Professional Documents
Culture Documents
TO START
TO END
Step 1: Feed yarn into Step 2: Wrap yarn clockwise Step 3: Set yarn into holder
cylinder from the top. around each pin. guide.
Note: Hold the end of
the yarn with your fingers
as shown for the first few
rounds of knitting.
TO KNIT
Step 1: Turn disk clockwise Step 2: Place the knitting hook from top to bottom through Step 3: Lift knitting off the
so that the yarn from the loop (stitch) on pin. Twist knitting hook up and away from pins and pull yarn tail tight
holder guide is above the you, pulling the loop up and over the loose yarn to the to finish.
stitch on the pin. back of the pin.
Step 3: Turn the disk clockwise to the next pin and continue
knitting.
13438 ALONDRA BLVD. CERRITOS, CA 90703 TOLL-FREE: (800)233-1703 Fax: (562)282-0220 Website: www.clover-usa.com JULY 2008