Professional Documents
Culture Documents
Laboratorio 1 Grupo 2
Laboratorio 1 Grupo 2
------------------------
Ping laptop
-------
R1
------------------
------------------------------
R2
System Bootstrap, Version 15.1(4)M4, RELEASE SOFTWARE (fc1)
Technical Support: http://www.cisco.com/techsupport
Copyright (c) 2010 by cisco Systems, Inc.
Total memory size = 512 MB - On-board = 512 MB, DIMM0 = 0 MB
CISCO1941/K9 platform with 524288 Kbytes of main memory
Main memory is configured to 64/-1(On-board/DIMM0) bit mode with ECC disabled
A summary of U.S. laws governing Cisco cryptographic products may be found at:
http://www.cisco.com/wwl/export/crypto/tool/stqrg.html
R2>en
R2#config t
Enter configuration commands, one per line. End with CNTL/Z.
R2(config)#interface s0/0/1
R2(config-if)#ip add 10.2.2.2 255.255.255.252
R2(config-if)#no sh
R2(config-if)#interface s0/0/1
R2(config-if)#
R2(config-if)#encapsulation ppp
R2(config-if)#
%LINEPROTO-5-UPDOWN: Line protocol on Interface Serial0/0/1, changed state to
down
R2(config-if)#exit
R2(config)#encapsulation ppp
^
% Invalid input detected at '^' marker.
R2(config)#interface s0/0/1
R2(config-if)#encapsulation ppp
R2(config-if)#exit
R2(config)#interface G0/0
R2(config-if)#ip add 192.168.30.1 255.255.255.0
R2(config-if)#no sh
R2(config-if)#exit
R2(config)#exit
R2#
%SYS-5-CONFIG_I: Configured from console by console
R2#
R2#copy run start
Destination filename [startup-config]?
Building configuration...
[OK]
R2#
%LINEPROTO-5-UPDOWN: Line protocol on Interface Serial0/0/1, changed state to
up
R2>
R2>config t
^
% Invalid input detected at '^' marker.
R2>config t
^
% Invalid input detected at '^' marker.
R2>en
R2#config t
Enter configuration commands, one per line. End with CNTL/Z.
R2(config)#
R2(config)#username R3 secret class
R2(config)#interface s0/0/0
R2(config-if)#ppp authentiucation pap
^
% Invalid input detected at '^' marker.
R2(config-if)#
R2(config-if)#ppp authentication pap
Must set encapsulation to PPP before using PPP subcommands
R2(config-if)#
R2(config-if)#ppp pap sent-username R2 password cisco
Must set encapsulation to PPP before using PPP subcommands
R2(config-if)#exit
R2(config)#exit
R2#
%SYS-5-CONFIG_I: Configured from console by console
ISP
A summary of U.S. laws governing Cisco cryptographic products may be found at:
http://www.cisco.com/wwl/export/crypto/tool/stqrg.html
If you require further assistance please contact us by sending email to
export@cisco.com.
Router>en
Router#config t
Enter configuration commands, one per line. End with CNTL/Z.
Router(config)#inter
Router(config)#interface s0/0/0
Router(config-if)#encap
Router(config-if)#encapsulation ppp
Router(config-if)#
%LINEPROTO-5-UPDOWN: Line protocol on Interface Serial0/0/0, changed state to
up
Router(config-if)#encapsulation ppp
Router(config-if)#no sh
Router(config-if)#exit
Router(config)#exit
Router#
%SYS-5-CONFIG_I: Configured from console by console
Router>
Router>
Router>confg t
^
% Invalid input detected at '^' marker.
Router>config t
^
% Invalid input detected at '^' marker.
Router>en
Router#config t
Enter configuration commands, one per line. End with CNTL/Z.
Router(config)#
Router(config)#hostname ISP
ISP(config)#username R3 secret cisco
ISP(config)#interface s0/0/0
ISP(config-if)#ppp authentication chap
ISP(config-if)#
%LINEPROTO-5-UPDOWN: Line protocol on Interface Serial0/0/0, changed state to
down
ISP(config-if)#
ISP(config-if)#exit
ISP(config)#exit
ISP#
%SYS-5-CONFIG_I: Configured from console by console
ISP#
ISP#sopy start run
^
% Invalid input detected at '^' marker.
ISP#
ISP#sopy run start
^
% Invalid input detected at '^' marker.
ISP#
ISP#copy run start
Destination filename [startup-config]?
Building configuration...
[OK]
ISP#
ISP#
%LINEPROTO-5-UPDOWN: Line protocol on Interface Serial0/0/0, changed state to
up