All rights reserved. CNH Lep SM160B3001-0NA Printed in USA. May 2007 3001-2 TABLE OF CONTENTS SPECIFICATIONS ......................................................................................................................................................... 2 FUEL RESERVOIR ........................................................................................................................................................ 3 Removal ...................................................................................................................................................................... 3
SPECIFICATIONS See Section 1002
Lep SM160B3001-0NA Issued 05-07
3001-3 FUEL RESERVOIR Removal STEP 1 STEP 6
JS00163A Remove the filter (1).
Park the machine on hard, flat ground. Lower the attachment to the ground. STEP 7 Drain the fuel. STEP 2 Reduce the engine speed to idle for 30 seconds, then STEP 8 shut down the engine. STEP 3 Turn the ignition key to "ON" without starting the engine. STEP 4 Attach a "DO NOT OPERATE" tag to the ignition key in the cab. STEP 5
Disassemble the retaining screws (1), and then
remove the top cover (2). STEP 9
Remove the cap (1).
Disassemble the retaining screws (1), and then
remove the cover (2).
Lep SM160B3001-0NA Issued 05-07
3001-4 STEP 10 STEP 12
Disassemble the retaining screws (1), and then
remove the under cover (2). STEP 13
Disassemble the retaining screws (1) and (2), and
then remove the handle (3). STEP 11
Loosen the hosebands, and then remove the hoses
(1) and (2). Mark the fuel tank and hoses so that they can be connected correctly at the time of assembly. Attach caps or plugs to the fuel tank and hoses to prevent entry of water, dust or dirt. STEP 14
Remove the connector (1).
Disassemble the retaining screws (1) and (2), and
then remove the side cover (3).
Lep SM160B3001-0NA Issued 05-07
3001-5 STEP 15 STEP 18
Disassemble the retaining screws (1).
STEP 16
Connect the 4 shackles to the eyebolts, and then use
the wires and crane to lift the fuel tank. Thoroughly check that the location is safe before lowering the fuel tank on a crosstie. NOTE: When installing, proceed in the reverse order from that of removal.
Disassemble the retaining screws (1) and (2), and
then remove the side cover. STEP 17
Install 4 12-mm eyebolts (1) on top of the fuel tank.
Spray lubricating oil on the eyebolts. Fully tighten the eyebolts, and then loosen them by a half turn.