Professional Documents
Culture Documents
LTE Planning Outlines PDF
LTE Planning Outlines PDF
Planning
Theoretical and tools training course on LTE
radio network planning and optimisation
TeleResources Engineering (Aust) Pty Limited A.B.N. 48 093 413 604 website: www.teleres.com.au
Unit2a 4-6 Aquatic Drive Frenchs Forest • PO Box 693 Brookvale NSW 2100 Australia
Tel: +61 2 9975 2230 Fax: +61 2 9975 2240
Associates in Berlin, Boston, Budapest, Helsinki, Hong Kong, Kiev, London, Manila, New Zealand, Paris, Ottawa,
Singapore, Seoul, Tokyo and Washington
Introduction
Radio network engineers are faced with the challenges that come with a rapid
change in technology. A new radio interface such as Long Term Evolution requires a
different set of competencies and new tools that are designed to face the
challenges of mobile broadband growth and efficient network utilization.
For this reason we have often been sought out by operators, vendors and
independent service providers wanting to get experience with our tools and benefit
from our global knowledge. Consequently we have decided to offer a structured
training program in LTE radio network planning and optimization utilizing the Atoll™
planning tool and the Symena Automatic Cell Planning and optimization tool,
Capesso™.
The program is condensed into a 5 day intensive course where students will get
detailed knowledge about the LTE air interface and design methods. To complement
this there are practical training exercises on Network Design using the Planning Tool
and an Automatic Cell Planner. This knowledge of industry leading tools will provide a
competitive advantage to Radio Engineers who want to achieve success in their
profession.
Prerequisites
Administrative Details
Hard copy of the slides presented during the course for note taking and future
references.
A series of practical exercises. Exercises are entwined sequentially with
slideshows, to validate that each section is understood and acquired.
A maximum of eight (8) attendees will participate in each training session assuring
individual attention by our instructors.
For bookings and any queries concerning the course please contact:
Email: enquiries@teleres.com.au
EPC Architecture
o Interfaces in EPC
o Function of MME, SGW and PGW
o S1 and X2 Protocol Stacks
Voice in LTE
o CS Fallback
o VoLTE (Voice Over LTE)
o VoIP and IMS ( IP Multimedia System )
Random Access
o Timing synchronisation
o Contention Based Random Access
o Contention Free Random Access
o Random Access Preamble
Idle Mode
o Synchronization
o Cell selection and reselection
o Registration Update procedure
o Paging
o System Information
Introduction to ATOLL ®
o ATOLL ® General Concepts
o ATOLL ® Working Environment
o Geographic data
o Radio Data
o Predictions
o Prediction Analysis, Reports and Exports
LTE Network Modelling and analysis using ATOLL ® radio planning Tool
o LTE Predictions
o Neighbour Allocation
o Automatic Frequency and PCI allocation
o Frequency and PCI Plan Analysis
o Monte-Carlo Simulations for Capacity Analysis
Initial Tuning & Optimisation of LTE Networks using Symena’s CAPESSO ® ACP
Tuning Preparation
o Design Review
o Parameter Consistency and Configuration Checks
o Drive Route Planning
o Hot Spot Identification
o LTE KPI definition for Drive Test
Network Testing
o Single Site Checks
Drive Test Data Features in planning Tool and Automatic cell Planner
o Drive Test Data Import
o Drive Test Data Management
o Drive Test Data Display