Professional Documents
Culture Documents
rc17015 PDF
rc17015 PDF
Temperature (°C)
0 85
Pressure (Bar ga)
DN 25- 300 10.0 10.0
Notes
- Design limits acc. to the nom. pressure of valves
- Ball valves are in accordance with ISO17292
- For basis of design see DEP 31.38.01.10-Gen.
- For requirements regarding GRP piping systems, see DEP 31.40.10.19-Gen.
- Bolts for GRP flanges to be provided with washers
- Piping material: glass reinforced epoxy resin (GRE) alphatic amine, hot cured, tg > 115 deg c, all
executed with aluminium foil barrier
- Flanges to be drilled acc. to ASME B16.5, class 150
- Bolt sets not shown in piping class; flange thickness differs per manufacturer
- Piping components for potable water service shall be approved by local health authorities
- Under ground carbon steel components (incl. bolting) shall be protected by a coating as per DEP
30.48.00.31-Gen.
Table of schedules
DN Schedule
25 .
40 .
50 .
80 .
100 .
150 .
200 .
250 .
300 .
Valves
Miscellaneous
GKRP Gasket flat ring (r/f face) DN 25-300 Ethylene propylene rubber (EPDM)
hardness 70+/-5 shore A
STBT Studbolt with nuts --- ASTM A193-B7/A194-2H
DEP 31.38.01.12-Gen. Class 17015, rev. B page 3
PIPING COMPONENTS
Valves
Ball valve float RB flgd ff 770322 3051 3071 3081
Butterfly valve conc lug type 775056 5101 5121 5141 5151 5161 5171
Check valve dual plate lug ff 776826 0101 0121 0141 0151 0161 0171
Check valve flgd ff 771301 0051 0071 0081
Miscellaneous
Gasket flat ring (r/f face) 854810 0081 0121 0141 0181 0201 0241 0261 0281 0301