Professional Documents
Culture Documents
01 Installation
Installing DiagBox 8.01
This procedure and the software provided are intended for personal, educational and experimental
use to install DiagBox 8.01 and related updates. I hold no responsibility for any illegal or improper
usage. Carry out this procedure at your own risk.
Links for all required software, updates and tools are in the attachments.
Done !,
Restart DiagBox 8.01 as Administrator to confirm all is well (don't be concerned about the reported
version and do not start Lexia or PP2000 yet). If you face an issue, run the activation tool again
and/or review "Versions" below.
If DiagBox runs fine, ensure you keep a backup copy of the file “C:\AWRoot\bin\fi\APPDIAG.SYS” in a
safe location.
Installing Updates
1- Download and install "DiagBox_updt_802.ISO" update.
2- Download and install subsequent v8.xx updates or Maitresox updates (from 7.66+).
Versions
The order of the version lines and which one is active in VERSION.INI is important for the correct
running of the system. DiagBox will display 08.01 if set as shown below. But Lexia will NOT work with
the line (version=08.xx) in "version.ini" (xx is the version number depending on which update is
applied).
[APPLICATION]
version=08.01
version=07.65
Notice
- DiagBox v7 and v8 install and run on all x86 (32bit) Windows including XP, Vista, 7, 8, 10 (TH1,
TH2, RS1 and RS2).
- Entering a System Serial for the Virtual Machine (as described above) resolves the "psaAagent.exe"
and the missing tabs issue on VirtualBox.
- If you get "Error 2" after restarting DiagBox, try commenting "version=8.xx" in "version.ini" before
restarting DiagBox again.
P.S. DiagBox has been running on Firmware v4.3.4 since v7.66/8.02 and Firmware v4.3.5 since
v8.45.
Enjoy; Simple.
I changed the attached file and added a tool that will report DiagBox 08.01.
If Lexia is started with "version=08.xx" active, APPDIAG.SYS will be corrupted and it will
need to be restored before DiagBox will work again. To have lexia working you need to
remove the line "version=08.xx" or insert a ";" (as shown below) BEFORE starting
LEXIA.
Setting "version.ini" to 07.xx will prompt DiagBox to report V 07.xx, but everything will
work..
[APPLICATION]
;version=08.01
version=07.65