Professional Documents
Culture Documents
4.0
2.9 2.9
4.5
8.7
■ Applications
21.0 ± 1.0
1. Audio equipment
1.0
+
2. Cameras 1.0 0.4 - 0.2
0.1
0.5
2.1 1.5
2.54 2.54
1 2 3 1 VOUT
2 GND
* Tolerance : ± 0.2 3 VCC
*2
Soldering temperature T sol 260 ˚C
2.9 2.9
0.4 - 0.2
0.1
*1 No dew condensation is allowed.
+
4.5
*2 For 5 seconds θ
θ
1.4
1 2 3
2.1 1.5
“ In the absence of confirmation by device specification sheets, SHARP takes no responsibility for any defects that occur in equipment using any of SHARP's devices, shown in catalogs,
data books, etc. Contact SHARP in order to obtain the latest version of the device specification sheets before using any SHARP's device.”
IS1U60/IS1U60L
600µ s 600µs
Output
T2 T1
Vout
Vcc
GND
IS1U60/IS1U60L
■ Performance
Using the transmitter shown in Fig. 1, the output signal of the light detecting unit is good enough to meet the following items in the standard optical system in Fig. 2.
(1) Linear reception distance characteristics
When L=0.2 to 5 m, Ee < 10 lx ( *4) and φ =0˚ in Fig. 2, the output signal shall meet the electrical characteristics in the attached list.
(2) Sensitivity angle reception distance characteristics
When L=0.2 to 3 m, Ee < 10 lx ( *4) and φ<= 30 ˚ in the direction X and θ =0˚ in the direction Y in Fig. 2,
the output signal shall meet the electrical characteristics in the attached list. Further, the electrical characteristics shall be met
when L=0.2 to 5 m, Ee < 10 lx (*4) and φ =0˚ in the direction X and θ<= 15˚ in the direction Y.
*4 It refers to detector face illuminance.
20cm
10kΩ
+ 5V
PD49PI
10 µ F
Transmitter (GL521 used)
Duty 50%
f o = 38kH z 10k Ω
Vout
Oscilloscope
Fig. 1 Transmitter
In the above figure, the transmitter should be set so that the output Vout can be 40mV P - P .
However, the PD49PI to be used here should be of the short-circuit current I SC =2.6 µ A at Ev=100 lx.
(Ev is an illuminance by CIE standard light source A (tungsten lamp).)
Direction Y
Direction X
Transmitter
φ : Direction X
θ : Direction Y
- 40˚ 40˚
- 50˚ 50˚
- 60˚ 60˚
- 70˚ 70˚
- 80˚ 80˚
20 30 40 50 60 - 90˚ 90˚
0
Carrier frequency (kHz)
Angular displacement φ
Fig. 3 Sensitivity Angle (Direction Y) Fig. 4 Relative Reception Distance vs. Ambient
Characteristics (TYP.) for Reference Temperature (TYP.) for Reference
- 20˚ - 10˚ 0˚ 10˚ 20˚ 120
- 50˚ 50˚
40 Unit SHARP
- 60˚ 60˚ standard transmitter
Relative comparison with reception
- 70˚ 70˚ 20
distance at V CC =5V,φ =0˚ , Ee <10 lx
- 80˚ 80˚ and Ta=25 ˚C taken as 100%
0
- 90˚ 90˚ - 40 - 20 0 20 40 60 80 100
0
Ambient temperature Ta (˚C)
Angular displacement φ
400
VCC =5V, Ta=RT, φ =0˚ , Ee < 10 lx
300
High level pulse width
200
1st bit
100 T= 430 µ s
0
0 1 2 3 4 5 6 7 8 9 10
Reception distance (m)
IS1U60/IS1U60L
80
Relative sensitivity (%)
70
60
50
40
30
20
10
0
500 600 700 800 900 1000 1100
Wavelength λ (nm)
R1
VCC Ve
+
C1 (Circuit constant)
IS1U60 R1 = 47Ω ± 5%
GND GND
C1 = 47µ F
Vout Vout