Dop id: P003_01 Performance specification ≤ 16 235 Tolerances on the nominal thickness (acc. EN 10029 > 16 ≤ 40 225 S235J0 Thickness Class A unless otherwise stated) > 40 ≤ 63 215 Tolerances on > 63 ≤ 80 215 dimensions and EN 10025- > 80 ≤ 100 215 shapes. Nominal thickness (mm) Lower Upper 1:2004 > 100 ≤ 150 195 3≤t<5 -0,3 +0,7 > 150 ≤ 200 185 Thickness 5≤t<8 -0,4 +0,8 > 200 ≤ 250 175 8 ≤ t < 15 -0,5 +0,9 15 ≤ t < 25 -0,6 +1,0 Tensile strength thickness mm min (Mpa) max (Mpa) ≤ 100 360 510 25 ≤ t < 40 -0,7 +1,3 > 100 ≤ 150 350 500 40 ≤ t < 80 -0,9 +1,7 > 150 ≤ 250 340 490 80 ≤ t < 150 -1,1 +2,1 150 ≤ t < 250 -1,2 +2,4 Elongation thickness mm min % ≥ 3 ≤ 40 24 > 40 ≤ 63 23 Width Nominal thickness Tolerances > 63 ≤ 100 22 Lower Upper > 100 ≤ 150 22 t < 40 0 +20 > 150 ≤ 250 21 40 ≤ t < 150 0 +25 150 ≤ t ≤ 400 0 +30 Impact strength thickness mm temperature, °C min. energy, J Tolerances on width for plates with untrimmed edges (NK) shall be the subject of ≤ 150 0 27 agreement between the manufacturer and purchaser at the time of enquiry and order > 150 ≤ 250 0 27
Weldability CEV thickness mm CEV max %
Length Nominal length Tolerances ≤ 40 0,35 l Lower Upper > 40 ≤ 150 0,38 l < 4000 0 +20 > 150 ≤ 250 0,40 4000 ≤ l < 6000 0 +30 Durability 6000 ≤ l < 8000 0 +40 (chemical 8000 ≤ l < 10 000 0 +50 composition) element Value 10 000 ≤ l < 15 000 0 +75 C, max 0,17 15 000 ≤ l ≤ 20 000 0 +100 Mn, max 1.40 Tolerances on plates with nominal length l > 20 000 mm shall be agreed at the time of P, max 0.030 enquiry and order. S, max 0.030 N, max 0.012 Cu, max 0.55 Flatness Nominal thickness t Measuring length t 1000 2000 3≤t<5 9 14 5≤t<8 8 12 8 ≤ t < 15 7 11 15 ≤ t < 25 7 10 25 ≤ t < 40 6 9 40 ≤ t < 250 5 8