Professional Documents
Culture Documents
Garlock
S E A L I N G T E C H N O L O G I E S ®
Garlock Kammprofile Gasket
Superior Performance
Serrated solid metal core Soft, deformable seal-
■ Serrations concentrate bolt load on ing material
small area for tight seals at lower ■ Under compression, fills seating
stress surface imperfections to form a
■ Solid metal core resists cold flow, tight, metal-to-metal connection
overcompression and blowout ■ Seals under low stress—ideal
■ Rigid core provides exceptional for weaker flanges
stability, even in large sizes, and ■ Withstands extreme fluctuations
facititates handling and installation in temperatures and pressures
Male/Female
Raised Face
■ Integral centering ring en-
Flat Face
Floating
Garlock
Integral
a = 0.4
1000
Tps = 16219
Tps = 16219
WARNING:
Properties/applications shown throughout this
Gb = 368
brochure are typical. Your specific application
GA20RT01 should not be undertaken without independent
GA20RT02 study and evaluation for suitability. For specific
To Gs = 27.7 application recommendations consult Garlock.
GA20RT03
Failure to select the proper sealing products
100 could result in property damage and/or serious
1 10 100 1000 10000 100000 1000000 personal injury.
Performance data published in this brochure has
Tightness Parameter,
Tightness Parameter, TpTp been developed from field testing, customer field
reports and/or in-house testing.
While the utmost care has been used in com-
* "Gb" and "a" measure tightness at initial seating, "Gs" indicates tightness under bolt load loss piling this brochure, we assume no responsibil-
ity for errors. Specifications subject to change
during operation—low values indicate best performance. "Tp" measures the gasket's ability to without notice. This edition cancels all previous
control leakage in a pressurized joint—the higher the Tp the tighter the joint. issues. Subject to change without notice.
Thicknesses Heat Exchanger
Core Compressed Configurations
Thickness Thickness*
Inches mm Inches mm
0.093 2.36 0.095 to 0.105 2.41 to 2.67
R C-A C-B D-A D-B E-A E-B E-C
0.125 3.18 0.128 to 0.138 3.25 to 3.51
0.187 4.75 0.190 to 0.200 4.83 to 5.08
0.250 6.35 0.253 to 0.263 6.43 to 6.68
0.375 9.53 0.378 to 0.388 9.60 to 9.86 E-D F-A F-B F-C G-A G-B G-C G-D
Ordering Information
When ordering, specify: I-H I-I I-J I-K J-A J-B J-C J-D
■ Style number
■ Material for metal core and sealing element
■ OD, ID, and thickness
J-E J-F J-G J-H K-A K-B K-C K-D
■ Configuration from chart, if applicable