Professional Documents
Culture Documents
Air Polution Concentration Calculation
Air Polution Concentration Calculation
TAREA #3
PROFESOR:
ING. ORLANDO AGUILAR, Ph.D.
ESTUDIANTES:
MARTIN VARGAS 8-818-844
JONATHAN NASH 8-894-276
1
Air Pollution Engineering
Problem Set #3
()
NOTA: No entregue imágenes de esta tarea; en su lugar, entréguela en formato pdf.
1. A particle size distribution (on a mass basis) follows a log-normal distribution with a
geometric mean diameter of 5.0 m and a geometric standard deviation of 2.0.
The mass percent of particles larger than 10 m is approximately
a. 15.9%
b. 50.0%
c. 84.1%
d. none of the above
2. A spherical particle has a density of 2.5 g/cm3 and a diameter of 20 m. What is its
aerodynamic diameter?
a. >20 m
b. 20 m
c. <20 m
d. It cannot be determined from the given data
3. Which of the following particles has the greatest value of slip correction factor?
a. dp=10 μm, ρp=1.0 g/cm3
b. dp=5 μm, ρp=2.5 g/cm3
c. dp=1 μm, ρp=2.0 g/cm3
d. dp=0.1 μm, ρp=2.5 g/cm3
4. Which of the following spherical particles has the greatest value of terminal settling
velocity in standard air?
a. dp=10 μm, ρp=1.0 g/cm3
b. dp=5 μm, ρp=2.5 g/cm3
c. dp=1 μm, ρp=19.0 g/cm3
d. dp=0.1 μm, ρp=1.0 g/cm3
5. A particle size distribution (on a mass basis) follows a log-normal distribution with a
geometric mean diameter of 5.0 m and a geometric standard deviation of 2.0.
The mass percent of particles between 2.5 and 10 m is most nearly
a. 15.9%
b. 34.1%
c. 50.0%
d. 68.2%
e. 84.1%
2
Name: ___________________
1. Consider the particle size distribution in the table below obtained using a cascade
impactor.
a. Calculate the geometric mean Size Range Mass
diameter and the geometric standard (μm) Concentration
deviation of the psd. (μg/m3)
b. Show that the distribution is log-normal <0.6 25.5
by plotting the points on a log- 0.6-1.0 33.2
probability paper. From the plot, 1.0-1.2 17.9
determine the mass median diameter 1.2-3.0 102.0
and geometric standard deviation. 3.0-8.0 63.8
Compare these values with those in 8.0-10.0 5.1
part a. 10.0-12.0 7.7
c. From the plot, determine the mass
percentages of fine particles (i.e., d p≤2.5 m) and coarse particles (i.e., 2.5 to
10 m).
3. What particle size (ρp=4000 kg/m3) will be too large to be carried out of a vertical
exhaust duct 35 cm in diameter that handles 5.0 m3/min of air? Assume STP.
3
4
Name: ___________________
5
6
Name: ___________________
7
8
Name: ___________________