Professional Documents
Culture Documents
This electronic thermostat circuit allows us to control a room temperature, turning on and off a
heating device.
In order to properly set the temperature level at which the relay is activated, the potentiometer should
be carefully adjusted. To adjust the electronic thermostat, the NTC thermistor is inserted into a glass
tube. The NTC thermistor ends must be welded to a pair of long wires.
Place the glass tube and a mercury thermometer in a container of water, which will be placed first in a
refrigerator, then at ambient temperature and finally on a gas burner or similar. The temperature of the
gas burner must not be high. (see the temperature limits of the mercury thermometer).
In each case, locate the point where the red LED lights, gently manipulating the potentiometer to the
maximum and marking on a screen (white card) behind the potentiometer, the temperatures readed on
the mercury thermometer.
The operation of the circuit is very simple and can be understood by analyzing the states of cut-off and
saturation of each transistor.
When the NTC thermistor resistance is very high (the ambient temperature level is low), the transistor
T1 goes into saturation, as long as the adjustment made to the potentiometer so permits. If transistor
T1 goes into saturation, transistors T2, T3 and T4 go into saturation too, activating the relay. This relay
has dual contact and each time it is activated, it makes two connections, one to turn on the LED and the
other to activate the heater.
The C1 capacitor is used to prevent sudden changes on the value of NTC thermistor and the C2
capacitor is used to avoid sudden changes on the voltage when the relay is disconnected, so the
transistor is not damage.