Professional Documents
Culture Documents
NOMINAL COMPOSITION
Composition is confidential
PARTS AVAILABILITY
Most wet-end parts can be manufactured in
TYPICAL MICROSTRUCTURE alloy A05.
The microstructure of Alloy A05 consists of
The most common parts are as follows:
eutectic M7C3 and secondary carbides in a
Impellers, volute liners, throatbushes, frame
ferrous matrix predominantly of martensite.
plate liner inserts, bowls and doors.
A small amount of retained austenite may be
present in the final microstructure. A05 is
heat treated to develop high hardness and
optimum erosion resistance.
SERVICE RECOMMENDATIONS
Alloy A05 can be used for pumping a wide
range of mildly acidic duties. The alloy gives
excellent wear life for a variety of particle
size and hardness.
SPECIAL NOTES
600
550
500
450 Near
UTS MPa
surface A05
400
A11
350
Centre
300
250
200
0 20 40 60 80 100 120 140
Thickness mm