Professional Documents
Culture Documents
Taguchi Qe
Taguchi Qe
Loss Function
Taguchi has defined quality as the loss imparted to society
from the time a product is shipped. Societal losses include
failure to meet customer requirement, failure to meet ideal
performance, and harmful side effects. Also included the
losses due to production, such as raw material, energy, and
labor consumed on unusable products or toxic by-products.
Loss to Society
Distribution of Color Density for Sony-USA and Sony-Japan
Nominal-the-Best
The quadratic loss function is described by the equation
Thus, if the number of dof is 13, then the next available OA is OA16.
Interaction Table
Confounding is the inability to distinguish among the effects of
one factor from another factor and/or interaction. In order to
prevent confounding, we must know which column to use for the
factors.
Let’s assume that factor A is assigned to column 1 and factor B
to column 2. if there is an interaction between factors A and B,
then column 3 is used for the interaction, AB.
Another factor, C, would need to be assigned to column 4. If
there is interaction between factor A (column 1) and factor C
(column 4), then interaction AC will occur in column 5.
The columns that are reserved for interactions are used so that
calculations can be made to determine whether there is a strong
interaction. If there are none, then all columns can be used for
factors.
The actual experiment is conducted using columns designated
for factors, referred to as design matrix. All the columns are
referred to as design space.
Linear Graphs
Taguchi developed a simpler method of working with
interactions using linear graph. They make it easier to
assign factors and interactions to the various columns of an
array. Factors are assigned to the points. If there is an
interaction between two factors, then it is assigned to the
line segment between the two points.
Linear graphs for OA8:
Interactions
Taguchi’s approach to interactions are:
1. Interactions use dof; therefore, more treatment conditions are
needed or fewer factors can be used.
2. OA are used in parameter design to obtain optimal
factor/levels for robustness and cost in order to improve
product and process performance.
3. Interactions are primarily between control factors and noise
factors.
4. Main effect analysis will give the optimal results and good
reproducibility as long as interactions are relatively mild.
5. OA12 (two-level) and OA18 (three-level) are recommended
so that if interactions are present, they are dispersed among
all the factors.
6. Engineers should develop a design that uses main effects
only.
7. An unsuccessful confirmation run may indicate an interaction.
Signal-to-Noise (S/N) Ratio
The S/N concept:
Signal factors ( ) are set by the designer or operator to obtain the
intended value of the response variable. Noise factors ( ) are not
controlled or are very expensive or difficult to control. Both the
average,a , and the variance, , need to be controlled with single
figure of merit.
Squaring and taking the log transformation gives