Professional Documents
Culture Documents
Anti
Anti
electrical fixtures to provide the building with a chemical barrier against the subterranean
termites before and after construction.
Anti-termite chemicals, pre and post construction treatment, preventive measures, safety,
advantages and disadvantages of anti-termite treatment are discussed in this article.
Fig 1: Protection
methods from termites.
Anti-Termite Chemicals
The chemicals used for anti-termite treatment in buildings as per Indian Standards (IS
6313 Part-3) are :
1. Chlorpyrifos 20 EC
2. Lindane 20 EC
The above-mentioned chemicals are used in water emulsion for the treatment of soil in
order to protect a building from termite attack. For the treatment of wood, oil or
kerosene-based solution of the mentioned chemicals with 1.0% concentration is used.
1. For the excavation made for foundation, the sides and the bottom surface of the foundation
trenches and pits are treated with an anti-termite chemical to a height of about 30cm at the rate of
5 Lit. per square meter of surface area.
2. For flooring, the earth surface is firstly cleaned from wooden and any other garbage particles.
6. This emulsion shall be poured in the holes by pouring jars and sprayed on the surface by using
pressure pumps and sprayers.
Fig 1: Surface
anti-termite treatment.
Benefits of Pre-Construction Anti-Termite
Treatment
1. Less Expensive
The steps involved in Pre-construction treatment are lesser when compared to post-
construction treatment. Thus the cost of the anti-termite is less.
2. Fewer Obstacles
The number of obstacles in case of Pre-construction anti-termite treatment is lesser.
Major components of buildings like walls, which gives better access to every nook and
corner of the buildings without any obstacles.
Preventive Measures
1. The primary function of soil treatment is to establish a chemical barrier between the termites in
the soil and the building to be protected.
2. To treat the soil outside of foundations, the soil in contact with the external wall of the building
shall be treated with the chemical emulsion at the rate of 7.5 lit/Sqm of the vertical surface of the
substructure to a depth of 300 mm.
3. The termites seek their way inside the building floor through the cracks or voids at the following
locations –
(a) At the junction of the floor and walls as a result of shrinkage of the concrete.
(b) Cracks formed on the floor surface due to construction defects.
(c) At construction joints and expansion joints in a concrete floor.
4. Chemical treatment should be done in the building area of the ground floor wherever the cracks
are noticed. This is done by drilling vertically 12 mm holes at the junction of floor and walls,
constructional and expansion joints mentioned above at 300 mm interval to reach the soil below.
5. Treatment for wood is done at the points of contact of the woodwork. All the locations where the
woodwork in the building is in contact with the woodwork must be treated with anti-termite
treatment.
6. This is done by spraying at the points of contacts with the adjoining masonry with the chemical
emulsion of concentration by drilling 6mm holes at a downward angle of about 45° at the
junction of woodwork and masonry.
7. Treatment of electrical fixtures such as switch boxes in the wall is done by removing the outer
coverings and treating the internal parts with 5 percent Malathion dusting powder.
2. Basic Personal Protective Equipment (PPE) shall be worn by all staff or laborers.
3. It eliminates the problem of gaps forming in the protection barrier, allowing termites to enter the
home.
4. Liquid termiticides are relatively inexpensive when compared to other forms of termite control.
2. Drilling into areas that show evidence of termite entry, or concrete may be necessary, which can
reduce the strength of the member or structure.
3. Any small negligence or left out portion can lead to problems with an infestation in future.