Professional Documents
Culture Documents
INSTRUCTIONS TO CANDIDATES
2. Answer ALL questions in the Answer Booklet. Start each answer on a new page.
3. Do not bring any material into the examination room unless permission is given by the
invigilator.
4. Please check to make sure that this examination pack consists of:
QUESTION 1
., x-1
linr
') !-l
x
-> 1 x -X
(3 marks)
tan3x
ii) lim
x^o 2x
(4 marks)
4x8+3
i) lim
x->» Vx -6x
(4 marks)
2
2 x - / f , x<1
b) Let g(x) 16x-21 , 1 < x < 3
2x 3 , x>3
QUESTION 2
dy
a) Find - ^ for the following:
dx
i) y = - + 3x2-Vx
x
(2 marks)
ii) y = x2Vx-2
(4 marks)
dy
b) Find — for sinfx + y) = x 6 + 3xy by using implicit differentiation.
dx
(6 marks)
< x •
2m Flower garden
11 m
t-
Figure 1
i) Show that the combined area of the garden and the border is A - 2x + + 53 .
(3 marks)
ii) What dimensions of the garden will minimize the combined area of the garden
and the border?
(5 marks)
iii) What is the minimum combined area of the garden and the border?
(2 marks)
QUESTION 3
a) Use differential to estimate the value of 2J7.96 correct to four (4) decimal places.
(5 marks)
iii) Find the interval(s) where f(x) is concave up and/or concave down.
(3 marks)
QUESTION 4
b-a
If f"(x) = -s/4x + 1, find the value of c in the interval (0,6), that satisfies the above
theorem.
(5 marks)
b) The area of a Square whose sides have length xcmis increasing at the rate of
12cm 2 s -1 . Howfast is the length of a side increasing when the area is81cm2?
(4 marks)
c) Solve I V x ( x 2 + 3 x ) d x
(3 marks)
i) M^dx
Jfx + 3 /
(5 marks)
ii) Itan(20jd0.
(4 marks)
QUESTION 5
a) Find the area of the shaded region R enclosed by the curve y = x 2 , the line
y = 2 - x and y-axis as shown in Figure 2.
Figure 2
(5 marks)
b) Consider the region R, enclosed by the curve y = x 3 + 1 , the line x = 3 and x-axis as
shown in Figure 3.
Figure 3 x=3
Use the Disk method to find the volume of the solid obtained by revolving the
region R about the x-axis.
(6 marks)
Using the Shell method, set up and simplify the integral to find the volume of
the solid obtained by revolving the region R about the line x = -2.
Do not evaluate the integral.
(4 marks)