Professional Documents
Culture Documents
Method of Procedure
ABSTRACT
This document presents to commissioning NE (new site) for 1830PSS-36
1 PREFACE......................................................................................................................... 3
2 SCOPE.............................................................................................................................. 3
This Method of Procedure is applied to give the engineer a clear guideline during
commissioning new NE (new site) 1830PSS-36
2 SCOPE
The scope of the following operating procedure concerns the tests carried out on
standatd configured equipment belonging to the 1830PSS-36
3.2 HW Setup
There are six circuit packs that may be installed in fixed locations, per subrack The slots
used for these packs are reserved and may not be used for any other circuit packs
types.
All other circuit packs must be placed per the customer order, work order, or rack face
drawing
The Equipment is started up through the 6 circuit breakers on the Top Rack Unit.
4.2 PC Start Up
Make sure all software for commisioning are already install on PC
- Internet Explorer
- Java 1.6
Required equipment
The following equipment is required to perform this task:
USB flash drive
DVD that contains the new generic/version of the Alcatel-Lucent 1830 PSS suitable
NE software.
PC with USB 2.0 interface.
Insert the USB flash drive with the system software into the USB plug of the FLC
located in the worker slot
Then press the ACO button on the FLC and hold it ntil LED 1 is flashing green
The progress of the initial SW installation from the USB flash drive is indicated by
LED 1 on FLC. The LED 1 lits until the FLC has booted the release SW with the
default name FLCHCA and the default IP address 18.70.1.3
Wait around 30 minutes for the SW installation has finished and the FLC is ready
(indicates to be in active state) when both, the STAT and the EPS LEDs display
‘GREEN’ color
PC CONNECTION SETTING