Professional Documents
Culture Documents
EUROCODE 8
1
Darko Gajić, PhD student, University of Novi Sad, Faculty of Civil Engineering Subotica, Kozaračka
2a, Subotica, Serbia, tel: +381 24 554 300, e – mail: darko.gajic24@gmail.com
2
Nemanja Bralović, PhD student, Assistant, University of Novi Sad, Faculty of Civil Engineering
Subotica, Kozaračka 2a, Subotica, Serbia, tel: +381 24 554 300, e – mail:
nemanjabralovic@hotmail.com
3
Prof. dr Aleksandar Prokić, dipl. inž. građ., University of Novi Sad, Faculty of Civil Engineering
Subotica, Kozaračka 2a, Subotica, Serbia, tel: +381 24 554 300, e – mail: aprokic@eunet.rs
4
Prof. dr Đorđe Lađinović, dipl. inž. građ., University of Novi Sad, e – mail:
djordje.ladjinovic@gmail.com
H⋅ ρ
Timp = Ci ⋅ EN 1998-4 Annex А 3.2.2 (A.35) (1)
s
⋅ E
R
( )
Q = ( mi + mw + mr ) ⋅ Se Timp + mc ⋅ Se (Tcon ) EN 1998-4 Annex A (3)
Where is: Где је:
mr - represent the mass of the tank roof mr - маса крова резервоара,
𝑚𝑚𝑤𝑤 - stands for the mass of tank wall 𝑚𝑚𝑤𝑤 - маса зидова резервоа
( )
Se Timp - Impulse spectral acceleration ( )
Se Timp - Импулсно спектрално
Se (Tcon ) - convective spectral acceler- убрзање,
ation Se (Tcon ) - конвективно спектрално
убрзање
( )
M =( mi ⋅ hi + mw ⋅ hw + mr ⋅ hr ) ⋅ Se Timp + mc ⋅ hc ⋅ Se (Tcon ) EN 1998-4 Annex A (4)
Where is: Где је:
hr − brunt roof height of the tank, hr − тежишна висина крова
hw − brunt wall height of the tank резервоара,
( ) ( )
M ' = mi ⋅ hi' + mw ⋅ hw + mr ⋅ hr ⋅ Se Timp + mc ⋅ hc' ⋅ Se (Tcon ) EN 1998-4 Annex A (5)
Слика 18. Основна сила смицања за однос H/R=3 у зависности од типа тла
Figure 18. The basic shear force for the ratio H/R=3 depending on the soil type
Слика 19. Момент превртања изнад темељне плоче за однос H/R=3 у зависности од
типа тла
Figure 19. Overturning momentum above the foundation slab for the ratio H/R=3
depending on the soil type
4. CONCLUSION 4. ЗАКЉУЧАК
After the seismic analysis of the steel Након спроведене сеизмичке ана-
liquid storage tank, this study shows the лизе челичног резервоара за скла-
moments of overturning and shear force диштење течности у овој студији су
at a maximum acceleration of soil is приказани моменти превртања и
0,4g. The analysis of the results is based смичуће силе при максималном
on three parameters: the type of liquid to убрзању тла 0,4 g. Анализа резу-
be stored, the relationship between the лтата се заснива на основу три
height of the fluid in the tank and the парамтера: врсте течности која се
inner radius (H / R), and the soil складишти, односа висине течности у
categories. The analysis showed that резервоару и унутрашњег радијуса
shear forces on the basis of reservoirs (H/R) и категорије тла. Анализа је
and overturning moments increased показала да силе смицања на бази
with an increase in the H / R ratio. In резервоара и моменти превртања
addition to the H / R ratio, another very расту са повећеањем односа H/R.
important parameter is the liquid that is Поред односа H/R други веома битан
stored, in the paper it can be seen that параметар је течност која се скла-
significantly higher seismic impact дишти, у раду се види да знатно веће
values arise from the storage of sulfuric вредности сеизмичких утицаја на-
acid in relation to water. Also, the impact стају услед складиштења сумпорне
of the soil category should not be киселине у односу на воду. Такође не
ignored, where it is clearly seen that the треба занемарити утицај категорије
category "E" gives the greatest impacts тла, где се јасно види да категорија
while category "A" gives the least „Е“ даје највеће утицаје док кате-
impact. It should be noted that the горија „А“ даје најмање утицаје.
categories of soils that are aligned in Треба напоменути да категорије тла
alphabetical order of the same order, in које су поређане абецедним редом
turn, do not give more results. Since, in истим тим редом не дају веће
practice, we can not control the design резултате. С обзиром да се у пракси
REFERENCES