on the upper right hand corner.
corner corner.
b) Detach one (1) Answer Sheet from the last page.
page. Do the same in the
next subjects.
subjects.
c) Return the remaining ID/AS sets and your metered stamped stamped--mailing
envelope to your brown envelope and give it back to the 25 Room
Watcher/Proctor..
Watcher/Proctor
5. FILLING-UP OF THE ANSWER SHEET
FILLING-
a) Fill-
Fill-up the data on your Answer Sheet by using black ballpen,ballpen, refer
to the sample written on the board.
board. Read carefully the instructions on the
face of your Answer Sheet "DO NOT WRITE YOUR NAME, SEAT
NUMBER OR ANY IDENTIFYING MARKS OTHERWISE YOUR
EXAMINATION WILL BE CANCELLED".CANCELLED". WRITE THE CORRECT
SUBJECT TITLE TITLE..
b) After filling-
filling-up your Answer Sheet, you may now attend to your personal
needs, as no one will be allowed to go out while the examination is in
progress.. Empty your pockets of any codigo,
progress codigo, cell phone, beeper, etc
etc..
27
8. SUBMISSION OF TEST BOOKLET AND ANSWER SHEET - Be sure that
you marked the Set Box (A or B) on the Answer Sheet, and b) submit
your test papers to your Room Watcher and arrange your test papers
following this order:
order:
a) Notice of Admission on top followed by Answer Sheet, then your
Test Booklet set.
set.
b) Sign on the EXAMINEES RECORD OF ATTENDANCE, indicate the
SET of TB, time submitted and the number of pages of TB
submitted..
submitted
c) Room Watcher/Proctor will sign your Notice of Admission.
Admission.
10. BEFORE THE START OF THE 2ND, 3RD, 4TH SUBJECT, ETC. ETC. do the
following:
a) Get your brown envelope from your Room Watcher.
b) Check the name printed on the envelope and on the ID Sheet. Be
sure it is your envelope.
c) Follow procedures No. 4 - 9, for every subject. 28
IMPORTANT REMINDERS AND INSTRUCTIONS TO APPLICANT EXAMINEES
1. Submission of Fake Transcript of Records, CANCELLATION of examination papers
Birth Certificates and other Documents and DEBARMENT
2. Non-recognition of school graduated from and degree DISAPPROVAL of APPLICATION or
program by CHED CANCELLATION of examination papers
3. WRITING OF NAMES, UNNECESSARY WORDS OR CANCELLATION of examination papers
PHRASES ON THE ANSWER SHEET and SUSPENSION for one (1) year
4. Use of CORRECTION FLUID, SNO-PAKE or any other CANCELLATION of examination papers
erasing agents and SUSPENSION for two (2) years
5. MULTIPLE MARKINGS, two or more boxes marked per CANCELLATION of examination papers
item on the Answer Sheets, either with ink or other and SUSPENSION for two (2) years
impressions without ink
6. ACTS OF CHEATING (Use of codigos, cellular phones, CANCELLATION of examination papers
beepers, programmable calculators, communication and SUSPENSION for two (2) years
with anyone by means of words, signs, gestures,
codes and other similar acts)
7. WRONG MARKING OF BOX corresponding to the set Answers will be corrected using the key
of test question set/booklet (Example: Marked Box answer of the marked letter
"A", but the test question is set "B")
8. No set or non-marking of set of test question Answers will NOT be corrected
set/booklet received
9. Taking out of test questions used or pages thereof, CANCELLATION of examination papers
copying, and/or divulging or making known the nature and SUSPENSION for two (2) years
or content of any examination question or answer to 29
any individual or entry
OTHER PROHIBITED ACTS
1. Bringing inside the examination rooms the following:
following:
books, notes, review materials and other printed
materials containing coded data/information/formula.
data/information/formula.
2. Accepting or receiving anything, including food from any
person while the examination is in progress
progress..
3. Giving money, food, or any favor and other consideration
to the Room Watchers and other examination
personnel..
personnel
4. Loitering, talking, or discussing your answers inside the
room or along the corridor while the examination is still
in progress
progress..
REMINDERS:
REMINDERS:
1. Report to the test center before 6:30 a.m. on the first
day of examination
examination..
30
2. Late examinees will not be admitted
admitted..
Professional Regulation Commission
36
PROHIBITED ACTS INSIDE THE
EXAMINATION ROOM
1. Accepting or receiving anything, including food from
any person while the examination is in progress
progress..
2. Giving money, food, or any favor and other consideration
to the Room Watchers and other examination
personnel..
personnel
3. Loitering, talking, or discussing your answers inside
the room or along the corridor while the examination
is in progress
progress..
4. Putting any of the following markings on your answer
sheets:: name, seat number, unnecessary words or
sheets
phrases, strokes, dots or any other marks not called
for in the test questions
questions..
5. Taking out of the examination room test questions used or
pages thereof, copying, and/or divulging or making
known the nature or content of any examination
37
question of answer to any individual or entity.
entity.
6. Copying or referring to any solution, answer or work of
another examinee or allowing anyone to copy or refer
to your work, helping or asking help from any person
or communication with anyone by means of words,
signs,, gestures, codes and other similar acts which
signs
may enable you to exchange, impart or acquire
relevant information
information..
7. Bringing inside the examination rooms the following:
following:
books, notes, review materials and other printed
materials containing principles or excerpts thereof,
coded data/information/formula which are relevant to
or connected with the examination subject,
PROGRAMMABLE CALCULATORS, CELLULAR
PHONES,, beeper, portable personal computers or
PHONES
other similar gadgets/devices
gadgets/devices.. The act shall be
considered cheating and/or act of dishonesty and shall
be a ground for the cancellation of your examinations
(PRC Resolution NoNo.. 463 dated November 27,
27, 1996
1996))
38
PENALTIES FOR MULTIPLE MARKINGS & PLACING OF NAME IN THE
SPACE PROVIDED FOR THE SUBJECT OF THE EXAMINATION
Resolution No. 2003-
2003-154
1. Placing of Name - Cancellation of the examination papers
& suspension from taking the licensure examination
for one (1) year.
year.
2. Multiple Markings - Cancellation of the examination papers
& suspension from taking the licensure examination
for (2) years.
years.
IMPORTANT
Use of correction fluid, sno-
sno-pake and other erasing agent is
strictly prohibited
prohibited..
LIST OF NON-
NON-PROGRAMMABLE CALCULATORS
ALLOWED TO BE USED
Examinees shall be allowed to bring in and use ONLY
of the following calculators that were identified as non
non--
programmable (PRC Memorandum Circular No No.. 2004-
2004-06 dated
39
March 4, 2004
2004..
CASIO STANDARD/DESK TOP SCIENTIFIC CALCULATORS
CASIO 530 CASIO FX82C CASIO JS 40LA CASIO MS-100TE
CASIO 20V CASIO FX82LP CASIO JS-140 CASIO MS 120TE
CASIO 470LA CASIO FX85B CASIO JS-SC CASIO MS 170LA
CASIO D-20M CASIO FX855A CASIO LC-401B CASIO MS-270LA
CASIO D-60M CASIO FX220 CASIO LC-1000T CASIO MS-470LA
CASIO D-100V CASIO FX250HC CASIO LC-403LD CASIO MS-10V
CASIO D-208H CASIO FX350D CASIO M-7LB CASIO MS-10TE
CASIO D-120TE CASIO FX350W CASIO MJ-100 CASIO MS-80TE
CASIO DM-1600 CASIO FX570W CASIO MS 115 CASIO MS-8T
CASIO DS-208H CASIO HC100 CASIO MS 373 CASIO MS-20/V
CASIO DS-881 CASIO HL-821 CASIO MS-350 CASIO MS-1002
CASIO DF100 CASIO HL-122L CASIO MS-470 CASIO O-40M
CASIO DN 858A CASIO J-120TE CASIO MS 240 T CASIO SL-320V
CASIO DS1800S CASIO JS-10LA CASIO MS-808V CASIO SL-305TE
CASIO EL310-A CASIO JS-20LA CASIO MS-812V CASIO ELECT. D-20M
Fx65 Fx82MS Fx300W Fx580D Fx350TL
Fx75 Fx82SX Fx452M Fx825X Fx350HA
Fx82 Fx82TL Fx500A Fx911W Fx350HB
Fx95 Fx82Super Fx506G Fx991H Fx531GH
Fx260 Fx95MS Fx506M Fx991S Fx531LH
Fx401 Fx100D Fx509D Fx991ES Fx570AD
Fx580 Fx100S Fx509G Fx991W Fx570MS
Fx824 Fx100W Fx520G Fx992S Fx991MS
Fx901 Fx115D Fx546D Fx992s Fx992VB
Fx991N Fx115S Fx546L Fx100MS Fx350TLG
Fx855 Fx115W Fx570S Fx115MS 40
Fx82LB Fx122s Fx570W Fx300SA
SHARP
EL-233S EL-376S EL-509D EL-520A EL-556G
EL-240S EL-378S EL-509G EL-531GH EL-771C
EL-242M EL-501V EL-509R EL-531RH EL-2125
EL-250S EL-501V (BK) EL-509V EL-531VH EL-6053
EL-310A EL-506P EL-510R EL-531VH (BK) EL-6750
EL-310A-GR EL-506R EL-520G EL-531 VH (BL) EL-6810
EL-327S EL-506V EL-520V EL-546L EL-6850
EL-331A EL-506V (BK) EL-520-V (BK) EL-546VA
OTHER BRANDS
CEBAR CD402 KARCE-833 PORPO YH-105 TAKSUN TS-217
DAL 506X KARCE KC 250 PORPO YH-106 TAKSUN TS-128B
LIFELONG KARCE KC 593 TIME BIRD SJC-122
TL 30XS TEXAS TI 30 TAKSUN TS-128
43
(Revise June 18, 2013)
Republic of the Philippines
Professional Regulation Commission
Cebu Regional Office
44
ERRORS/OMISSIONS/VIOLATIONS PENALTIES/ACTION TO BE TAKEN
1. Submission of Fake Transcript of Records, CANCELLATION of examination papers
Birth Certificates and Other Documents and DEBARMENT
2. Non-recognition of school graduated from DISAPPROVAL of APPLICATION or
by CHED CANCELLATION of examination papers
3. WRITING OF NAMES, CANCELLATION of examination papers
UNNECESSARY WORDS OR PHRASES and SUSPENSION for one (1) year
ON THE ANSWER SHEETS
4. Use of CORRECTION FLUID, SNO- CANCELLATION of examination papers
PAKE or any other erasing agents and SUSPENSION for two (2) years
5. MULTIPLE MARKINGS, two or more CANCELLATION of examination papers
boxes marked per item on the Answer Sheets, and SUSPENSION for two (2) years
either with ink or other impressions without
ink.
6. ACTS OR CHEATING (Use of codigos, CANCELLATION of examination papers
PROGRAMMABLE CALCULATORS, and SUSPENSION for two (2) years
CELLULAR PHONES, communication with
anyone by means of words, signs, gestures,
codes and other similar acts, writing formulae,
notes on the palm of hand)
7. WRONG MARKING OF BOX Answers will be corrected using the key
corresponding to the set of test question answer of the marked letter
set/booklet (Example: Marked Box “A”, but
the test question is set “B”
8. NO SET or NON-MARKING OF SET of Answers will NOT be corrected
test question set/booklet received
9. Taking out of the rooms test questions used CANCELLATION of examination papers
or pages thereof, copying, and/or divulging or and SUSPENSION for one (1) year
making known the nature or content of any
examination question or answer to any
45
individual or entity
46
RESULTS, REGISTRATION AND OATHTAKING
48