Professional Documents
Culture Documents
As with most Linksys routers, and for all versions of the WRT54G2, the default
password is admin. This password is case sensitive.
You don't need to enter a username when logging into the WRT54G2 because this model
doesn't have a default username.
There are three versions of this router but each of them uses the same default
login information from above.
Fortunately, you can just reset the Linksys WRT54G2 router to its default settings
to clear away any customizations, leaving the router with the default username and
password we mentioned above.
If you see any lights on, it means the router is plugged in and ready to be used.
Turn the router around so you have access to the back where the cables are
connected.
With something small and sharp like a paperclip or pin, press and hold the Reset
button down for at least 5 seconds.
Wait 30 seconds for the router to reset everything, and then unplug the power cable
for a few seconds.
After you plug the power cable back in, wait another 60 seconds just to be sure
that the WRT54G2 is fully on and ready to be used.
Make sure the network cable and power cable are still firmly in place, and then you
can reposition the router how you had it before you started.
Now, can login to the router at http://192.168.1.1 using the password admin.
The Linksys WRT54G2 router has been reset to its factory default settings, so it's
important to change the default password to something more secure. However, to make
sure you don't forget it this time, it'd be a good idea to store it in a free
password manager.
Since the router was reset, any custom settings it was storing has been removed, so
you'll need to reconfigure those things. For example, the wireless network settings
like the SSID and wireless password will need to be set up again.
Page 21 of the WRT54G2 user manual (there's a link to this manual below) shows how
you can make a backup of these configurations so that you don't have to re-enter
the information if you ever need to reset the router again. It's done through the
Administration > Config Management menu.
Fortunately, unlike with a lost password, you don't have to reset the WRT54G2
router to reset or find the IP address. If you're using Windows, see our guide on
How to Find Your Default Gateway IP Address if you need help. The IP address you
find is the one that you need to use to login to the router.
All the downloads can be found on the Linksys WRT54G2 Downloads page. The WRT54G2
manual can be downloaded here, directly from the Linksys website. The same manual
is used for all three versions of the WRT54G2.
The Linksys WRT54G2 user manual is in the PDF format, so you'll need a PDF reader
to open it.