Professional Documents
Culture Documents
2011 / PP
Truck Parameters
BDI Curve Range: 1…10 Default: 3 Selection
Battery discharge curve select. Curve defines battery voltage level for each BDI level (1...10). Curve 9
indicates low battery sooner than curve 0.
If the truck is equipped with aisle detection magnet sensors, this parameter sets ON the aisle detection
using magnets.
If the truck is equipped with aisle detection photocells, this parameter sets ON the aisle detection using
photocells.
Page 2 of 5
NOH10N NOH10NH Display Parameters 28.02.2011 / PP
If the truck is equipped with magnetic aisle detection system, this parameter can be set to slowdown on
inner magnet. Maximum speed will be restored on outer magnet.
If the truck is equipped with magnetic aisle detection system, it can be set to slowdown on inner magnet
and stop on outer magnet. Maximum speed will be restored after the driver has released the throttle
lever.
The truck allows lowering in every other error case except slack chain.
WGU Parameters
Start Automatic Calibration
Start automatic calibration sequence by pressing either right or left arrow button.
When entering calibration mode, the calibration frequencies 1-10 will be used to determine the current
frequency. The detected antenna signal maximum is then used to determine a suitable gain.
In calibration sequence the truck must be driven over the inductive wire in moderate angle. The
calibration procedure will finish automatically 5 seconds after leaving the wire with both antennas.
If the correct calibration values are known, it is possible to write them directly without performing the
actual calibration sequence.
After calibrating, the result can be found in Current Gain and Current Frequency. Return by pressing
enter.
0 if uncalibrated. Automatically set in calibration mode. If the correct calibration values are known, it is
possible to write them directly without performing the actual calibration sequence.
0 if uncalibrated. Automatically set in calibration mode. If the correct calibration values are known, it is
possible to write them directly without performing the actual calibration sequence.
Page 3 of 5
NOH10N NOH10NH Display Parameters 28.02.2011 / PP
Frequency List
When calibrating, the actual frequency used in the wire must be present among the calibration
frequencies. The frequencies are scanned without any priority, so it does not matter in which order they
are set.
To ensure that only the correct frequency is detected, the different calibration frequencies in the list
should be at least 400 Hz apart.
If the values need to be modified, save them by pressing enter before starting the automatic calibration.
…
Calibration Frequency 1 Range: 0 – 10 000 Default: 5200 Hz
Calibration Frequency 2 Range: 0 – 10 000 Default: 6250 Hz
Calibration Frequency 3 Range: 0 – 10 000 Default: 7000 Hz
Calibration Frequency 4 Range: 0 – 10 000 Default: 10000 Hz
Calibration Frequency 5 Range: 0 – 10 000 Default: 6250 Hz
Calibration Frequency 6 Range: 0 – 10 000 Default: 6250 Hz
Calibration Frequency 7 Range: 0 – 10 000 Default: 6250 Hz
Calibration Frequency 8 Range: 0 – 10 000 Default: 6250 Hz
Calibration Frequency 9 Range: 0 – 10 000 Default: 6250 Hz
Calibration Frequency 10 Range: 0 – 10 000 Default: 6250 Hz
Display Parameters
M= Management Mode
S= Service Mode
Page 4 of 5
NOH10N NOH10NH Display Parameters 28.02.2011 / PP
Fork End Display (S) Range: ON/OFF Default: ON (EU) OFF (US)
If the display is installed on forks side of the cabin this parameter turns the direction arrows of the
display around.
Page 5 of 5