Professional Documents
Culture Documents
Infrastructure Sector PDF
Infrastructure Sector PDF
Infrastructure Sector
6. INFRASTRUCTURE
6.1 Transportation
Based on the 2017 Road Data of the Department of Public Works and Highways
(DPWH), National Roads traversing the territorial jurisdiction of the Province of Batangas
reached a span of over 555.49 km. All of these roads are paved having 137.50 km or
24.77% made of concrete while 417.98km or 75.31% made of asphalt.
Along these roads are 154 National Bridges with a total length of approximately 4,824
linear meters. All of these bridges are permanent in nature, 4,078m or 84.55% of which
are made of concrete while almost 746 m or 15.46% are made of steel.
National Roads and Bridges in the Province generally have good and fair conditions
based on the condition rating made by DPWH. A total of 24.97 m or 4.49% of roads and
6.66 km or 0.14% of bridges remain in bad condition as shown in Figure 17 and 18
respectively. (Refer to annex 8 for the details)
Table 120: Batangas Permanent Roads, 2017
.
Paved Unpaved
District Engineering Office /
Paved Total Unpaved Total Grand Total
Functional Classification Concrete Asphalt Gravel Earth
Batangas 1st DEO 28.37 134.54 162.91 - - - 162.91
Secondary 26.79 127.14 153.93 - - - 153.93
Tertiary 1.58 7.41 8.98 - - - 8.98
Batangas 2nd DEO 58.82 87.68 146.5 - - - 146.5
Primary - 9.93 9.93 - - - 9.93
Secondary 43.51 57.88 101.38 - - - 101.38
Tertiary 15.31 19.88 35.19 - - - 35.19
Batangas 3rd DEO 37.78 71.43 109.22 - - - 109.22
Primary 0.02 24.51 24.54 - - - 24.54
Secondary 8.52 32.83 41.35 - - - 41.35
Tertiary 29.24 14.09 43.33 - - - 43.33
Batangas 4th DEO 12.53 124.33 136.86 - - - 136.86
Primary 0.30 23.30 23.60 - - - 23.60
Secondary 4.38 46.79 51.17 - - - 51.17
Tertiary 7.85 54.24 62.09 - - - 62.09
137.5 417.98 555.49 555.49
Data
Notes: Source: Department of Public Works and Highways, 2017 Road Data
Notes:
1.) Road
1.data Road
provided data
are as ofprovided
09 November are2017.as of 09 November 2017
2.) The2.unit of The
measureunit of measure
for Road for Road
Data is kilometers . data is kilometres
3. No Assessment refers to Road Sections that are either under construction and/or segments with length below
3.) No Assessment refers to Roadgauging
the 50-meter Sections thatlength
are either under construction and/or segments with length below the 50-meter gauging length.
4. National Roads are classified into
4.) National Roads are classified
Primary Roads into: - roads that connect cities of >100,000 population
Secondary Roads
Primary Roads - roads that connect cities - other roads
of > 100,000 which complement with the national arterial roads to provide access to main
population.
population and production centers of the country.
Secondary Roads - other
Tertiary roads which
Roads- othercomplement
existingwithroads
the national arterialDPWH
under roads to provide
which access to main apopulation
perform and production centers of the country.
local function.
171
Tertiary Roads - other existing roads under DPWH which perform a local function. (In the map, these roads are represented only by letters.)
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
Condition Rating of
National Roads Condition Total Length
4.49% Good
7.06% Good 311.72
8.04% Fair
Fair 134.89
Poor
Poor 44.69
24.28% 56.11% Bad Bad 24.97
No Assessment No Assessment 39.24
Grand Total 555.51
Permanent Bridges
Distrtict
Engineering Office Concrete Steel Total
Number Length Number Length Number Length
Batangas 1st 46 1,475 3 138 49 1,613
Batangas 2nd 26 1,019 9 347 35 1,366
Batangas 3rd 31 852 6 206 37 1,058
Batangas 4th 30 732 3 55 33 787
GRAND TOTAL 133 4,078 21 746 154 4,824
PERCENTAGE 84.55% 15.45% 100%
Data Source: Department of Public Works and Highways, 2017 Bridge Data
Notes:
1. Bridge data are as of 20 November 2017
2. The unit of measure for Bridge Data is Linear meters
3. Further Assessment refers to Bridges that are either under the circumstances of on-going construction
under major maintenance work or washed-out.
4. National Bridges are classified into:
Permanent Bridges are bridges that are composed of concrete and steel
Temporary Bridges are bridges consisting of timber and bailey
Data Source: Department of Public Works and Highway, 2017 Bridge Data
Note: The Unit of measure is in Linear Meter
172
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
Roads classified as Provincial Roads pursuant to Provincial Ordinance No. 002 dated 15
April 2015, has a total length of 514.002km with width ranging from 3m - 6.5m.
This road classification remains unchanged since the promulgation of the ordinance.
Based on the latest evaluation of Provincial Engineering Office, surface conditions of
provincial roads show that almost all roads are in good and fair conditions and only
15.11% or 77.65 km. are in poor condition. (Refer to annex 9 for the details)
Records indicate a total of 137 provincial roads with length that ranged from 2 km. to
17.40 km. and width that ranged from 3 m. to 6.5 m. Along provincial roads are 147
bridges with a total length of floor deck of more or less 1,914 meters. Almost all of these
bridges are in good and passable conditions with the capacity ranging from 5 to 15 tons.
Over 75% of provincial bridges are made of concrete and over 21% are made of steel
while the rest are made up of asphalt, timber and R.C. Pipe. (Refer to annex 9 for the
details)
Infrastructure Sector
Map 1: Road Surface Type & Condition, 2016: District I
174
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
175
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
176
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
177
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
178
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
179
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
Map 7: Bridge Type & Condition, 2016: District III
180
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
181
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
There are a total of 147 provincial bridges in the Province of Batangas as of the year
2017. Around 79% of these are either made up of Reinforced Concrete Design Girder
(RCDG), Concrete or Steel.
The minority of 21% are made up of: 3 baileys, 11 box culverts, 8 flat slabs, 2 spanish
arcs, 4 spillways, and one each of Reinforced Concrete (RC) Pipe, Welded Column
(WC) Pipe and Steel Girder.
All bridges with width varying from 3 to 8 meters are passable except for Sta. Cruz
Bridge which is located at San Pedro-Sta. Cruz Road, Sto. Tomas due to old dilapidated
timber structure. (Refer to annex 10 for the details)
Infrastructure Sector
Based on their records from Land Transportation Office, Planning & Management
Information System (MIS) Unit for calendar year 2017, the number of motor vehicles
registered totalled to 532,269. The New Registration Unit of LTO Region IV-A has the
highest number of motor vehicles registered with 252,720 or 48%, followed by Lipa
District Office with 110,754 or 21%, Batangas District Office with 81,468 or 15%, Balayan
Extension Office with 54,734 or 10%, and Taal Extension Office with 32,593 or 6%.
As to the classification of motor vehicles by fuel used presented in Table 125, private
vehicles account the most number with 495,304, followed by “for hire” vehicles with
34,061, government vehicles with 2,121 and trailer with 783. Out of the 532,269
registered motor vehicles, 441,875 or 83% use gas while 89,272 or 16.77% use diesel
for fuel and only 339 or 0.06% motor vehicles use electric power.
Table 126 shows the renewal registration for private, for hire and government motor
vehicles summed up to 273,474 while there are 258,795 new registered vehicles.
As shown in Table 127, there are different types of motor vehicle registered. This
includes cars, utility vehicles, service utility vehicles, trucks, busses, motorcycles or
tricycles and trailers. Among these types, utility vehicles account the most number with
87,792.
183
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
Table 128: Number of MV Inspected, Registered & Registration Cases Handled: 2017
184
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
There are thirty three (33) existing ports in the Province of Batangas of which six (6) are
government ports and twenty- seven (27) are private ports. (Refer to Tables 130 and
131)
Among the government ports, Batangas International Port in Batangas City is the biggest
and one of Batangas' major assets for development; along with coastlines suitable for
industrial and commercial activities. Conversion of the Port of Batangas into an
International Port of Entry is anticipated to generate massive employment and
investment opportunities.
BASEPORT
1 Batangas
2 Batangas Phase 1
3 Batangas Phase 2
4 Batangas (Anchorage)
TMO-BAUAN
OTP-Bauan
TMO-TABLAS
OTP-Tablas
TMO-ROMBLON
OTP-Romblon
OTHER GOVERNMENT PORTS
1 Ambulong, Occidental Mindoro
2 Azagra, San Fernando, Romblon
3 Cajidiocan, Romblon
4 Calatagan, Batangas
5 Nasugbu, Batangas
6 San Juan, Batangas
Data Source: Philippine Ports Authority, 2017
*RORO- Roll-on/Roll-off **NON-RORO- Non- Roll-on/Roll-offf
185
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
Other Government Ports are the Port of Nasugbu and Port of Calatagan in the First
District, Port of Bauan and Port of Mainaga (Mabini) in the Second District and the Port
of San Juan in the District IV.
FOURTH DISTRICT
1. Port of San Juan Mr. Maceduño U. Banuelos ( 043 ) 723-8704
Brgy. Subukin, San Juan Acting Port Services Division Manager 723-3514
FIFTH DISTRICT
1. Batangas Port Atty. Leopoldo C. Biscocho, Jr. ( 043 ) 723-8704
Port Access Road, Calicanto, Port Manager 723-3514
Batangas City
Data
DataSource:
Source :Philippine
PhilippinePorts
PortsAuthority-
AuthorityPort Management
- Port ManagementOffice,
Office,Batangas
Batangas
The following is a list of Private Ports under PMO BGS according to PPA. Discrepancies
are due to several companies having more than one private port while registered under
the same name. Registration status that follows show the expiration dates based on the
latest data.
The twenty seven (27) private ports were operated and managed by private companies
mostly located along the Batangas Bay Area as of March 2018.
Five (5) are located in Calaca and one (1) in Balayan for a total of six (6) in District I;
one (1) in San Pascual, four (4) in Bauan and seven (7) in Mabini for a total of twelve
(12) in District II while nine (9) are in Batangas City, District V.
186
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
Table 131: List of Registered Ports with Valid Permits as of March 20, 2018
REGISTRATION COR/PTO
ISSUED EXPIRATION COMPANY ADDRESS
STATUS NO.
(COR/PTO NO 5-A) Pilipinas
P/NC 5 4/19/1993 4/19/2043 Tabangao, Batangas City
1 Shell Petroleum Corp. (Jetty 4)
(COR/PTO NO 5 ) Pilipinas Shell
T/NC 5 7/14/2015 7/13/2020 Tabangao, Batangas City
2 Petroleum Corp. (Jetties 1, 2 & 3)
San Miguel Mills, Inc. (Formerly
issued to San Miguel Foods, Inc.
T/NC 13 5/5/2014 5/4/2019 Tabangao, Batangas City
and originally granted to Pacific
3 Flour Mills, Inc.)
Chervon Phils. Inc. (CPI)
4 P/NC 60 3/26/1999 12/4/2023 San Pascual, Batangas
(Formerly Caltex (Phils.,) Inc.)
5 P/NC 92 10/24/2011 11/25/2020 Batangas Bay Terminal Inc. Bolo, Bauan, Batangas
Brgy. Aplaya, Bauan,
6 T/NC 193 4/28/2014 4/27/2019 United Coconut Chem., Inc.
Batangas
Pinamucan, Tabangao,
7 T/NC 202 9/30/2013 9/29/2018 Himmel Industries Inc.
Batangas
SEM-Calaca Power Corporation
Bo. San Rafael, Calaca,
T/NC 241 7/1/2012 6/30/2017 (Formerly National Power
8 Batangas
Corporation)
LMG Chemical Philippines
9 P/NC 262 6/16/2008 10/23/2031 Pinamucan, Batangas
(Formerly Chemphil-LMG, Inc.)
10 P/C 291 10/8/1996 5/3/2021 PNOC-EC/ESB Mabini, Batangas
Bo, Sta. Rita, Karsada,
11 P/NC 344 7/28/1999 5/25/2023 First Gas Power Corp.
Batangas
Brgy. Mainaga, Mabini,
P/NC 351 7/8/1998 6/2/2023 Suntrak Corporation
12 Batangas
Mainaga, Mabini,
13 P/NC 353 4/27/2000 8/31/2018 Petron Corporation
Batangas
PNOC Exploration Corporation
San Miguel, Bauan,
P/NC 357 5/9/2008 5/8/2031 (Formerly PNOC Coal
14 Batangas
Corporation)
FARMIX (Formerly Bulk Handlers, Brgy. Calamias, Mabini,
P/NC 367 2/8/1999 2/11/2019
15 Inc.) Batangas
Bacnotan Industrial Park Corp.
P/NC 370 4/6/1999 7/22/2022 Calaca, Batangas
16 (BIPC)
P/NC 374 1/26/2004 1/17/2021 National Power Corporation Brgy. Ilijan, Batangas City
17
18 T/NC 380 11/11/2015 11/10/2020 Lucky One Realty Ventures, Inc. Brgy. Mabini, Batangas
Brgy. Talisay, Calaca,
19 P/NC 398 1/1/2009 7/29/2029 Balayan Distillery, Inc.
Batangas
Bo. Sta. Marian, Bauan,
T/NC 415 5/8/2014 5/7/2019 EEi Corporation
20 Batangas
Brgy. Mabacong,
P/NC 430 10/21/2011 5/11/2035 Tiger land Realty Corporation
21 Batangas, City
Golden Bay Grain Terminal Brgy. Bulacan, Mabini,
22 T/NC 447 8/22/2014 8/21/2019
Corporation Batangas
Brgy. San Rafael, Calaca,
T/NC 457 4/1/2014 3/31/2019 South Bay Bulk Terminal, Inc.
23 Batangas
Batangas Agro-Industrial
24 T/NC 463 6/16/2014 9/21/2018 Pinamucan, Batangas
Development Corporation
Brgy. Puting Bato West,
25 T/NC 468 9/18/2014 9/17/2019 Phoenix Petroterminals
Calaca, Batangas
Brgy. Guimalas, Balayan,
T/NC 493 1/1/2017 12/31/2021 Empire East Land Holdings, Inc
26 Batangas
Mr. Rolando M. Magsino Brgy. San Juan, Mabini,
27 P/NC 496
(Landoor Pier) Batangas
Data Source: Philippine Ports Authority
Note: T/NC-Temporary/Non-Commercial T/C-Temporary/ Commercial
P/NC-Permanent/ Non-Commercial P/C- Permanent/ Commercial
187
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
As of November 2018, there are 12 Shipping Lines registered with a total of 49 vessels.
Routes are from Batangas City to Calapan, Abra de Ilog, Odiongan-Romblon, Corcuera-
Romblon, Puerto Galera and Isla Verde.
Maritime Industry Authority (MARINA) has a total of 6,231 vessels recorded in Batangas.
From the majority of vessels registered, 3,419 are passenger, 2,172 ships are fishing
vessels, and 425 are cargos.
188
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
189
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
190
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
In comparison to the Port of Manila, the Port of Batangas recorded six times more
commuters in year 2017. Passenger traffic statistics show that a total of 1,322,115
passengers embarked, disembarked and in cruise ship at Port of Manila compared to
7,933,814 passengers at Port of Batangas.
Passenger Traffic Disembarked Embarked Cruise Ships Total Disembarked Embarked Cruise Ships Total
Passenger Count 633,654 629,654 58,807 1,322,115 4,364,635 3,568,354 825 7,933,814
*Combined statistics for NCR North, NCR South and MICT **TEUs= Twenty Equivalent Unit Container
Data Source:
Data Source: Philippine
Philippine Ports Authority, Port Management Office, Batangas
Ports Authority
Fernando Air Base (FAB), a Philippine Air Force (PAF) facility, is the only civil military-
airport facility in the Province. It is located in Lipa City, Batangas, about 83 kilometer
South- South East (SSE) of Manila, Philippines. It is 1,220 feet (370 m) above sea level
and is situated on a plateau overlooking Taal Volcano with an area of 712 acres (288
hectares) of land which keep its climate temperature cool all day.
191
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
The power supply requirement of Batangas Province is being supplied by the National
Power Corporation (NPC) through Manila Electric Company (MERALCO), Batangas
Electric Cooperative (BATELEC I & II), and by a private electric company, First Bay
Power Corporation and Ibaan Electric Light System.
The power needs of Batangas City, San Pascual and Sto. Tomas are provided by
MERALCO, Bauan was formerly managed by the municipal electric light system and was
turned over to a private provider in 2005, the First Bay Power Corporation (FBPC) while
Ibaan is serviced by Ibaan Electric Engineering Corporation (IEEC). BATELEC I which is
located in Calaca, Batangas covers the Municipalities of Agoncillo, Balayan, Calaca,
Calatagan, Lemery, Lian, Nasugbu, San Luis, San Nicolas, Sta. Teresita, Taal and Tuy
while BATELEC II in Lipa City covers the Municipalities of Alitagtag, Balete, Cuenca,
Laurel, Lobo, Mabini, Malvar, Mataasnakahoy, Padre Garcia, Rosario, San Jose, San
Juan, Talisay, Taysan and Tingloy and the Cities of Lipa and Tanauan and barangays
Sico and Talumpok in Batangas City.
IBAAN ELECTRIC
ENGINEERING Servicing the Municipality of Ibaan
CORPORATION
192
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
Out of 1,078 barangays of Batangas Province, only 7 or 0.65% are not yet energized.
These are Calawit, Balete; Alas-as and Pulang Bato, San Nicolas; and De la Paz
Proper, De la Paz Pulot Itaas, De la Paz Pulot Aplaya and Talahib Pandayan, Batangas
City.
Although 1,071 barangays are energized, there are still sitios in some barangays without
access to electricity. These are from the Municipalities of Agoncillo, Balayan, Calatagan,
Laurel, Lobo, Malvar, Mataasnakahoy, Nasugbu, Padre Garcia, San Juan, San Luis,
Talisay, Taysan, Tingloy and Tuy. Verde Island from Batangas City has barangays which
are energized through solar cell/panels.
BRGY.
ENERGIZED
ENERGIZED
CITY/ NO. OF BRGY. WITHOUT
THROUGH SITIO WITHOUT ELECTRICITY
MUNICIPALITY BARANGAY ELECTRICITY
SOLAR
CELL/PANELS
So. Ibaba, Banaba South; So. Kanluran, Brgy.
(Isla Verde) San
Dela Paz Proper; Dela Banaba South; Purok 1, So. III, Brgy. Mahabang
Agapito; San
Paz Pulot Itaas; Dela Paz Parang; So. Silangan, Brgy. Banaba South; So.
Batangas City 105 100 5 Agustin; San
Pulot Aplaya; Talahib Kanluran, Maapaz; So. Pulo, Maaapaz, So. Ilaya,
Andres; San
Pandayan; Isla Verde Maapaz; So. Maanunang, Talahib Pandayan; So.
Antonio; Liponpon
Tibig, Talahib Pandayan;
Lipa City 72 72 0
Tanauan City 48 48 0
Agoncillo 21 21 0 So. Bayabasan, Barigon; So. Lucas, Bilibinwang
Alitagtag 19 19 0
So. Caybunga, Patugo; So. Maragat Dagat, Patugo;
Balayan 48 48 0
So. Sahing Patugo
Balete 13 12 1 Brgy. Calawit, Volcano Is
Bauan 40 40 0
Calaca 40 40 0
Calatagan 25 25 0
Cuenca 21 21 0
Ibaan 26 26 0
Laurel 21 21 0
Lemery 46 46 0
Lian 19 19 0
So. Banoy, Brgy. Banalo; So. Baluarte, Brgy. San
Nicolas, So. Tabuko, Brgy. San Nicolas, So.
Lobo 26 26 0
Mariwasa, Brgy. Biga; So. Tulay na Busog, Brgy.
Bignay
193
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
UNENERGIZED
BRGY.
ENERGIZED
ENERGIZED
CITY/ NO. OF BRGY. WITHOUT
THROUGH SITIO WITHOUT ELECTRICITY
MUNICIPALITY BARANGAY ELECTRICITY
SOLAR
CELL/PANELS
Mabini 34 34 0
Malvar 15 15 0 So. Luta Sur, Brgy. Maligaya
Mataasnakahoy 16 16 0 Munting Sulok, Bayorbor; Kinaiputan, Santol
So. Kwako, Banilad; So. Kabot, Bulihan; So.
Matahong Butucan; So. Pingkian, Latag; So.
Bayabas, Looc; So. Bernanda, Latag, So.
Nasugbu 42 42 0
Bungahan, Mataas na Pulo; So. Kaytiw, Mataas na
Pulo; So. Hamilo, Papaya; So. Bayabas, Putat; So.
Tibagan, Utod
Umali Compound, San Felipe; Rizare Compound
Padre Garcia 18 18 0
Maugat
Rosario 48 48 0
San Jose 33 33 0
So. Lambak, Brgy. Barualte; (So.)Phase 2, Marilas,
San Juan 42 42 0 Brgy. Marilas; So. Kidkid, Brgy. Pulangbato; Gawad
Kalinga, Brgy. Janao-Janao
San Luis 26 26 0 Sitio Tulo, Muzon
Brgy. Alas-as; Brgy.
San Nicolas 18 16 2
Pulang Bato
Green Dream Subdivision, So. Nangkaan,
Poblacion; Kaingin; san Mateo; So. Ibaba, antipolo;
San Pascual 29 29 0
Dimatactac Road; So. Nangkaan; Perfectos
Compound, So. Nangkaan
Sta. Teresita 17 17 0
Sto. Tomas 30 30 0 Ulila Street, Brgy. San Jose
Taal 42 42 0
Talisay 21 21 0 Sitio Camantigue, Brgy. Tumaway
So. Maynila, Brgy. Bacao; So. Guinhawa, Brgy.
Taysan 20 20 0 Mahanadiong, So. Masambong, Brgy. Guihawa; So.
Gabihan, Brgy. Piña; So. Atsuete, Brgy. Piña
So. Bagong Sikat 1 & 2, Brgy. San Pedro; So. Pook,
Tingloy 15 15 0 Brgy. Sto. Tomas; So. Hulo, Brgy. Payapa; So.
Capiz, Brgy. Payapa; So. Bago, Brgy. Talahib
Tuy 22 22 0 Sitio Niogan, Putol
Data Source: Local Government Units
194
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
Total installed capacity of power plants throughout Batangas reached over 4,780.90 MW
(Megawatts) as of September 2018. First Gas Power Corporation provides 2,073.90
MW which accounts for almost half of the power supply throughout the province.
GRID-CONNECTED
1. COAL 1,170.0 1,093.9
Pulvurized Sub
CALACA U1 300.0 270.0 1 Calaca, Batangas
Critical Coal SEM Calaca
September 1984
Pulvurized Sub Power Corp.
CALACA U2 300.0 300.0 1 Calaca, Batangas
Critical Coal
Circulating Fluidized
SLPGC U1 150.0 140.0 1 Calaca, Batangas Southwest Luzon
Bed (CFB) Coal
Power
July 2016
Circulating Fluidized Generation
SLPGC U2 150.0 140.0 1 Calaca, Batangas
Bed (CFB) Coal Corporation
SLTEC PUTING BATO Circulating Fluidized
135.0 121.0 1 Calaca, Batangas Unit 1 - April 2015
U1 Bed (CFB) Coal South Luzon
Thermal Energy
SLTEC PUTING BATO Circulating Fluidized
135.0 122.9 1 Calaca, Batangas Corporation Unit 2 - February 2016
U2 Bed (CFB) Coal
2. OIL-BASED 62.4 58.0
2.2. Diesel 62.4 58.0
Republic Cement
Bunker/Diesel Internal
and Building
RCBMI Combustion 12.4 12.0 2 Taysan, Batangas July 2014
Materials
Engine
Inc.
Southwest Luzon
Power
SLPGC U3 Modular Gas Turbine 25.0 23.0 1 Calaca, Batangas March 2018
Generation
Corporation
Southwest Luzon
Power
SLPGC U4 Modular Gas Turbine 25.0 23.0 1 Calaca, Batangas March 2018
Generation
Corporation
3. NATURAL GAS 3,451.5 3,286.1
Open Cycle Gas Prime Meridian
AVION 100.6 97.0 2 Bolbok, Batangas City August 2016
Turbine (OCGT) PowerGen Corp.
Combined Cycle Gas KEPCO (Ilijan)
ILIJAN 1,277.0 1,200.0 6 Ilijan, Batangas City June 2002
Turbine (CCGT) Corp.
Combined Cycle Gas First NatGas Power
SAN GABRIEL 430.0 420.0 1 Sta. Rita, Batangas City July 2016
Turbine (CCGT) Corp.
Combined Cycle Gas First Gas Power
SAN LORENZO 549.1 526.6 2 Sta. Rita, Batangas City September 2002
Turbine (CCGT) Corp
Combined Cycle Gas First Gas Power Unit 1&2 - June 2000
SANTA RITA 1,094.8 1,042.5 4 Sta. Rita, Batangas City
Turbine (CCGT) Corp Unit 3&4 - October 2001
4. SOLAR 63.0 44.1
Solar Philippines
Ground Mounted Solar Calatagan and Balayan,
CALATAGAN SOLAR 63.0 44.1 Calatagan March 2016
PVs Batangas
Corporation
EMBEDDED 34.0 33.6
1. GEOTHERMAL 32.0 32.0
Flash Type Steam Maibarara
MAIBARARA 20.0 20.0 1 Sto. Tomas, Batangas February 2014
recovery Geothermal Inc.
Flash Type Steam Maibarara
MAIBARARA U2 12.0 12.0 1 Sto. Tomas, Batangas
recovery Geothermal Inc.
2. SOLAR 2.0 1.6
Ground Mounted Solar Absolut Distillers
LIAN SOLAR 2.0 1.6 Lian, Batangas March 2016
PVs Inc.
TOTAL 4,780.90 4,515.70
Data Source: Department of Energy
195
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
Majority of power production of the Province comes from natural gas power plants
representing 72% of the total power capacity while plants powered by coal represent
25% of power generation and the remaining 1% each for solar, geothermal and oil-based
power plants.
The oldest power plant operating since 1979 is the Macban Geothermal Plant with an
area of 40 hectares located at Sto. Tomas. Others are Sta. Rita Power Plant – First Gas
Power Corporation located at Brgy. Sta. Rita Aplaya and Brgy. Sta. Rita Karsada,
Batangas City with an area of 35 hectares started operating since 2000; San Lorenzo
Power Plant – First Gas Power Corporation located at Brgy. Sta. Rita Aplaya and Brgy.
Sta. Rita Karsada, Batangas City with an area of 23 hectares, operating since 2002;
KEILCO Power Plant, KEPCO – Ilijan Power Corporation located at Brgy. Ilijan,
Batangas City with an area of 25 hectares operating since 2000; Calaca Coal Power
Plant – SEM Calaca Power Corporation located at Brgy. San Rafael, Calaca with an
area of 167 hectares operating since 1981; and Maibarara Geothermal Power Plant
located at Brgy. San Rafael, Sto. Tomas with an area of 25 hectares operating since
2000.
196
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
Year of
Name of Power Plant Location Plant Area Contact Number Owner
Operation
1 Sta. Rita Power Plant Brgy. Sta. Rita Aplaya & (+632) 449-6400 Subsidiary of First
First Gas Power Corporation Brgy. Sta Rita Karsada 35 has 2000 (+632) 637-8366 Gas Holdings Corp.
Batangas City
2 San Lorenzo Power Plant Brgy. Sta. Rita Aplaya & Conglomerate of
First Gas Power Corporation Brgy. Sta Rita Karsada 23 has. 2002 910-3040 First Gas Holdings
Batangas City Corporation
3 KEILCO Power Plant Subsidiary of Korea
KEPCO- Ilijan Power Brgy. Ilijan, Batangas City 25 has. 2000 (+632)395-1300 Electric Power
Corporation (+632)395-1324 Corporation
4 Calaca Coal Power Plant Brgy. San Rafael, Calaca (+632)436-1858 (Operated
SEM Calaca Power Batangas 167 has 1981 (+632)436-1858 David M. Consunji,
Corporation Inc. (DMCI)
5 Macban Geothermal Plant Sto. Tomas, Batangas 40 has 1979 ___ under the management
(Parcel) of Aboitiz
6 Maibarara Geothermal Brgy. San Rafael, 25 has. 2000 (+632) 637-2917 Majority owner
Power Plant Sto. Tomas, Batangas (+632) 637-4362 PetroEnergy
Resource Corp.
Data Source: Department of Energy, 2015
There are also a total of thirteen (13) indicative power projects which are expected to
generate an additional of 5,041 MW power capacities, some of which are expected to
operate by year 2019 to 2023. These projects include three (3) coal fired power plants,
two (2) natural gas plants, six (6) solar power projects, one (1) wind power project and
one (1) biomass project.
197
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
Table 138: Private Sector Initiated Power Project / Indicative Power Projects,
as of September 2018
RATED TARGET
PROJECT TARGET TESTING &
NAME OF THE PROJECT LOCATION CAPACITY COMMERCIAL
PROPONENT COMMISSIONING
(MW) OPERATION
COAL
SRPGC 2x350MW Coal‐Fired St. Raphael Power Brgy. San Rafael,
700 June 2022 June 2023
Power Plant Project Generation Corporation Calaca, Batangas
Merbau Coal-Fired Thermal Brgy. Pinamukan
Merbau Corporation 600 TBD TBD
Power Plant Ibaba, Batangas City
1,800
SMC Global Power ( Ph1 ‐ 2 x 600 )
SMC Ilijan LNG Power Plant Batangas ( Ph2 ‐ 2 x 600 )
TBD TBD
Holdings Corp
( Ph3 ‐ 2 x 600 )
NATURAL GAS
500 MW VIRES LNG‐FIRED Batangas Bay area,
VIRES Energy Corporation 500 TBD TBD
POWER BARGE PROJECT Batangas
1 x 450 Sta. Maria Power Plant First Gen Ecopower Sta. Rita,
450 TBD TBD
(Phase II) Solutions Inc. Batangas City
SOLAR
Earthenergy Solar Power Plant Earthenergy Corp. Balayan, Batangas 30 April 2019 May 2019
Infrastructure Sector
The water supply needs of the different municipalities and cities of Batangas Province
particularly for domestic purposes are being provided by existing water districts,
municipal water system and barangay waterworks associations.
6.3.2 Water Districts, Municipal Water System (MWS), Barangay Water Program-Rural
Waterworks and Sanitation Associations (BWP-RWSAs), Barangays without Water
System
The municipalities that have existing operational BWP-RWSA aside from existing water
districts are Agoncillo, Balete, Lobo, Mabini, Malvar, Taal, Tuy and the City of Tanauan.
Aside from existing municipal water system, the municipalities of Cuenca and San
Pascual have also existing operational BWP-RWSA. Other operational BWP-RWSAs
are located in the municipalities of Ibaan, Laurel, Padre Garcia, San Nicolas and Sta.
Teresita. Some BWP-RWSAs are no longer operational; some are non-BWP and
separated RWSAs.
Table 139: List of Water Districts and Municipality Water Systems as of 2016
MUNICIPAL
NO. OF WATER BARANGAYS WITHOUT WATER
CITY/MUNICIPALITY WATER BWP-RWSAs
BARANGAY DISTRICT SYSTEM
SYSTEM
Batangas City 105 LWUA
Lipa City 72 LWUA
Banjo West, Luyos-Altura Bata-
San Jose, Mabini, Pagaspas,
Tanauan City 48 LWUA Talaga, Suplang-Sulpoc-
Montaña, Montaña***, Janopol
II***, Santor***
Pamiga-Pook-Bangin, Subic Ilaya
Agoncillo 21 LWUA Barigon, Bilibinwang, Banyaga, Adya
& Ibaba
Alitagtag 19 LWUA
Malalay, Dilao, Tactac, Tanggoy,
Balayan 48 LWUA
Duhatan
Balete* 13 LWUA Malabanan
San Agustin, San Andres, New
Bauan 40 x Danglayan, Poblacion (inside Bauab
Tech.)
So. Matala, Cahil/ Tamayo/ Munting
Calaca 39 Makina-Pantay**
Coral
Bagong Silang, Sta. Ana, Tanagan,
Calatagan 25 Lucsuhin**, Real-Sambungan**
Carlosa, Luya, Paraiso, Luksuhin
Cuenca 21 x Emmanuel
Catandala-Mabalor-Panghayaan, Matala, San Agustin, Pangao, Quilo,
Ibaan 26 x
Tulay-Calamias Munting Tubig, Lucsuhin
Dayap Itaas, Sta. Maria, San Gabriel,
Laurel 21 Poblacion
Molinete
So. Bagong Paraiso, San Isidro
Lemery 46 LWUA Mayasang Water System
Itaas/Niogan
* included in Metro Lipa Water District
** not operational BWP-RWSAs
*** non-BWP & separated RWSAs
199
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
(continuation) Table 139: List of Water Districts and Municipality Water Systems as of
2016
MUNICIPAL
NO. OF WATER BARANGAYS WITHOUT WATER
CITY/MUNICIPALITY WATER BWP-RWSAs
BARANGAY DISTRICT SYSTEM
SYSTEM
Lian 19 LWUA Matabungkay-Luyahan**
Biga, Bignay, Calo, Malalim na
Lobo 26 LWUA Fabrica-Masaguitsit Sanog, Nagtoctoc, San Nicolas,
Sawang, Soloc, Tayuman
Sto. Tomas, Estrella, Laurel, Pilahan,
Pulang Lupa, Pulong Anahaw, Sta.
Mabini 34 LWUA Anilao East-Proper-Majuben Mesa, Sto. Niño, Solo, Ligaya,
Bagalangit, San Teodoro, Mainit, Nag-
iba, Malimatoc 1&2
200
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
The Cities of Batangas, Lipa and Tanauan have their own water districts. The
Municipalities of Malvar, Mataasnakahoy and Balete are supplied by Metro Lipa Water
District in Lipa City.
Data for water districts presented are consolidated by the Provincial Planning and
Development Office (PPDO) from the existing water districts and respective local
government units as shown in Table 140. Total connections reported reached 192,124,
where, almost 94% or 180,362 connections are residential while the remaining 6% are
either commercial or industrial.
There are two types of water sources as reported by different Water District, the surface
water source and the ground water source. Surface water and groundwater are both
important sources for community water supply needs. Groundwater is a common source
for single homes and small towns, rivers and lakes are the usual sources for large cities.
Although approximately 98% of liquid fresh water exists as groundwater, much of it
occurs very deep in the Earth. This makes pumping very expensive, preventing the full
development and use of all groundwater resources.
Table 141 shows the water resources of different water districts in the Province. Lobo
and Taysan Water Districts use surface water while the rest are using ground water.
Meanwhile, Table 142 shows the estimated rate of water service in the first 30mᶟ
consumption. Record shows that among the sixteen (16) Water Districts, Agoncillo Water
District has the highest rate ranging from ₱27.20 to ₱36.25 for the first 30mᶟ while
Lemery Water District has the lowest water rate per cubic meter ranging from ₱15.00 to
₱17.50 per cubic meter.
Non-revenue water (NRW) is water that has been produced and is "lost" before it
reaches the customer. Losses can be real losses (through leaks, sometimes also
referred to as physical losses) or apparent losses (for example through theft or metering
inaccuracies). High levels of NRW are detrimental to the financial viability of water
utilities, as well to the quality of water itself. NRW is typically measured as the volume of
water "lost" as a share of net water produced. However, it is sometimes also expressed
as the volume of water "lost" per km of water distribution network per day.
Non-Revenue water and targets are shown in Table 143. Balayan Water District having
the highest percentage of non-revenue water from 55% in 2005 and 54% in 2010
reduced to 44% on the latest data in 2015 and target to trimmed by 20% in 2020 and
18% in 2025.
Some of the factors in water losses are due to unbilled authorized consumption,
Apparent losses (water theft and metering inaccuracies), and Real losses (from
transmission mains, storage facilities, distribution mains or service connections).
201
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
202
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
Table 142: Estimated Rate of Water Service in terms of Peso per Cubic Meter (₱/mᶟ),
2017
Name of City/
0-10 m3 11-20 m3 21-30 m3
Municipality
Agoncillo 27.20 33.25 36.25
Alitagtag 27.00 28.00 29.50
Balayan 20.20 23.20 26.45
Batangas City 20.50 22.50 24.70
Lemery 15.00 16.00 17.50
Lipa City 17.25 18.90 21.40
Lobo 27.00 28.30 30.00
Mabini 27.04 30.40 34.25
Nasugbu 19.50 22.00 23.95
Rosario 16.00 19.00 20.50
San Juan 21.00 22.50 25.00
Sto. Tomas 12.00 18.00 25.00
Taal 22.00 23.40 25.20
Tanauan City 23.98 25.45 29.30
Taysan 20.68 22.70 24.00
Tuy 18.00 19.30 20.20
Data Source: Provincial Planning and Development Office
Infrastructure Sector
San Juan Water District Mrs. Lilian P. Alcantara (043) 575-3512 sjwd_055@yahoo.com
Infrastructure Sector
The water supply of Bauan, Cuenca, San Jose, Padre Garcia and San Nicolas are from
their own municipal water systems which are classified as Level III, Residential,
Residential with Commercial Activities, Commercial, Institutional and Industrial.
Cuenca Pump # 1 2" 592 metered ½" 224.00 311.00 318 cu.m/day
Pump # 2 2" (Level I I) ½" 28.00 31.00 36.00 36.00
Pump # 3 2" ½"
San Jose Two (2) 7.5 HP 6" 500 Estimated Residential 1/2 60.00 4.20 5.40 6.60 6.60 6.60 chlorination 897
Submersible Pump 4" 4,936 Residential A 1/2 60.00 4.80 6.00 7.20 7.20 7.20 chlorination 76
2" w/ Commercial
Activities
Two (2) Spring Source 8" 4,000,000 Commercial, 1/2 130.00 8.45 9.75 13.65 13.65 13.65 chlorination 126
6" Institutional
4" & Industrial
San Nicolas Municipal WS 2" Full 1,500 100.00 20.00 20.00 20.00 20.00 130 cu.m / day
Infrastructure Sector
Other water sources include community water system, deep well, artesian well,
dug/shallow well owned and shared bottled water, river stream, lake, and other bodies of
water and tanker truck/peddler.
There are eleven (11) municipalities and one (1) city around Taal Lake. They are
Agoncillo, Alitagtag, Balete, Cuenca, Laurel, Malvar, Mataasnakahoy, San Nicolas, Sta.
Teresita, Taal, Talisay and Tanauan City. Six (6) springs can be found in the
Municipalities of Laurel, Bauan, Ibaan, San Jose and in the City of Tanauan. On the
other hand, there are forty-eight (48) rivers which can be found in different cities and
municipalities in the Province.
206
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
207
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
Cell phone is one of the most important gadgets as a mean of communication. As shown
in Table 147, Top 3 numerous cell site networks are located in Batangas City, Lipa City
and Bauan. Government Postal Services are available in all cities and municipalities in
the Province.
No. of No. of
Internet Telephone No. of Broadcast Station & Network Cable TV
City/ Municipality
Service Service Cell Sites Providers
Providers Providers AM FM TV
TOTAL 401 0 12 2 43
Batangas City 8 5 63 0 7 2 2
Lipa City 7 6 51 0 2 0 1
Tanauan City 7 5 25 0 0 0 3
Agoncillo 5 4 5 0 0 0 1
Alitagtag 4 4 5 0 0 0 2
Balayan 5 6 12 0 0 0 2
Balete 3 3 3 0 0 0 1
Bauan 5 5 15 0 0 0 2
Calaca 5 5 12 0 0 0 1
Calatagan 5 6 12 0 0 0 1
Cuenca 6 5 7 0 0 0 1
Ibaan 5 5 9 0 0 0 2
Laurel 2 2 2 0 0 0 1
Lemery 5 5 12 0 1 0 1
Lian 5 5 10 0 0 0 1
Lobo 2 2 2 0 0 0 1
Mabini 6 5 11 0 0 0 1
Malvar 5 5 6 0 0 0 3
Mataasnakahoy 5 5 3 0 0 0 1
Nasugbu 5 5 29 0 0 0 1
Padre Garcia 5 4 5 0 0 0 1
Rosario 5 5 13 0 0 0 2
San Jose 6 5 16 0 0 0 1
San Juan 6 5 8 0 0 0 1
San Luis 4 4 5 0 0 0 1
San Nicolas 2 2 3 0 0 0 1
San Pascual 6 5 12 0 0 0 1
Sta. Teresita 6 4 2 0 0 0 2
Sto. Tomas 6 5 22 0 2 0 1
Taal 6 5 4 0 0 0 1
Talisay 3 3 3 0 0 0 1
Taysan 3 3 5 0 0 0 0
Tingloy 1 3 3 0 0 0 0
Tuy 5 5 6 0 0 0 1
Data Source: National Telecommunication Commission, Region IV
208
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
Globe Telecom Nasugbu Cable Landing Station (CLS) is Globe Telecom’s first landing
station. Globe started construction of the Batangas cable landing station in October
2000. The actual construction of the building was finished by end-March 2001. Globe
Telecom inaugurated on November 15, 2001 its US$25-million (PhP1.3-billion) cable
landing station and backhaul facility in Nasugbu, Batangas which is part of the
company's participation in the transnational City-to-City (C2C) Cable Network Project.
Globe is both the owner and backhaul provider of this station. Cable Systems in this
facility includes SJC (Southeast Asia Japan Cable) and C2C (City-to-City Cable Network
Project). Most connections to cities from other countries, provided by Globe, use this
facility in Nasugbu, Batangas.
Data Source: IP Peering Perspective from a Philippine Carrier, Francisco "Cocoy" Claravall, VP - Product Development &
Management at Globe Telecom
209
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
Philippine Long Distance Telephone (PLDT) Batangas Cable Landing Station located in
Nasugbu, Batangas and the first international cable landing station in the Philippines
covers several cable systems including Asia-Pacific Cable Network (APCN), Asia-Pacific
Cable Network 2(APCN-2) and South East Asia-Middle East- Western Europe 3 or SEA-
ME- WE 3 (SMW3).
Source: https://www.retailnews.asia/
The APCN-2 is a 19,000-km optical fiber submarine cable system linking Japan, Korea,
China, Taiwan, Hong Kong, Philippines, Malaysia, and Singapore in a ring configuration,
with four fiber pairs connecting 10 submarine cable landing stations in Asia region.
The APCN-2 is the first submarine cable system that has a self-healing function in the
Asia Region, and is capable of restoring itself instantly with its ring configuration when a
failure occurs in a part of the system. It has a design capacity of 2.56 Terabytes per
Second (TBps) by operating with 64x10 Gigabytes per Second (Gbps) Dense
Wavelength Division Multiplexing (DWDM) technology.
SMW3 is the longest Submarine Cable in the world led by France and China.
210
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
Telegraph/ Telegram/ Messengerial TELOF-DOTC, WWW Express (formerly DHL), JRS Business
Cargo Services Corp., LBC Express, Inc., Universal Sup Inc.
37 Post Offices strategically located at different cities and
Postal Services municipalities.
Data Source: Local Government Units
211
SOCIO ECONOMIC AND PHYSICAL PROFILE
Infrastructure Sector
According to Philippine Information Center- Batangas, they have listed some of the local
newspapers in the Province of Batangas which includes Sunstar Peoples Courier,
Batangas Post, Pahayagang Balikas, Balaraw Journal, Headlines News Today, Dyaryo
Veritas, Dyaryo Balisong, which services the entire Province of Batangas. Weekly
Frontpage, Southern Tagalog Herald and Pantas ng Batangas were also listed as local
newspapers servicing some municipalities in Batangas.
212