Professional Documents
Culture Documents
ADS Installation Notes for Cree GaN HEMT Large Signal Models
This instruction sheet covers the installation in ADS for Cree’s CGH35015F, CGH35015P, CGH35030F,
CGH35030P and CGH35060F GaN HEMT models.
1. Remove “ADS_”.
2. **Important** Save the .zip file to disk.
3. Start up ADS and look for the drop-down menu in main window titled "DesignKit."
4. Choose the option "Install Design Kits." (Note: A window will pop up with Steps).
5. Use ADS step 2 "Define Design Kit" and browse to the kit file.
6. At the bottom of this ADS window you can select user level, project level, etc.
Then click OK.
Note: This will install the kit.
7. Open a design window and select model from the palette.
Note: Here you can pick and place the models.
8. The Gate voltage is -3.0 < Vg < -1.5, with pinch off ~2.9 Volts. Vd is valid
from ~28V to ~48V
In the event that additional support is required, please contact Ryan Baker at ryan_baker@cree.com
Note: If the .zip file installs successfully, but does not appear in the palette, there is an alternate path to the models.
Insert > Component > Component Library > Encoded Library
CREE CONFIDENTIAL
www.cree.com/wireless