show voice calls status (one call leg should be POTS
show call active voice brief
show dial-peer voice summary show dialplan number XXXX
###############################
ISDN SHOW COMMANDS
=================== ISDN Layer 1 ++ show controller e1 0/2/0 ++ show isdn status (L1/L2/L3) ++ show isdn service (B Channels) ++ E1 = 0/2/0:15 (17th Signaling) ++ T1 = 0/2/0:23 (24th Signaling) DEBUG ISDN COMMANDS ==================== ++ debug isdn q921 ++ debug isdn q931 (L3 information)
DEBUG SIP MESSAGES
==================== ++ debug ccsip messages
IOS 15.x Behavior
=================== ++ Disable Toll Fraud by one of method 1) Disable Authentication 2) White List your IP address If you are configuring dial-peers IP address will be automatically white-listed
++ By default IOS router will allow
1) VOIP (Mgcp/sip/h323) to POTS call 2) POTS to VOIP 3) POTS to POTS IOS will not allow VOIP to VOIP calls (only for H323 / SIP )
That is the reason you use H323 / SIP for CUBE implementation