Professional Documents
Culture Documents
MHP Manual Knockout Punch Kit
MHP Manual Knockout Punch Kit
The MHP manual knockout hole puncher can create a common sized conduit hole in a matter of seconds
with ease. This manual knockout tool uses the force of the operators hand for hole punching through
sheetmetal. The MHP manual hole puncher produces no burrs or distortion around the hole of the
finished material piece. This unit is ideally used on sheetmetal, electrical panels, aluminium channel, etc.
The MHP manual hole puncher individual sets are available in separate sizes from 15mm to 120mm
Diameter, each set is complete with a draw shaft. The MHP manual hole puncher can punch up to
2.4mm mild steel & 1.6mm stainless steel maximum thickness. This unit is also able to suit conduit sizes.
Stainelec
2/605 Hume Highway T: +61 2 9824 2499
Casula NSW 2170 F: +61 2 9824 2466
www.stainelec.com.au Australia