Professional Documents
Culture Documents
survey is true?
06/26/2019 - by Mod_GuideK
Which purpose of using Metageek Chanalyzer during site survey is true?
A. to verify the antenna pattern of the APs
B. to show only the usage of the 2.4 GHz spectrum
c. to determine the sources of non-802.11 interferences
D. to verify the different channels used during the design of Wi-Fi networks
HIDE ANSWERS
Correct Answer: D
Explanation/Reference:
Explanation:
A spectrum analysis tool like Chanalyzer + Wi-Spy which shows you non-WiFi interference from devices like cordless
phones, wireless video cameras, and microwave ovens. After you\te detected an otherwise-invisible non-WiFi device,
Chanalyzer + Wi-Spy can identify it and track it down.
https:tlsupport.metageek.comlhc/en-uslarticles/205050684-ls-Chanalyzer-a-Site-Survey-Tool-
Posted in: 300-360
3 thoughts on "Which purpose of using Metageek Chanalyzer during site survey is true?"
Anonymous says:
09/10/2019 at 12:31 PM
C
JackP says:
08/01/2019 at 2:34 PM
C
Alvaro says:
08/16/2019 at 4:55 AM
I agree. the correct answer is the c
After installation of a new data-only wireless network. an engineer found that RRM has set all of the APs to a
power level of 1.
Which option describes the reason for this?
A. APs are too far apart for the set data rates.
B. EORRM is enabled
c. High co-channel interference exists.
D. DTPC value is set too high.
HIDE ANSWERS
Correct Answer: AB
Explanation/Reference:
Explanation:
You must take note on what adapter was used in a site survey. The adapter should have similar characteristics to the
adapters on the devices that are actually to be used in the wireless network. You should always verify what type of
client adapter was used throughout the survey. A client adapter with a better receiver sensitivity and stronger
antenna does not provide accurate results to compare against clients that are actually used in production.
HIDE ANSWERS
Correct Answer: B
Explanation/Reference:
Explanation:
Evaluating Compliance With FCC Guidelines for Human Exposure to Radio frequency Electromagnetic Fields; This
revised OET Bulletin 65 has been prepared
https:IIWWW.fcc.govlgeneraltoet-bu//etins-line
Where do you install the access points?
06/26/2019 - by Mod_GuideK
You must redesign an existing wireless network that spans multiple floors to support location- based services.
Where do you install the access points?
A. in the elevators
B. in the perimeter of each floor
c. in the stairwells of each floor
D. in the center of each floor