Professional Documents
Culture Documents
Elect Test 20.03.2019
Elect Test 20.03.2019
2019
1. If the induction motor speed at no-load is 745 RPM, what is the speed of the motor:
a. 700 RPM
b. 750 RPM
c. 800 RPM
d. 850 RPM
2. Synchronous speed for motor 1600 RPM, 60Hz, calculate number of poles.
a. P = 2
b. P = 4
c. P = 6
3. At what region of operation is the base emitter junction forward biased and the base collector
Junction reverse biased for BJT.
(a) Saturation
(b) Linear or active
(c) Cut-off
(d) None of the above
4. What is the role of the Zener diode?
a. Rectification
b. Amplification
c. voltage regulation
5. The heat loss inside a straight conductor is 60J upon applying current I for 5s. if the resistance of
the conductor is decease to half, and the same current is applied for 5s, what will be the heat
dissipation:
a. 60J
b. 30J
c. 15J
d. 120J
6. Why we use power factor correction device to
a. Mitigate PF
b. increase PF
c. Getting PF
d. None of the above
7. What does the power factor stands for?
a. Cosine of the angle between voltage and current.
b. Sine of the angle between voltage and current.
c. Apparent power over real power.
8. Rotor of Induction motor is rotating at synchronous speed, what is Torque?
a. High
b. Low
c. Zero
d. Infinity
Unrestricted
9. The underground cable is laid in a marine environment at system voltage, A. what shall be the
design of the cable insulation
a. (1/√3) *A
b. √3 * A
c. √2 * A
d. 2 A
10. Cable length is 1000 m, time of returning signal is 9.43 µ sec what is speed of wave in the cable?
a. 0.35
b. 0.75
c. 1
d. 2.1
11. We have something = 10 X 10-6 and current through it is 6 X 10-3 and this thing Dh = I X T what is
the period will be taken?
a. 9 months
b. 18 months
c. 24 months
d. 30 months
Hint: the values are not correct, but it is easy, law is given
12. For the shown block diagram
what is the damping ratio
a. 0.4
b. 0.63
c. 0.7
d. 2.82
e.
13. 10 HP single phase motor, 0.8 P.F., 240 V, Efficiency = 0.6, what is the current?
a. 70 A
b. 52.5 A
c. 64.76
d. 90 A
Hint:
Pout = η X Pin Pout = η V I cos Ɵ 746 X 10 = 0.6 X 240 I X (0.8) I = 64.76 A
Unrestricted
15. Which of the following is not the opportunity to do the project?
a. Demand of the product
b. Emerging markets
c. Lot of manpower
d. Favorable exchange rates
e. None of these are Organizational opportunities
Unrestricted