Professional Documents
Culture Documents
a. only mass
b. both energy and mass
c. neither energy nor mass
3) Which of the following energy conversion devices convert heat into work?
a. Electrical generators
b. I.C engines
c. Condensers
d. All of the above
a. 1 and3
b. only1
c. only4
d. 2 and4
(a) spark
(b) injected fuel
(c) heat resulting from compressing air that is supplied for combustion
(d) ignition
(a) kcal
(b) kcal/kg
(c) kcal/m2
(d) kcal/n?
(e) all of the above.
10) Fuel oil consumption guarantees for I .C. engine are usually based on
11) In a typical medium speed 4-stroke cycle diesel engine the inlet valve
(a) opens at 20° before top dead center and closes at 35° after the bottom dead center
(b) opens at top dead center and closes at bottom dead center
(c) opens at 10° after top dead center and closes 20° before the bottom dead center
(d) may open or close anywhere
(e) remains open for 200°.
12) The maximum temperature in the I.C. engine cylinder is of the order of
(a) 500-1000°C
(b) 1000- 1500°C
(c) 1500-2000°C
(d) 2000-2500°C
(e) 2500-3000°C
17) The materials having same elastic properties in all directions are called
18) Tensile strength of a material is obtained by dividing the maximum load during the test by the
(a) area at the time of fracture
(b) original cross-sectional area
(c) average of (a) and(b)
(d) minimum area after fracture
(e) none of the above.
(a) toughness
(b) tensile strength
(c) capability of being cold worked
(d) hardness
(e) fatigue strength
20) Percentage reduction of area in performing tensile test on cast iron may be of the order of
(a)50%
(b)25%
(c) 0%
(d) 15%
(e) 60%.
WWW.ALLEXAMREVIEW.COM
WWW.ALLEXAMREVIEW.COM