Professional Documents
Culture Documents
UP220 AE A Power Supply PDF
UP220 AE A Power Supply PDF
SMPS SPECIFICATION
UMEC P/N:
UP220-AE-A(open frame)
This unit is ready for “Green Product” and meet “Pb -free lead plating”&” ROHS Compliant”
Requirement.
2/8
UMEC SMPS SPECIFICATION
3.2 Output Current Range
Output Min. Current Max. Current Peak Current Unit
+5.1V 0.2 3.5 A
+12V 0.5 1.7 A
+24V 0.5 7.5 A
3/8
UMEC SMPS SPECIFICATION
5.0 GENERAL REQUIREMENTS
5.1 Turn-On Delay Time
The delay time for all output rises within regulation limit after the input power turn on.
AC100V~AC240V
Output Specification (max.) Unit
+12V 1 Sec
+24V 1 Sec
5.4 Efficiency
Input Spec. (min.) Unit
115Vac 85 %
230Vac 87 %
4/8
UMEC SMPS SPECIFICATION
6.0 Mechanical
6.1 Power Supply Dimensions
B3 B2
限高板上 28.5 mm 以內
B1
5/8
UMEC SMPS SPECIFICATION
6.2 AC Connectors
B1: 2.54mm Pitch
Pin Signal
1 L
2 NC
3 FG
4 NC
5 N
6.3 DC Connectors
B2: 2.0mm pitch
Pin Signal
1 24V
2 24V
3 12V
4 12V
5 5.1V
6 5.1V
7 5.1V
8 GND
9 GND
10 GND
11 B/L Adj.
12 ON/OFF
13 B/L on/off
6/8
UMEC SMPS SPECIFICATION
B3: 2.0mm pitch
Pin Signal
1 B/L on/off
2 B/L Adj.
3 24V
4 24V
5 24V
6 24V
7 24V
8 GND
9 GND
10 GND
11 GND
12 GND
6.4 ON/OFF
The ON/OFF signal is required to remotely turn on/off the power supply. ON/OFF
signal is an active high signal that turns on the 12V, and 24V power rail.
ON/OFF Signal Characteristic
Signal Specification
ON/OFF = Open or Low Power Supply Off
ON/OFF = high Power Supply On
Min. Max.
Logic level low 0V 2.0V
Logic level High 3.0V 5.25V
7/8
UMEC SMPS SPECIFICATION
10.0 Test Placement
測試時需擺放方式如下圖所示
TOP
BOTTOM
TOP
測
試
時
需
擺
放
方
式
如
右
圖
所
示
BOTTOM
8/8