[?] Gives the list of available commands RS232/Serial command [?] Gives help on the command and list of arguments Telnet [Tab] Completes the command/word. If the input is ambiguous, a second [Tab] gives possible options SSH / Move up to base level MAC-Telnet .. Move up one level Winbox /command Use command at the base level Webfig Base Levels Popular Sublevel Commands RJ45 Rollover certificate ppp /ip /system ssh ppp-server mac-scan driver queue accounting backup sup-out pppoe-client mac-server file radius address check-disk telnet pppoe-server mac-telnet interface routing arp check-installation upgrade pptp-client netwatch ip snmp dhcp-client clock watchdog pptp-server ping-speed ipv6 special-login dhcp-relay console /interface sstp-client profile lcd store dhcp-server default bonding sstp-server sms log system dns health bridge traffic-eng sniffer metarouter terminal firewall history eoip virtual-ethernet torch mpls tool hotspot identity ethernet vlan traceroute partitions user ipsec leds gre /routing traffic-generator port wireless neighbor license ipip bfd traffic-monitor packing logging l2tp-client bgp wol Examples pool note l2tp-server mme bandwidth-server proxy ntp lte ospf bandwidth-test /ip ? route package mesh rip /log ip route print service reboot monitor-traffic /tool debug inter ether print settings reset-configuration ovpn-client bandwidth-server error smb resource ovpn-server bandwidth-test info General Syntax socks routerboard ppp-client dns-update warning ssh scheduler ppp-server e-mail add move tftp script pppoe-client fetch Popular Keyboard Shortcuts edit/set remove traffic-flow serial-terminal pppoe-server graphing Control-C Interrupt/Break find export upnp shutdown pptp-client ip-scan Control-D Log out print import Version 1.1 – 20130707 Control-X Toggle safe mode Control-L Clear screen get enable by: Werner van Heerden Control-V Command auto-complete werner@neonnetworks.co.za comment disable Not all commands/connection methods may be possible, supported or enabled. Control-\ Split line at cursor (new line) http://wiki.mikrotik.com/wiki/Manual:Console F1 or ? Show help