You are on page 1of 25

University of Nebraska - Lincoln

DigitalCommons@University of Nebraska - Lincoln

U.S. Department of Agriculture: Agricultural


Publications from USDA-ARS / UNL Faculty Research Service, Lincoln, Nebraska

1983

PHYSIOLOGY OF MALE REPRODUCTION


R. P. Amann
Colorado State University - Fort Collins

B. D. Schanbacher
USDA-ARS

Follow this and additional works at: https://digitalcommons.unl.edu/usdaarsfacpub

Part of the Agricultural Science Commons

Amann, R. P. and Schanbacher, B. D., "PHYSIOLOGY OF MALE REPRODUCTION" (1983). Publications from
USDA-ARS / UNL Faculty. 765.
https://digitalcommons.unl.edu/usdaarsfacpub/765

This Article is brought to you for free and open access by the U.S. Department of Agriculture: Agricultural Research
Service, Lincoln, Nebraska at DigitalCommons@University of Nebraska - Lincoln. It has been accepted for inclusion in
Publications from USDA-ARS / UNL Faculty by an authorized administrator of DigitalCommons@University of
Nebraska - Lincoln.
PHYSIOLOGY OF MALE REPRODUCTION

R. P. Amann I and B. D. Schanbacher 2

Colorado State University, Fort Collins 80523


and
U.S. Department of Agriculture, Clay Center, NE 68933

Summary ram and stallion. This would allow producers


The major advances over the past 25 yr to make more efficient use of genetically
in male reproductive physiology of cattle, superior sires.
sheep, swine and horses are reviewed. Those Artificial insemination of beef cattle and
findings which have allowed efficient culling sheep is likely to increase, but not to the
of subfertile males and exploitation of the extent achieved for dairy cattle or swine.
reproductive capacity of genetically superior Most sheep and beef cattle probably will con-
sires are emphasized. tinue to be bred by natural mating under
Hormones secreted by the male gonad conditions which maximize the utilization
early in gestation induce regression of poten- of forage but which make difficult, or preclude,
tially female structures and development of application of high technology management
the male reproductive tract. Compartmentaliza- practices. Sires used for natural mating routinely
tion of the testis and formation of the blood- will undergo a breeding soundness examination.
testis barrier during prepubertal development By the year 2,000, spermatozoal motility,
permit the steroidogenic and gametogenic velocity and concentration probably will be
activities of the adult testes to proceed nor- measured by dipping a fiber optic probe into
mally. The role of the central nervous system, a semen sample. However, visual examination
hypothalamus and anterior pituitary in regula- of semen quality still will require a phase con-
tion of the endocrine and exocrine functions trast microscope. Insemination of frozen semen
of the testes are discussed in view of the physio- enriched in sperm bearing either the X- or
logical constraints and reproductive require- the Y-chromosome, with at least 80% off-
ments of the domestic male. The relationships spring of the desired sex, is likely within
among testes size, the efficiency of spermato- the next 20 yr. Application of sexed semen
genesis and daily spermatozoal production are in commercial dairy herds will be common,
discussed. Ignorance about epididymal function but its impact on other species of livestock
and the physiology of spermatozoal maturation may be marginal.
are mentioned. Successful techniques have been An expanded array of options for manage-
developed and applied to the extension and ment of sires will be available to the livestock
preservation of genetically superior bovine producer in the next decade. The greatest
sperm, but similar success and exploitation impact of those technologies will be on dairy
has not been achieved in other species. A cattle and swine. Future sires may be conceived
better understanding of the biochemical and as a result of planned matings accomplished by
biophysical differences among sperm from artificial insemination followed by sexing and
domesticated animals should enable develop- splitting of embryos, transfer of desirable
ment of procedures for successful extension embryos to appropriate recipients, and possible
and cryopreservation of sperm from the boar, manipulation of reproductive development
before or after birth. A better understanding
of factors controlling sexual behavior should
enhance the usefulness of sires used for natural
matings or in artificial insemination centers.
t Animal Reproduction Laboratory, Colorado State
Univ. Manipulation of the seasonal pattern in sperm
2Roman L. Hruska U.S. Meat Anita. Res~ Center, production of rams and stallions also will be
ARS, USDA. commonplace.
380
JOURNAL OF ANIMAL SCIENCE, Vol. 57, Suppl. 2, 1983

This article is a U.S. government work, and is not subject to copyright in the United States.
MALE REPRODUCTION 381

(Key Words: Bulls, Rams, Boars, Stallions, puberty and body growth of future sires
Male Reproduction, Sperm Production, Semen may be possible.
Preservation, Male Fertility.) In this review, advances in our under-
standing of differentiation of the male re-
productive system, the testis and sperma-
Introduction togenesis, neuroendocrine control of male
The past 3 5 to 40 yr have seen remarkable reproduction, epididymal function, repro-
advances in our understanding of male re- ductive capacity of the male, spermatozoa
productive physiology. These advances have and techniques for extension and preserva-
led to techniques for exploitation of the tion of semen will be considered. Physiological
reproductive capacity of bulls with semen concepts have been illustrated using bulls
from individual superior sires being used to and rams because a more complete picture
inseminate up to 100,000 dairy cows annually. is available for these species, but comparisons
Such exploitation of genetically superior with boars and stallions are made when possi-
sires is a direct result of our increased under- ble. Lack of space has necessitated the citation
standing of testicular physiology and sexual of many review articles rather than the primary
behavior; improved procedures for extension, references for all topics considered. We apolo-
processing and cryopreservation of semen; gize to individuals who may feel slighted.
the design of efficient packaging and storage We conclude with our speculations concerning
containers; improved methods for evaluating advances within the next decade or two.
spermatozoal quality; and establishment of
the minimum number of motile spermatozoa Differentiation and Development of the
Mammalian Testis
required for maintenance of an adequate
conception rate. The greatest impact of this The indifferent gonad in the developing
knowledge has been through artificial insemina- fetus arises from a thickening of the coelomic
tion of dairy cattle. The same procedures epithelium on the medioventral aspect of
are used for preservation of semen from beef the mesonephros. These thickenings, known
bulls. However, our understanding of the as the genital ridges, are invaded by primordial
physiology of beef bulls lags behind that germ cells which migrate from the mesenchyme
for Holstein bulls and the commercial appli- (Gier and Marion, 1970). The chronology
cation of artificial insemination to beef cattle of development of the indifferent gonad
is limited by factors not related to male re- is asymetric in that a male gonad develops
productive physiology. With horses, sheep days before the earliest changes in a female
and swine, artificial insemination of fresh gonad (Jost et al., 1973). In normal males,
semen is practical, but with frozen semen expression of a gene on the Y-chromosome
the conception rates and numbers of off- organizes the indifferent embryonic gonad
spring born are less than those obtained with to produce a male gonad from structures
fresh semen or natural service. that otherwise would form an ovary at a
Improved understanding of the neuro- later time. Thus, expression of male genetic
endocrine control of male reproductive func- sex is essential for testicular formation.
tion, sexual behavior, and approaches for The early initiation of testicular function
evaluation of semen have led to widespread is essential for development of the male repro-
adoption of the breeding soundness evaluation ductive tract. The male embryo contains
for beef bulls used for natural mating and, anlage of both the male and female excurrent
to a lesser extent, evaluation of rams, boars ducts - the mesonephric tubules and duct
and stallions for potential fertility. This appli- and the MiiUerian duct. The male genome
cation of basic research has increased pregnancy contains a program for inhibition of female
rates in herds and flocks through early culling duct development. This sequence is activated
of sterile or potentially subfertile males and by hormones secreted by the male gonad
males with a low reproductive capacity. It (Jost, 1970; Jost et al., 1972; Ford, 1982).
now is possible to shift the seasonal cycle The Leydig cells of the fetal male gonad pro-
of sperm production and fertility of rams. duce testosterone (near day 35 in pigs or day
Manipulation of the seasonal cycle of stallions 42 in cattle) which stimulates development of
should be common within the next decade the mesonephric tubules and duct into the
and manipulation of testicular development, efferent ducts, ductus epididymidis, ductus
382 AMANN AND SCHANBACHER

deferens and vesicular glands. The indifferent seminiferous tubules (figure 1). Steroid secre-
supporting cells (fetal Sertoli cells) produce tion and spermatozoal production each are
a Miillerian duct inhibiting hormone which dependent on the separate actions of the two
causes degeneration of potentially female gonadotropins, luteinizing hormone (LH) and
structures (Josso et aI., 1977, 1979). As dif- follicle stimulating hormone (FSH). Never-
ferentiation of the mesonephric duct proceeds, theless, both processes are intimately coupled
induction of the enzyme 5~-reductase allows in that adequate levels of testosterone are
metabolism of testosterone to dihydrotestos- essential for the normal production and
terone which induces differentiation of the maturation of spermatozoa.
urogenital sinus into the prostate and bulboure- The testis can be considered to have three
thral glands and male type urethra and phallus functional compartments. The interstitial tissue
(Wilson and Siiteri, 1973). The urogenital compartment, which includes the Leydig cells,
folds develop into a scrotum. Castration of surrounds the seminiferous tubules and bathes
a male bovine fetus on day 40 removes these the seminiferous tubules with a fluid rich in
influences of the testis and the animal de- testosterone. The other two compartments
velops as a phenotypic female (Jost et aI., are within the seminiferous tubules which
1973). Final development of the mammalian are divided functionally into a basal and an
testis involves testicular descent (Gier and adluminal compartment (figure 1). The former
Marion, 1970) which occurs long before birth contains spermatogonia which divide by mitosis
in cattle, sheep and swine but within 2 wk whereas the latter contains a special isolated
before or after birth in horses. environment in which spermatocytes undergo
meiosis and spermatids differentiate into
The Adult Testis spermatozoa. Although Sertoli cells extend
Much of the early understanding of testicu- from the basal compartment into the adluminal
lar function has resulted from the practice compartment, the two tubular compartments
of castration. The exposed position of the are separated by junctional complexes that
testes and the observation that removal of function as the major component of the blood-
the testes is not life-threatening provided testis barrier (Dym and Fawcett, 1971 ; Fawcett
the incentive for intentional orchidectomy et al., 1970). The blood-testis barrier excludes,
by early civilizations. Hormonal contribu- totally or partially, from the adluminal com-
tions of the testes may have been deduced partment many compounds found in blood
by ancient man, since castration was used or intersitital tissue fluid (Neaves, 1977;
before 7000 B.C. to produce tender meat SetchelI, 1980; Waites and Gladwell, 1982).
for human consumption and Aristotle recog- Several substances believed to play key roles
nized the different consequences of prepubertal in the development and maintenance of testicu-
and postpubertal castration (Bremner, 1981). lar function are secreted by Sertoli cells and
However, the contribution of the testes to concentrated in the isolated adluminal com-
fertility was not acknowledged until Leeuwen- partment of the testis. Distention of semi-
hoek observed spermatozoa in 1667 A.D. niferous tubules and accumulation of fluid
(Meyer, 1938) and de Graft (1668) described after ligation of the efferent ducts (Setchell,
the seminiferous tubules. While the endocrine 1980) and the inability of large molecules
and exocrine functions of the testes long such as lanthanum to penetrate the distended
have been recognized, only in the past three testis (Neaves, 1973), bear proof to the im-
decades has a fuller appreciation of the spe- permeable barrier which resides in the semi-
cialized functions of the testes been realized. niferous tubules.

Compartmentalization and the Blood-Testis The Leydig Cell


Barrier Leydig cells are large, polyhedral cells
The two basic functions of the testes are occurring in clusters and are found in associ-
a) secretion of testosterone and other hormones ation with the lymphatics and blood capillaries
through the process of steroidogenesis and b) in the interstitial compartment of the testis
production of spermatozoa through the process (Setchell, 1978). The cytoplasm of Leydig
of spermatogenesis. These two functions cells contains numerous lipid-filled vacuoles
occur, respectively, in the Leydig cells and and an extensive smooth endoplasmic reticulum
MALE REPRODUCTION 383

Figure 1. Drawing of part of a seminiferous tubule showing the relationship of the germ cells to the ad-
jacent Sertoli cells. Formation of spermatozoa starts near the basement membrane when a spermatogonium
divides to form other spermatogonia and ultimately primary spermatocytes. The primary spermatocytes are
moved from the basal compartment, through the junctional complexes between adjacent Sertoli cells, into the
adluminal compartment, where they eventually divide to form secondary spermatocytes (not shown) and spher-
ical spermatids. The spermatogonia, primary spermatocytes, secondary spermatocytes, and spherical spermatids
all develop in the space between two or more Sertoli cells and are in contact with them. During elongation
of the spermatid nucleus, the spermatids are repositioned by the Sertoli cells to become embedded within
long pockets in the cytoplasm of an individual Sertoli cell. When released as a spermatozoon, a major portion
of the cytoplasm of each spermatid remains as a residual body within a pocket of the Sertoli cell cytoplasm.
Note the intercellular bridges between adjacent germ cells in the same cohort or generation.
384 AMANNAND SCHANBACHER

(Hooker, 1944, 1970; Zirkin et al., 1980). within the Sertoli cells. Organelles within the
Leydig cells bind HCG (Schanbacher, 1979a) Sertoli cells, including the endoplasmic re-
and in vitro the cells respond to LH by pro- ticulum, have an active role in modifying
ducing testosterone. Leydig cells are active the spermatid during nuclear elongation and
in the early embryo, regress during later de- acrosome formation.
velopment, and reactivate during the onset The Sertoli cells have a pivotal role in the
of puberty (Hooker, 1970). In the boar there hormonal control of spermatogenesis. Bio-
also is a neonatal period of Leydig cell dif- chemical and morphological changes in Sertoli
ferentiation (van Straaten and Wensing, 1978). cells are induced by FSH and Sertoli cells
Leydig cells are the primary source of are the only testicular cell with specific binding
testicular steroids, including testosterone, pro- sites for radiolabeled FSH (Schanbacher,
gesterone and probably estrogen (Ewing and 1979a). Thus, the action of FSH on sperma-
Brown, 1977; Zirkin et al., 1980). However, togenesis is indirect, via the Sertoli cells,
Sertoli cells also are a source of estradiol rather than directly on the germ cells. Because
(Huggins and Moulder, 1945; Ritz6n et al., of the blood-testis barrier, FSH must enter
1981). Steroid production by a testis is corre- through the basal aspect of the Sertoli ceil.
lated with the amount of smooth endoplasmic In response to FSH stimulation, and with
reticulum in the Leydig cells (Zirkin et al., the availability of testosterone, Sertoli cells
1980). Cholesterol is produced from acetate secrete fluid and specific products like andro-
within the smooth endoplasmic reticulum gen binding protein (ABP) and inhibin (Stein-
of the Leydig cells and stored as the free berger, 1981a,b). The functional role of ABP
or esterified compound. Formation of preg- is believed to reside within the seminiferous
nenolone involves enzymatic cleavage of the tubules or epididymis where ABP presumably
side chain from cholesterol and occurs in serves to attenuate changes in testosterone
the mitochondria. This step is rate limiting concentration or to aid in testosterone trans-
in the production of testosterone and for- port. Inhibin is thought to act on the anterior
mation of pregnenolone is stimulated by pituitary gland to suppress FSH secretion
LH. Pregnenolone is rapidly metabolized to (Blanc et al., 1981; Ritzen et al., 1981). Both
testosterone, via a number of A4- and A s_ secretory proteins have been detected in
intermediates, in the smooth endoplasmic peripheral plasma. It seems likely that ABP,
reticulum (Ewing and Brown, 1977; van der inhibin and other secretory products of Sertoli
Molen and Rommerts, 1981). Although the cells enter the systemic circulation via two
testes of all species secrete a variety of steroids routes: a) the basal aspect of the Sertoli cells
in addition to testosterone, the testes of boars and b) absorption from the luminal fluid
and stallions produce relatively large quantities in the proximal epididymis (Setchell, 1978).
of estrogens (Bedrak and Samuels, 1969; Oh Regardless of routes and mechanisms, con-
and Tamaoki, 1970). The boar also secretes tinuous communication exists between
a C16-unsaturated steroid (Booth, 1982) the anterior pituitary, Sertoli cells and germ
that serves as a pheromone (Signoret, 1970). cells.
It currently is accepted that the number
of Sertoli cells in the testis is established
The Sertoli Cell during puberty and that Sertoli cell number
Sertoli cells, which rest upon the lamina is constant in an adult male (Lino, 1971;
propria of the seminiferous tubule (figure 1), Hochereau-de Reviers and Courot, 1978).
are the only somatic cells within the semi- However, the validity of this assumption
niferous tubules. Their cytoplasmic processes has been challenged by Johnson and Thompson
extend to the lumen of the seminiferous tubule (1983) who found that the number of Sertoli
and envelope the developing germ cells. Sertoli cells within the stallion testis was 26% lower
cells provide the only communication link during the winter than in the summer. If
across the blood-testis barrier. The precise this report is confirmed, consideration should
function of Sertoli cells in spermatogenesis be given to the possibility that slow replace-
is not fully understood, but they provide ment of Sertoli cells or seasonal changes in
the microenvironment required for germ Sertoli cell number occur in other domesticated
cell development. The germ cells are anchored males. Additional studies of factors controlling
by desmosome-like, ectoplasmic specializations the number of Sertoli cells at different times
MALE REPRODUCTION 385

of year or the number formed during the pre- tremely resistant to radiation or toxic agents.
pubertal period are needed. In domesticated species, a number of stem A1 -
spermatogonia in one area of a seminiferous
tubule synchronously become committed to
Spermatogenesis produce differentiated A2-spermatogonia and
Spermatogenesis is the sum of the trans- the cohorts of germ cells resulting from these
formations that result in formation of sperma- A2 -spermatogonia differentiate in unison.
tozoa from spermatogonia while maintaining The progeny of a stem Al-spermatogonium
spermatogonial numbers (Courot et al., 1970; remain joined by intercellular bridges (Dym
Ortavant et al., 1977). This process involves and Fawcett, 1971), except where cell death
mitotic division of A1 -spermatogonia to breaks the "chain" of interconnected cells.
form more differentiated ceils termed A2-, Because a synchronous population of de-
A3-, in-, Bl- and B2-spermatogonia. The veloping germ cells occupies a considerable
latter divide to form two primary spermato- area of the basement membrane of a semi-
cytes that enter meiosis, form secondary niferous tubule, the major part of most cross
spermatocytes, and finally spermatids. sections through a seminiferous tubule has
Sperrnatids undergo differentiation into the same appearance. However, adjacent
spermatozoa. Early workers (yon Ebner, cross sections frequently have a different
1888; Regaud, 1901; Schoenfeld, 1901) out- appearance.
lined spermatogenesis in domesticated animals Eight to 12 different cellular associations
from a morphological point of view. They have been discerned for the bull, boar, ram
observed that spermatogenesis could be classi- and stallion (Setchell, 1978). Each cellular
fied into a series of cellular associations based association contains four or five types of
on the general appearance of seminiferous germ cells organized in a specific, layered
tubule cross sections. Further advancement arrangement (figure 2). Each layer represents
of knowledge concerning spermatogenesis was one cell generation with the most differentiated
minimal until the 1950's. nearest the tubule lumen. The eight stage
In the mid-1950's, two techniques were classification scheme (figure 2) is based on
developed which revolutionized the study morphology of the spermatids and the re-
of spermatogenesis. Clermont and Leblond lationships among all germ cell types. The
(1955) noted that use of the periodic acid- cells that should be present in a given tubule
Schiff stain allowed them to describe the cross section are listed in the eight columns.
morphologic changes of the acrosome in Modifications of this classification approach
developing spermatids. By this approach, are useful with prepubertal animals (Courot,
they were able to define a number of steps 1971; Curtis and Amann, 1981) or if the
during spermiogenesis which later served development of spermatids is impeded. An
as the basis for definition of 12 cellular as- alternative approach for defining cellular
sociations within the bovine germinal epi- associations is based on morphology of the
thelium (Berndtson and Desjardins, 1974). acrosome in the developing spermatid - 12
The second technique involved radiolabeling cellular associations have been described
of DNA during synthesis by young primary for the boar, bull and ram (Setchell, 1978).
sperrnatocytes. This enabled the time course With either approach, the complete series
of spermatogenesis and the pattern of sperma- of cellular associations is termed the cycle
togonial divisions to be ascertained. Classic of the seminiferous epithelium.
studies with rams (Ortavant, 1958) and bulls Collectively, the germ cells at a point within
(Koefoed-Johnsen, 1958) utilized 32p, but a seminiferous tubule sequentially acquire
in subsequent studies (Hochereau et al., 1964; the appearance of each of the 8 to 12 cellular
Swierstra, 1968a; Swierstra et al., 1974) 3H- associations characteristic of that species.
thymidine has been used because of increased The interval required for one complete series
specificity and resolution during radioautog- of cellular associations to appear at a point
raphy. within a tubule is termed the duration of
A seminiferous tubule contains a number the cycle of the seminiferous epithelium.
of reserve Ao-spermatogonia which are not This duration is uniform for a species (table 1)
part of the proliferating pool of germ ceils and is not influenced by any known factor.
(Hocbereau-de Reviers, 1981) and are ex- Critical studies of the pattern of spermato-
386 AMANN AND SCHANBACHER

goniaI renewal have been published for the 61 d (table i ) .


bull ( H o c h e r e a u - d e Reviers, 1981), boar A n y realistic appraisal o f testicular f u n c t i o n
(Frankenhuis et al., 1980) and ram (Ortavant, m u s t include a quantitative analysis o f testicu-
1958), but alternative interpretations of certain far histology, because subtle and even substan-
aspects of spermatogonial d e v e l o p m e n t are tial changes in germ celt p r o d u c t i o n m a y
possible. Even allowing for this uncer- n o t be d e t e c t e d by subjective evaluations
rainty, the duration o f spermatogenesis (Berndtson, 1977; Amann, 1982). E x c e l l e n t
probably is b e t w e e n 4,3 and 4.7 cycles o f reviews o f approaches to m o r p h o m e t r i c analy-
the seminiferous epithelium or 3.9 and ses (Berndtson, 1977; Bolender, 1982) should

-61 DAYS 4

I it ill tv vvt vIivJ11


3.9 me 12.4 115 .9 i11 115
ONE C Y C L E = 1:3.6 D A Y S
Figure 2. The cycle of the seminiferous epithelium in the bull. In this chart, the basement membrane is
at the bottom and the lumen of the seminiferous tubule at the top. Each of the five upper rows represents
one generation of germ cells that are increasingly (from bottom to top) more mature. The columns represent
the eight cellular associations of the morphological classification scheme. The germ cells present in each cellular
association can be discerned by reading up in each column. Germ ceil types are A t -, A 2 -, A 3-, ln~, B~ - and B~ -
spermatogonia, preleptotene (PI), leptotene (L), zygotene (Z), pachytene (P), diplotene (D) and secondary
(2) spermatocytes and spermatids with a spherical (St), elongating ~Se), condensing (Sc) or definitive (Sin) nu-
clear shape. The complete series of celluJar associations is termed the cycle of the seminiferous epithelium. In the
bull, the duration of one cycle of the seminiferous epithelium is 13.5 d. The duration of each cellular association
also is shown. Since approximately 4.5 cycles of the semlniferous epithelium pass between commitment of
an A-spermatogonium to differentiate and produce more advanced types ~f spermatogonla and release of
the resulting spermatozoa from the germinal epithelium, the duration of spermatogenesls is 61 d in the bull.
MALE REPRODUCTION 387

TABLE 1. SPERMATOGENESIS IN ADULT DOMESTIC ANIMALSa


Daily sperm production
Per gram
Paired testes Duration of cycle Duration spermatogenesis parenehyma Per male
wt (g) (days) b (days) c (106/g) (109 )
Bull
Hereford 650 13.5 61 10 5.9
Charolais 775 13.5 61 13 8.9
Holstein 725 13.5 61 12 7.5
Stallion 340 12.2 55 16 5.3
Ram
lie de France 500 10.4 47 21 9.5
Suffolk 475 10.4 47 25 12.5
Boar
Yorkshire 939 8.6 39 20 16.8

acompiled from the literature.


bDuration of one cycle of the seminiferous epithelium.
CDuration of spermatogenesis assuming it requires 4.5 cycles of the seminiferous epithelium.

be consulted before quantitatively evaluating duction at a given time of year (Swierstra,


testicular function. The method of tissue 1968b; Amann, 1981). Thus, daily sperm
fixation is critical and use of buffered form- production is highly correlated with testicular
aldehyde is unsatisfactory (Amann, 1982). weight. Sperm production of living animals
Morphometric data should be used to cal- can be estimated with an orchidometer
culate the total number of germ cells of each (caliper) by measuring the length, breadth
type within the testis. By this approach changes and width of each testis (Foote, 1969). For
have been detected in the number of Sertoli bulls and rams, the circumference of the
cells and different classes of germ cells during scrotum around the widest point is highly
puberty (Attal and Courot, 1963; Courot, correlated with testicular weight and sperm
1971; Curtis and Amann, 1981), during dif- production (Willett and Ohms, 1957; Foote,
ferent seasons of the year (Ortavant, 1958; 1978; Coulter, 1980). Measurements of testicu-
Johnson and Thompson, 1983), or as a conse- lar size should be an integral part of any andro-
quence of drug or hormone therapy (Berndt- logic examination or experiment on male
son et al., 1979). reproductive function so that normalcy of
testes size or experimentally induced changes
Daily Sperm Production in testicular size, and potential spermatozoal
When evaluating spermatogenesis, the ulti- production, can be established.
mate end point is the number of potentially The testes of rams (Ortav~nt, 1958, 1977;
fertile sperm produced (table 1). Daily sperm Lincoln and Short, 1980; Ravault et al., 1980;
production is the number of sperm produced Lincoln, 1981) and stallions (Pickett et al.,
per day by the testes (Amann, 1970, 1981). 1981; Johnson and Thompson, 1983)undergo
The efficiency of sperm production is the a seasonal regression in function, but complete
number of sperm produced per day per gram cessation of spermatogenesis does not occur.
of testicular parenchyma. The efficiency Similar but more subtle effects may exist
of sperm production can be determined by in cattle (Amann, 1970) and high ambient
three methods (Amann, 1970; Berndtson, temperature decreases sperm production by
1977; Johnson et al., 1981a). In all species boars (Wettemann et al., 1978). An increased
(table 1), the efficiency of sperm production understanding of the mechanisms underlying
is influenced by age, environmental factors, the seasonal constraints to efficient lamb
hormonal status and drugs. Normal, adult production has enabled animal scientists
individuals of a given breed or species have to overcome seasonal infertility in rams by
a fairly uniform efficiency of sperm pro- use of modified light regimens or hormone
388 AMANN AND SCHANBACHER

injections (Ortavant, 1977; Schanbacher, blood concentration of FSH. Evidence for


1979c; Haynes and Schanbacher, 1983). hypothalamic control of the anterior pituitary
has come primarily from studies employing
Endocrine Regulation of Testicular Function hypothalamic lesions (Clegg et al., 1958)
The isolation and purification of testos- or immunoneutralization of GnRH activity
terone from testicular tissue (David et al., (Schanbacher, 1982a). In both cases, hypo-
1935) and its subsequent assay (Lindner, gonadotropism and gonadal atrophy result.
1959, 1961) were milestones in reproduc- While these perturbations have severe conse-
tive endocrinology. However, the develop- quences on gonadal function, less dramatic
ment of sensitive radioimmunoassays for inputs from both external (e.g., photoperiod
the rapid quantitation of protein (Yallow and physical stress) and internal (e.g., testicular
and Berson, 1960) and steroid (Midgley et al., steroid feedback) environments continually
1969) hormones in blood and tissue revolu- impinge on the hypothalamus (Schanbacher
tionized the field of endocrinology. For and Ford, 1979; Schanbacher, 1982b).
andrologists, the assays for LH (Niswender
et al., 1969), FSH (McNeilly et al., 1976), The Anterior Pituitary Gland
testosterone (Flavo and Nalbandov, 1974; Regression of the rat testes following hypo-
Schanbacher and D'Occhio, 1982), and GnRH physectomy provided evidence that the testes
(Nett and Adams, 1977) are especially im- are controlled by the pituitary gland (Smith,
portant. 1927). This observation has been confirmed
repeatedly in several species including sheep
The Hypotbalamus (Courot, 1967). It now is known that LH
The hypothalamus integrates inputs from and FSH from the anterior pituitary are essen-
the central nervous system and generally tial for normal function of Leydig cells and
is considered to be the orchestrator of testicu- Sertoli cells, respectively. Injection of pituitary
lar activity (Schanbacher, 1982b). A massive extracts containing LH and FSH prevent the
9 and highly competitive research effort estab- testicular regression that follows hypophy-
lished how these signals are transmitted by sectomy (Greep et al., 1936; Courot, 1967).
the hypothalamus. Research teams headed
by Guillemin and Schally extracted gonado- The Hypotbalarnic-Pituitary -Gonadal Axis
tropin releasing factors from millions of sheep The hypothalamic-pituitary-gonadal axis
and pig hypothalami, respectively. Almost (figure 3) is a self-regulating system. LH
simultaneously, the two groups established secretion is controlled by a complex interac-
the correct sequence for the decapeptide tion of the sex steroids and GnRH. In the
(Burgus et al., 1971; Matsuo et al., 1971) mature male, a release of LH usually is fol-
and showed that synthetic material caused lowed by a rise in serum testosterone. Based
the release of LH and FSH from the pituitary on the castrate animal model, it appears that
(Monahan et al., 1971). For both species the peripheral concentration of testosterone
the structure of gonadotropin releasing hor- largely dictates the pattern of LH secretion
mone (GnRH) is pyroGlu-His-Trp-Ser-Tyr- (Ford and Schanbacher, 1977; D'Occhio
Gly-Leu-Arg-Pro-Gly-NH2). Many synthetic et al., 1982b). Regulation of LH secretion
analogs now are available and certain of these by feedback inhibition also can be induced
have proven useful as profertility or anti- by other androgens and estrogens (Parrott
fertility agents. and Davies, 1979; D'Occhio et al., 1982a,
GnRH is released from the hypothalamus 1983; Schanbacher et al., 1983).
into the portal system in discrete pulses (Levine The observations that both LH and FSH
et al., 1982) whereby it reaches the gonado- secretion increase following castration (Schan-
trophs of the anterior pituitary and causes bacher and Ford, 1977; Amann and Walker,
the pulsatile discharge of LH and the discharge 1983) and cryptorchidism (Schanbacher,
of FSH. Whereas LH secretion is immediate 1979b) are evidence that a hormonal factor(s)
after GnRH stimulation, the discharge of FSH from the testes controls the secretion of both
is slow and gradual (Lincoln, 1979). This fact, gonadotropins. Although testicular steroids
together with a slower clearance of FSH from inhibit FSH secretion in the castrate ram
blood, results in attenuation of changes in (D'Occhio et al., 1982c), a nonsteroidal factor,
MALE REPRODUCTION 389

Hy00th.,amusr

I
I
Antitur'trr ~
I
PRL
LH @
I
I
I
I
I
"Sertoli cell in
O"~i Accessory seminiferous
sex glands tubule

I... m =--~_

eydig cells in
interstitial tissue

Epididymis vessel

Figure 3. Diagram showing inter-relationships among hormone production in the Leydig cells and semi-
niferous tubules and the feedback control of gonadal hormones on the hypothalamus and anterior lobe of the
pituitary gland. An increased level of testosterone (T) in peripheral blood, either as a result of increased pro-
duction by the testes or following injection of exogenous hormone, provides negative feedback on the hypo-
thalamus to suppress pulsatile discharge of GnRH and thus suppress discharge of luteinizing hormone (LH)
from the anterior pituitary. Consequently, the Leydig cells receive less LH stimulation which results in less
T being produced. Estrogens (E) are produced by the Leydig cells and to some extent by the Sertoli cells.
The ratio of T to E reaching the anterior pituitary may affect the relative amounts of LH and FSH secreted
by the gonadotrophs. Based on studies with rams, inhibin (I) suppresses discharge of FSH from the anterior
pituitary gland. The physiological roles of E and prolactin (PRL) in adult domestic males remain conjuctural.
Sertoli cells produce an androgen-binding protein (ABP) which serves as a carrier for testosterone and may
aid in maintaining a high androgen concentration within the seminiferous tubules or in providing testosterone to
the epithelium lining the proximal portion of the epididymis.
390 AMANNAND SCHANBACHER

termed inhibin, originating from the semi- spicious early change is an increase in the
niferous tubule may be the major regulator frequency of pulsatile discharge of LH. This
of FSH secretion (McCullagh, 1932). Hemi- is followed by altered testicular steroido-
castration results in increased secretion of genesis, increased circulating levels of testos-
FSH and with prepubertal lambs is followed terone, differentiation of Sertoli cells and
by compensatory growth of the remaining the onset of spermatogenesis (figure 4).
testis (Land and Carr, 1975; Walton et al., Ramirez and McCann (1963) proposed that
1978, 1980). The feedback regulator of FSH puberty occurs when an animal becomes
secretion may be inhibin (Keogh et al., 1976; desensitized to the feedback inhibition im-
Blanc et al., 1981) and probably originates posed on the hypothalamic-pituitary complex
from the Sertoli cells. Although the physiologi- by gonadal steroids. Presumably, this allows
cal role of inhibin has been studied, isolation an increase in GnRH discharge and a greater
and characterization of inhibin has not been response by the pituitary gland to GnRH.
accomplished (Setchell et al., 1977; Franchi- The repeatedly observed increased frequency
mont et al., 1981). and amplitude of LH discharges could reflect
Secretion of testosterone by the Leydig such a shift. This hypothesis also is supported
cells provides a high concentration of testos- by the observation that testicular growth,
terone around the seminiferous tubules which testosterone secretion and spermatogenesis
is essential for spermatogenesis (Albert, 1961). were delayed in pubertal-age bull calves ad-
The tissue concentration of testosterone ministered low doses of estradiol (Schan-
probably approaches that in testicular vein bacher, 1982b). Numerous environmental
blood which is 20 to 100 times higher than factors (both internal and external) influence
in peripheral blood (Lindner, 1959, 1961; the central nervous system to modulate the
Amann and Ganjam, 1976, 1981). endocrine system and, thereby, alter the
chronological age at which a given animal
Regulation of Puberty reaches puberty. Energy intake, breed and
Puberty is when a male first produces season of birth are major factors affecting
sufficient sperm to impregnate a female. age at puberty.
For practical reasons, puberty in bulls has
been defined as the age when an ejaculum Old Age
is obtained containing 50 x 106 sperm of With few exceptions, the testes of a mature
which I>10% are motile (Wolf et al., 1965). male continue to secrete testosterone and
This definition also is suitable for boars, rams produce spermatozoa at a rate adequate to
and stallions. For boars, bulls and rams, the meet the breeding requirements of the species.
pubertal period is associated with rapid testicu- Old age impinges on reproductive performance
lar growth, changes in LH secretory pattern, in man and certain laboratory species, but
a gradual increase in blood testosterone, and detailed longitudinal studies of changes in
the initiation of spermatogenesis. Puberty the pituitary-gonadal axis or of spermato-
is not synonymous with sexual maturity genesis with advancing age have not been
or adult status which occurs months or years made for domestic animals. Certain disorders
later (Amann, 1970, 1981). (e.g., genetic diseases, autoimmune disease,
The hypothalamus is believed to play a orchitis and tumors) can contribute to testicu-
key role in initiating puberty because the lar failure. The best data are for Holstein bulls
pituitary gland, gonads and steroid-dependent in artificial insemination organizations (Kratz
target tissues each are competent and ready et al., 1983). About 46% of the genetically
to respond to their respective tropic hormones desirable bulls eventually are removed for
prior to puberty (Davidson, 1974). In the boar, reproductive reasons although many are re-
bull and ram, puberty appears to be the moved for muscular-skeletal problems.
culmination of a continuous and lengthy
process of endocrine changes which begin
Epididymal Function
shortly after birth (Levasseur, 1977; FlorCruz
and Lapwood, 1978; Foster et al., 1978; In the mid-1950's, virtually nothing was
Hafs and McCarthy, 1979; Lacroix and Pel- known about the function of the epididymis.
letier, 1979; Amann, 1983). The most con- Early morphologists (Benoit, 1926) described
MALE REPRODUCTION 391

~SUPRESSIONI I~@FEEOBACKI
I • • G n
~) FSH:i:~:i:i:i:;:;.".;;:i:!:i:i:i:i:i:!:i:i:i:i:i:i;i;i:i:i:i:::::i:i:i:i:i:ii:ii?!iii:i!:i:i:i:i:i:i:i:ii:iii::i:i:i:i:i:i:i:i:i:i:iii:;:;:i:i:i:i:i:i:i:i
:i:;:i:i:i:i:i:?:;:i:i::::::::::::::::::::::::::::::::::::::::::
!:::!i!i:i::!ii::;:i:
:i:K:i;!:i:i:i:i:!:!:i:i:;:i:~

A
NDROGEN Lw4t tttt A4 T I_~

[l-SERTO~LCIINDIFFERENT
dE P T O R SSUPPORTING C. 3~ ,~'~ ~ . ~ : : ~ R T ~ L I
" CELLS
| ~ J [
""
GERM .7""":::: '.;~:.:. . . . . J'~

6 6 g 6 6 6 6
Figure 4-. A postulated sequence of events in neuroendocrine development, differentiation of the testes,
and the initiation of spermatogenesis between birth (B) and puberty (P) in well-fed Holstein bulls. Age is shown
in weeks. Starting at about 12 wk, a sequence of events induces a) initiation of pulsatile discharge of LH, possi-
bly resulting from a diminished suppression of GnRH discharge from the hypothalamus or from an increased
capacity of the anterior pituitary to respond to GnRH; b) LH-induced differentiation of Leydig cells with
increased secretion of androstenedione in response to LH stimulation; c) further differentiation of Leydig
cells resulting in LH-stimulated secretion of testosterone; d) testosterone-induced differentiation of indifferent
supporting cells to Sertoli cells concomitant with testosterone induced differentiation of gonocytes to presper-
matogonia and A-spermatogonia; e) an increased sensitivity of the hypothalamic-pituitary complex to the
negative feedback action of gonadal steroids; f) a somewhat diminished frequency and amplitude of LH dis-
charges; g) cessation of Sertoli cell formation followed by formation of junctional complexes between adjacent
Sertoli cells and establishment of the blood-testis barrier; h) sequential formation of primary spermatocytes,
spermatids and spermatozoa; and i) continued increases in the efficiency of spermatogenesis until sufficient
sperm are produced to provide the first ejaculum around 37 wk.

regional differences in epithelial m o r p h o l o g y ducts plus initial segment of the caput are
and the c o n c e n t r a t i o n of sperm within the involved in the resorption of fluid and solutes
epididymal duct. The n o t i o n that sperm from from the ductal l u m e n and m a y secrete other
proximal part of the epididymis were infertile, c o m p o u n d s . Sperm entering the epididymis
whereas those from the distal cauda epi- are infertile, b u t acquire fertilizing capacity
didymidis were fertile, was accepted based during a m a t u r a t i o n a l process. The middle
on classic studies with guinea pigs (Young, segment of the epididymis, which is comprised
1931). It also was recognized that the cauda of the major portions of the caput and corpus,
epididymidis served as a reservoir for sperm. is the site of sperm m a t u r a t i o n (Orgebin-Crist
It n o w is recognized that from a f u n c t i o n a l et al., 1975; Holtz and Smidt, 1976; F o u r n i e r -
point of view the epididymis has three seg- Delpech et al., 1979; J o h n s o n et al., 1980).
ments, although the duct has m a n y more The terminal segment, essentially the cauda
cytologically distinct regions (Nicander, 1958; epididymidis, together with the proximal
Glover and Nicander, 1971). The efferent deferent duct, is involved in the storage of
392 AMANN ANDSCHANBACHER

TABLE 2. SPERM RESERVES OF SEXUALLY RESTED, ADULT DOMESTIC ANIMALS (109/MALE)a

Epididymis
Caput Corpus Cauda Duct-us and ampulla Total
Bull
Hereford 11 1 21 6 40
Charolais 18 4 35 7 64
Holstein 20 5 39 8 72
Stallion 12 17 54 7 90
Ram
lie de France 23 11 126 ? >165
Suffolk 17 9 104 ? > 135
Boar
Yorkshire 76 51 234 ? >361

acompiled from the literature.

fertile sperm (table 2). Movement of sperm characteristics of ' t h e spermatozoal plasma
through the caput and corpus epididymidis membrane and changes in sperm metabolism
primarily is by continuous peristaltic con- (Bedford, 1975; Orgebin-Crist et al., 1981;
tractions of the smooth muscle surrounding Hammerstedt Ct al., 1982). Simple retention
the ductus epididymidis. In the cauda, con- of sperm within a given segment of the epi-
tractions are much less frequent and the duct didymal duct is insufficient to induce sperm
is inactive except when the smooth muscle maturation. Secretions by the epididymal
is stimulated to contract. Consequently, the epithelium must modify the spermatozoa.
time required for movement of sperm through Sperm leaving the corpus epididymidis are
the caput and corpus epididymidis is not fertile. However, studies with rams have lead
altered by ejaculation and is similar for c o m - to the concept that survival of embryos re-
mon mammals (table 3). suiting from sperm leaving the distal corpus
The biology of sperm maturation is not may be lower than for embryos resulting
understood. Evidence for sperm maturation from sperm taken from the cauda epididymidis
includes the acquisition of fertilizing capacity, (Fournier-Delpech et al., 1979). Based on
acquisition of progressive motility, changes research with ram sperm (Hammerstedt et al.,
in spermatozoal morphology, changes in 1982), it is likely that changes in the plasma
membrane are central to the process of sperm
maturation. These changes certainly include
alteration of exposed glycoproteins, membrane
TABLE 3. TRANSIT TIME OF SPERMATOZOA fluidity and transfer of substrates across the
THROUGH THE EPIDIDYMIS (DAYS) a plasma membrane. Sperm maturation is
dependent on secretions of the epididymal
Caput and corpus Cauda
epithelium as well as the transport of sodium,
Bull potassium and other compounds. These
Hereford 2.0 3.6 processes are dependent upon dihydrotestos-
Charolais 2.5 3.9
Holstein 3.1 5.2 terone, aldosterone and possibly other h o r -
Stallion mones (Orgebin-Crist and Jahad, 1978; Turner
4.0 9.8
and Cesarini, 1981).
Ram
lie de France The conditions and processes by which
3.6 12.8
Suffolk 2.1 8.3 fertile sperm remain viable for several weeks
within the cauda epididymidis are of great
Boar 5.4 6.4
biologic importance, but virtually unexplored.
The temperature of the cauda is lower than
acompiled from the literature. Transit time
through the caput-corpus epididymidis is unaffected that of the caput or corpus epididymidis.
by ejaculation, but transit time through the cauda Indeed, it has been suggested that the scrotum
is reduced two to four days by daily ejaculations. evolved as a device to cool the cauda epi-
MALE REPRODUCTION 393

didymidis rather than the testis (Bedford, and Foote, 1969; Lino, 1972; Amann et al.,
1978; Foldesy and Bedford, 1982). Although 1976).
not universally accepted, it generally is assumed
that sperm are immotile within the confines
of the ductus epididymidis and become motile Reproductive Capacity
only by removal of contact inhibition (Cascieri
et al., 1976) or dilution of suppressor molecules Semen Collection
(Turner et al., 1978). The substrates utilized The general approaches for semen collection
for energy production by sperm within the have not changed greatly during the past three
cauda epididymidis and the problem of moving decades. These approaches are use of an arti-
substrates or metabolites across the consider- ficial vagina with the bull, ram or stallion;
able distance from the ductal epithelium electroejaculation with the bull and ram;
to the center of the duct have not been ad- and digital manipulation for the boar. The
dressed. Molecular transport to and from m o s t notable advancement has been the
sperm within the ductal lumen may be facili- improvement of electrostimulators and in
tated by the mixing of sperm that probably the design of rectal probes used for collection
occurs through ductal contractions and physical of bull and ram semen (Ball, 1974). Use of
manipulations. a rectal probe with two or three parallel elec-
Since the rate of sperm movement through trodes on the ventral surface, rather than
the caput and corpus epididymidis, those circumferential electrodes or longitudinal
areas where sperm maturation occurs, is not electrodes equally spaced on the surface of
influenced by ejaculation (Amann and Alm- the electrode, has led to a great reduction
quist, 1962; Swierstra, 1971), the fertility in stress of the animal and an increased suc-
of sperm should not be depressed even in cess in seminal collection.
males ejaculating frequently. This is true Although the equipment used for semen
for daily or thrice weekly ejaculation (Hafs collection has not changed, the procedures
et al., 1959; Almquist, 1982) and for 5 or used during semen collection and the general
11 ejaculates collected in succession (Salamon, management of bulls have changed dramat-
1962; Martig et al., 1970). Although the ically. In the early 1950's, it was believed
transit time for sperm through the caput that collection of semen more than once
and corpus epididymidis is not altered by weekly would damage testicular function
ejaculation, the interval that sperm spend and might be detrimental to the health of
in the cauda is influenced profoundly by a bull. These notions were dispelled by a
ejaculation frequency (Amann and Almquist, series of studies (Bratton and Foote, 1954;
1976; Amann, 1981). The number of sperm Baker et al., 1955; Almquist and Hale, 1956;
in the cauda is maximal in males that have VanDemark, 1956; Hafs et al., 1959; Dukelow
not ejaculated for at least 7 to 10 d, but et al., 1960; Hale and Almquist, 1960) that
is reduced by at least 25% in males ejaculating convincingly demonstrated that bulls could
daily or every other day (Ortavant, 1958; be collected routinely 2, 3 or 7 d per week,
Amann and Almquist, 1962; Swierstra, 1971; week after week.
Pickett et al., 1981). A genetically superior sire is in essence
Sperm are produced continuously regard- a sperm factory producing packets (sperma-
less of ejaculation frequency. Since sperm tozoa) of genetically superior DNA. Rejec-
enter the epididymis at a constant rate, they tion of the notion that frequent collection
also must leave the excurrent duct at a rela- of a breeding male was harmful was essential
tively constant rate, although this rate is for exploitation of a superior sire. Education
influenced by ejaculation. Based on studies of lay and professional personnel was required
with bulls and rams (Koefoed-Johnsen, 1964; to gain acceptance that the important criterion
Lino and Braden, 1972), it is evident that of semen quality was the number of sperm
sperm that are not ejaculated at copulation harvested per day or per week, rather than
or voided by masturbation are eliminated the volume or concentration of spermatozoa
periodically during urination. Resorption with- in a given ejaculate (Almquist and Hale, 1956;
in the excurrent duct system of significant VanDemark, 1956; Hafs et al., 1959). Collec-
numbers of sperm does not occur (Paufler tion of semen from boars, rams and stallions
394 AMANN AND SCHANBACHER

daily, or even several times daily, is without zation has occurred, the number of sperm
deleterious effect on fertility. obtained in subsequent ejaculates should
oscillate around a mean value characteristic of
Sexual Behavior that male at that time of year. When expressed
A full understanding of sexual behavior as the mean number of sperm obtained per day,
this value is termed daily sperm output.
is critical to successful collection of four
to seven ejaculates weekly from a male. Classic If one ejaculate is collected each day, or
if several ejaculates are collected every 2
studies outlined procedures to maximize the
or 3 d, daily sperm output will be maximal
number of sperm obtained in a given ejaculate
provided appropriate sexual preparation is
and minimize the time expended in collecting
used prior to collection of each ejaculate.
the ejaculate (Collins et al., 1951; Branton
If sufficient samples are collected to obtain
et al., 1952; Hale and Almquist, 1960; Hafs
a valid estimate, daily sperm output is
et al., 1962; Hale, 1966). Bulls differ greatly
highly correlated with and approaches
in their inherent level of sexual activity (Hale
daily sperm production (Amann, 1970, 1981;
and Almquist, 1960; Chenoweth, 1983).
Amann et al., 1976). Daily sperm output
Sexual stimulation is presentation of a
increases for some time following puberty,
stimulus situation which will ellicit mounting
may vary with season and differs greatly
in the shortest possible time. Attainment
among males of a given breed or species because
of this objective is dependent upon novelty
of differences in their testicular size.
(Hale and Almquist, 1960). Novelty can be
The need for collection of multiple samples
obtained by a) introducing a new stimulus
to study testicular function on the basis of
animal or combination of stimulus animals
semen characteristics often is overlooked.
in a given location, b) presenting familiar
Evaluation of a single ejaculate provides no
stimulus animals in a new location, or c)
valid information on the number of sperm
changing both the stimulus animal and the
location simultaneously. being produced, other than if the male had
The goal of sexual preparation is to collect been producing spermatozoa in the last few
the greatest possible number of high quality weeks, but can provide limited information
sperm in an ejaculate. This is achieved by on the morphology and motility of sperm
prolongation of the period of sexual stimula- produced (Amann, 1981, 1982). Before under-
tion beyond that needed for mounting and taking an experiment involving semen collec-
ejaculation (Hale and Almquist, 1960). Ap- tion from boars, bulls, rams, or stallions,
proaches for sexually preparing a male are appropriate publications (Almquist, 1973;
a) the use of false mounts in which a male Amann and Almquist, 1976; Foote, 1978;
is allowed to mount the stimulus animal but Pickett et al., 1981; Amann, 1982) should
not ejaculate, b) restraint of a male a few be consulted.
feet away from the stimulus animal, or c)
a combination of false mounting and restraint Spermatozoa, Semen Extension and Preservation
(Branton et al., 1952; Hafs et al., 1962; Hale,
1966; Almquist, 1973). The concept of sexual Spermatozoa
preparation is applicable to sheep and boars Enormous strides have been made within
(Hemsworth and Galloway, 1979), but not the past 25 yr in our understanding of the
stallions (Pickett and Voss, 1973). biology of spermatozoa. This topic is an ex-
cellent example of how improvements in
Daily Sperm Output techniques for analysis of cellular ultrastmc-
If routine semen collections every one to ture, metabolic processes, membrane structure
three days are initiated with a previously and function, immunology and molecular
sexually rested male, the first few ejaculates biology can be focused on a single complex
will contain more sperm than subsequent cell to begin to unravel its life story. Because
ejaculates. This is because the number of sperm of the impetus of artificial insemination of
within the cauda epididymidis is reduced by dairy cattle, by the early 1960's the fine
ejaculation until it stabilizes at about 25% structure of the bovine sperm (Saacke and
lower than that characteristic of a sexually Almquist, 1964) and the dependence of sperm
rested male (Amann, 1970). Once such stabili- on glucose or fructose as major energy sub-
MALE REPRODUCTION 395

strates (Mann, 1954) had been established. generated CO2 from bicarbonate and citric
The biology of spermatozoal development acid incorporated in the buffer (Foote et al.,
and function is not considered in this review 1960). The second was based upon the addition
because excellent, recent reviews are available at 5~ of 10% glycerol to semen extended
(Bellv~, 1979, 1982; Hammerstedt, 1981; in heated milk (Almquist, 1962). Both the
Mann and Litwak-Mann, 1981; Zaneveld CO2-containing and glycerol-containing ex-
and Chatterton, 1982). tenders gave marked improvements in con-
In the past decade, studies of spermatozoal ception rate for semen used on the third
biology have solidified the notion (Mann, and fourth day after collection. A variety
1954) that one should not consider as separate, of other buffers have been evaluated (Salis-
discrete events the processes of spermato- bury et al., 1978). Inclusion of caproic acid
genesis, epididymal maturation of sperm, in a citrate-buffered egg yolk extender gassed
storage of sperm outside of the animal body, with nitrogen (Shannon, 1972) has been
transit of sperm into the female reproductive used routinely to the present time in New
tract, capacitation and activation of sperm, Zealand.
and fertilization. Rather, following completion The economics of artificial insemination
of the second division of meiosis, the newly of sheep and especially horses and swine
formed spermatid undergoes a series of mor- is very different from the situation with cattle
phologic, biochemical, and membrane changes because of the number of females that can
which continue after release of a spermatozoon be inseminated with one ejaculate. With cattle,
from the germinal epithelium, during its transit up to 1,000 cows can be inseminated with
through the epididymis and the female repro- one ejaculate. With boar, ram or stallion semen,
ductive tract, and culminate in the process however, insemination of only 5 to 50 females
of fertilization. Thus, observed spermatozoal per ejaculate is possible. This limitation has
characteristics may have been induced by reduced the potential genetic and economic
preceding events. Similarly, modifications of impacts of artificial insemination for those
the normal process, as induced by freezing species. Procedures for storage of boar, ram
and thawing spermatozoa or by artificial and stallion semen have been reviewed (Graham
insemination of fresh or frozen semen, almost et al., 1978).
certainly change the nature and timing of
subsequent events of the normal process. Frozen Semen
Such changes, even if undetected, may be The advent of frozen semen (Polge et al.,
responsible for the observed variation among 1949), and especially its wide-scale adoption
males in fertility of frozen semen. for artificial insemination of cattle, revolu-
tionized cattle breeding. Initially, semen
Liquid Semen was p~ckaged in 1-ml glass ampules and frozen
By the mid-1950's, artificial insemina- and stored in alcohol cooled with solid carbon
tion of cattle using bull semen extended in dioxide (Salisbury and VanDemark, 1961).
either egg yolk citrate or heated cows' milk This system was used commercially with
was routine (Salisbury and VanDemark, 1961). frozen semen in the U.S. However, the wide-
Inclusion of the antibiotics, penicillin and spread adoption and international use of
streptomycin, was an accepted practice. For frozen semen came only after the development
semen stored at 5~ C, fertility was satisfactory of superinsulated, cryogenic field storage
for two days following collection and exten- units in 1959 and reports that use of liquid
sion. Procedures also were available for short- nitrogen, to provide storage at - 1 9 6 ~ re-
term preservation of semen from boars, rams suited in higher conception rates than storage
and stallions (Maule, 1962), although insemina- at - 7 9 ~ and essentially indefinite storage
tion of fresh semen was more conventional. (Salisbury et al., 1978; Herman, 1981). For
In the late 1950's, two approaches were about 15 yr after glycerol was shown to be
developed to obtain satisfactory conception a suitable cryoprotective agent for freezing
rates for 3 to 5 d following extension of bull spermatozoa, an extraordinary effort
bull semen. One utilized egg yolk extenders was aimed at development of improved ex-
with a complex buffer that was gassed with tenders and procedures for packaging and
CO2 (VanDemark and Sharma, 1957) or freezing semen, and on the interaction between
396 AMANNAND SCHANBACHER

freezing rate and thawing rate (Pickett et al., sperm during the freezing-thawing process
1978; Salisbury et al., 1978). (Watson, 1979). With some species, it is essen-
The introduction of plastic straws in 1964 tial to change the composition of the extender
resulted in more efficient storage of semen, after thawing the spermatozoa to maximize
reduced losses of sperm during insemination, conception rate (Larsson and Einarsson, 1976).
and gave a slight improvement in conception However, with all three species, the results
rate (Pickett and Berndtson, 1974). In most are adequate to allow preservation and use
parts of the world, semen now is packaged with valuable germ plasm when breed regula-
in 0.25-ml straws, although in the U.S. the tions permit this.
0.5-ml straw is standard. Freezing semen
in the form of a small pellet has been tested.
The Future
This approach never received widespread
acceptance with bull semen, but has been By the year 2,000, animal scientists will have
used with boar (Johnson et al., 1981b) and expanded our basic knowledge of male re-
ram (Salamon and Lightfoot, 1970)semen. productive physiology to the point that farmers
Even with the best procedures for freezing and ranchers will have many options for
and thawing bull sperm, at least 20% of the manipulation of reproductive processes. The
sperm are rendered immotile. Damage prob- extent to which available processes are applied
ably is caused by the interactions of two will be determined by the economic tradeoffs
physical factors (Watson, 1979). These are associated with producing food and fiber.
a) formation of ice crystals that damage the It is reasonable to expect that efficient ex-
spermatozoa and b) increases in solute con- ploitation of genetically superior sires of all
centration as pure water is withdrawn by classes of livestock will have increased. How-
crystallization of the extracellular solvent. ever, the greatest impact of this research will
Conception rates for cattle inseminated be on dairy cattle and swine.
with frozen and thawed semen potentially Many future sires will be conceived as a
are equivalent to those obtained by insemina- result of planned matings accomplished by
tion of unfrozen semen or by natural service. artificial insemination followed by sexing
In some situations, this potential is not and splitting of embryos, transfer of de-
achieved because of inaccurate detection sirable embryos to appropriate recipients,
of estrus or faulty insemination technique. and possibly manipulation of reproductive
The success of procedures used to freeze development before or after birth. The ob-
bovine spermatozoa is exemplified best by jective of these manipulations will be to
the drastic reduction in the number of sperm produce individuals genetically superior for
used for each insemination dose. For many economically important traits which also
bulls of known fertility, it is possible to reduce have an enhanced reproductive capacity.
the number of motile sperm per insemination Manipulations of the neuroendocrine system
dose to 4 x 106 without reducing conception should allow reduction of the age at puberty
rate (Pace et al., 1981). Consequently, as and development of males producing more
many as 100,000 insemination doses can be sperm than today's sires. Although it is unlikely
processed annually from a superior sire and that the number of sperm produced per gram of
numerous Holstein bulls have been mated testis can be increased greatly above current
to more than 50,000 cows annually. values, the normal attrition of potential germ
Although the application of frozen semen cells may be reduced. The sexual behavior
technology to cattle breeding progressed of sires used in artificial insemination may
rapidly during the early 1960's, application be modified by hormones, pheromones or
with other species has been limited. Con- drugs acting on the central nervous system
ception rates and litter size achieved with to minimize the time required for semen
frozen boar semen are lower than with un- collection. Manipulation of the seasonal pattern
frozen semen (Johnson et al., 1981b). Simi- in sperm production of rams and stallions
larly, results with frozen ram (Graham et al., will be commonplace.
1978) and stallion (Klug et al., 1980; Loomis Artificial insemination of beef cattle and
et al., 1983) semen have been disappointing. sheep will increase, but will remain at a far
There are distinct species' differences in the lower percentage saturation than for dairy
extender required for optimum sulwival of cattle or swine. Even with superior methods
MALE REPRODUCTION 397

for control of estrus and ovulation, it probably By the year 2,000, a modern semen labora-
will not be economical to use artificial in- tory still will have a phase-contrast microscope
semination with herds and flocks maintained to allow visual examination of semen quality.
on the range. It seems inevitable that the However, spermatozoal motility, velocity and
majority of the sheep and beef cattle will concentration probably will be measured
continue to be bred by natural mating under by dipping a fiber optic probe into a semen
conditions which maximize the utilization sample. Sperm morphology may be evaluated
of forage but make difficult, or preclude, by computer. In the research laboratory, the
application of high technology management quality of frozen and thawed spermatozoa
practices. However, sires used for natural will be evaluated by measuring selected at-
mating will have undergone a breeding sound- tributes ot~ the spermatozoal plasma membrane
ness examination because farmers and ranchers in addition to an automated assessment of
will have recognized that failure to select spermatozoal motility. The role of the sperma-
sires for reproductive performance is a false tozoon as a cause of embryo death may be
economy. clarified.
Techniques for artificial insemination of As farmers and ranchers enter the twenty-
cattle with frozen semen probably will not first century, they will have an unprecedented
change dramatically. However, the artificial array of procedures to modify reproductive
insemination of swine using non-frozen semen function in the male. Benefits derived from
may become a widely accepted practice. these procedures certainly will contribute
This will occur if our understanding of sperm to humanity through enhanced efficiency
membrane physiology allows development of food and fiber production.
of techniques that enable normal conception
rates and litter size following insemination Literature Cited
of far fewer sperm than currently are neces-
Albert, A. 1961. The mammalian testis. In: W. C.
sary. Improved procedures for freezing sperm Young and G. W. Corner (Ed.) Sex and Internal
from the boar, ram and stallion may provide Secretions (3rd Ed.). Vol. 1. p 305. The Williams
increased survival of these sperm within the & Wilkins Co., Baltimore, MD.
female reproductive tract. Conception rates Almqulst, J. O. 1962. Diluents for bovine semen.
XI. Effect of glycerol on fertility and motility
using frozen semen with these three species of spermatozoa in homogenized and skim milk.
should approach that attainable with unfrozen J. Dairy Sci. 45:911.
semen, as has been true with cattle for the Almquist, J. O. 1973. Effects of sexual preparation
past decade. The greatest impact of this line on sperm output, semen characteristics and
of research will be a great reduction in the sexual activity of beef bulls with a comparison
to dairy bulls. J. Anita. Sci. 36:331.
number of sperm required for successful Almquist, J. O. 1982. Effect of long term ejaculation
insemination of swine. For all species the at high frequency on output of sperm, sexual
accuracy and ease of detecting estrus may behavior, and fertility of Holstein bulls; relation
be improved. of reproductive capacity to high nutrient allow-
Insemination of frozen semen enriched ance. J. Dairy Sci. 65:814.
Almquist, J. O. and E. B. Hale. 1956. An approach
for sperm bearing either the X- or the Y- to the measurement of sexual behavior and
chromosome, with at least 80% offspring semen production of dairy bulls. Proc. 3rd
of the desired sex, seems likely. Attainment Inter. Congr. Anita. Reprod. and A.I., Plenary
of this goal is reasonable because of the recent Papers: 50.
Amann, R. P. 1970. Sperm production rates. In:
development of procedures for monitoring A. D. Johnson, W. R. Gomes, and N. L. Van-
the effectiveness, or lack thereof, of a given Demark (Ed.). The Testis. Vol i. p r Aca-
separation technique. Although application demic Press, NY.
of sexed semen in commercial dairy herds Amann, R. P. 1981. A critical review of methods
for evaluation of spermatogenesis from seminal
seems likely, its impact on other species of
characteristics. J. Androl. 2:37.
livestock may be marginal. The utilization Amann, R. P. 1982. Use of animal models for de-
of freeze-dried spermatozoa for routine arti- tecting specific alterations in reproduction.
ficial insemination is not envisioned. Under Fund AppI, Toxicol. 2:13.
special circumstances, however, lyophilized Amann, R. P. 1983. Endocrine changes associated
with onset of spermatogenesls in Holstein bulls.
spermatozoa may be directly injected into J. Dairy Sci. 66:(ln press).
an oocyte with resulting embryonic develop- Amann, R. P. and J. O. Almquist. 1962. Reproductive
ment. capacity of dairy bulls. VI. Effect of unilateral
398 AMANN AND SCHANBACHER

vasectomy and ejaculation frequency on sperm 140:167.


reserves; aspects of epididymal physiology. Berndtson, W. E., J. H. Hoyer, E. L. Squires and
J. Reprod. Fertil. 3:260. B. W. Pickett. 1979. Influence of exogenous
Amann, R. P. and J. O. Almquist. 1976. Bull manage- testosterone on sperm production, seminal
ment to maximize sperm output. Proc. 6th quality and libido of stallions. J. Reprod. Fertil.
Tech. Conf. Artif. Insem. Reprod. p 1. Nat. (Suppl. 27):19.
Assoc. Anim. Breeders, Columbia. Blanc, M . R . , M.-T. Hochereau-de Reviers, C.
Amann, R. P. and V. K. Ganjam. 1976. Steroid Cahoreau, M. Courot and J. C. Dacheux. 1981.
production by the bovine testis and steroid trans- Inhibin: effects on gonadotropin secretion
fer across the pampiniform plexus. Biol. Reprod. and testis function in ram and rat. In: P. Franchi-
15:695. mont and C. P. Channing (Ed.). Intragonadal
Amann, R. P. and V. K. Ganjam. 1981. Effects of Regulation of Reproduction. p 299. Academic
hemicastration or hCG-treatment on steroids Press, NY.
in testicular vein and jugular vein blood of Bolender, R. P. 1982. Sterology and its uses in cell
stallions. J. Androl. 3:132. biology. An. NY Acad. Sci. 383:1.
Amann, R. P. and O. J. Walker. 1983. Changes in Booth, W. D. 1982. Testicular steroids and boar
the pituitary - gonadal axis associated with taint. In: D.J.A. Cole and G. R. Foxchroft
puberty in Holstein bulls. J. Anim. Sci. 57:(ln (Ed.). Control of Pig Reproduction. p 25.
press.) Butterworth, London.
Amann, R. P., J. F. Kavanaugh, L. C. Griel, Jr. and Branton, C., G. D'Arensborourgh and J. E. Johnston.
J. K. Voglmayr. 1976, Sperm production of 1952. Semen production, fructose content
Holstein bulls determined from testicular sper- of semen and fertility of dairy buUs as
matid reserves, after cannulation of rete testis related to sexual excitement. J. Dairy Sci. 35:
or vas deferens, and by daily ejaculation. J. 801.
Dairy Sci. 57:93. Bratton, R. W. and R. H. Foote. 1954. Semen pro-
Attal, J. and M. Courot. 1963. D6veloppement testicu- duction and fertility of dairy bulls ejaculated
laire et ~tablissement de la spermatogen~se either once or twice at intervals of either four
chez le tauraeau. Ann. Biol. Anita. Bioch. Bio- or eight days. J. Dairy Sci. 37:1439.
phys. 3:219. Bremner, W. J. 1981. Historical aspects of the study
Baker, F. M., N. L. VanDemark and G. W. Salisbury. of the testis. In: H. Burger and D. de Kretser
1955. The effect of frequency of ejaculation (Ed.). The Testis. p 1. Raven Press, NY.
on the semen production, seminal characteristics Burgus, R., M. Butcher, M. Amoss, N. Ling, M.
and libido of bulls during the first post-puberal Monahan, J. Rivier, R. Fellows, R. Blackwell,
year. J. Dairy Sci. 38:1000. W. Vale and R. Guillemin. 1971. Structure
Ball, L. 1974. Electroejaculation of bulls. Proc. 5th moleculaire du facteur hypothalamique (LRF)
Tech. Conf. A.I. and Reprod. p 101. Nat. Assoc. d'origine ovine controlant la secretion de
Anim. Breeders, Columbia. l'hormone gonadotrope hypophysaire de lute-
Bedford, J. M. 1975. Maturation, transport and inisation (LH). C. R. Acad. Sci. (Paris) 273:
fate of spermatozoa in the epididymis. In: 1611.
D. W. Hamilton and R. O. Greep (Ed.) Hand- Cascieri, M., R. P. Amann and R. H. Hammerstedt.
book of Physiology Sect. 7. Vol. 5. Male Re- 1976. Adenine nucleotide changes at initi-
productive System. p 303. Amer. Physiol. Soc., ation of bull sperm motility. J. Biol. Chem.
Washington, DC. 251:787.
Bedford, J. M. 1978. Anatortiical evidence for the Chenoweth, P. J. 1983. Sexual behavior in the bull:
epididymis as the prime mover in the evolution a review. J. Dairy Sci. 66:173.
of the scrotum. Amer. J. Anat. 152:483. Clegg, M. T., J. A. Santolucito, J. D. Smith and
Bedrak, E. and L. T. Samuels. 1969. Steroid bio- W. F. Ganong. 1958. The effect of hypothalamic
synthesis by the equine testis. Endocrinology lesions on sexual behavior and estrous cycles
85:1186. in the ewe. Endocrinology 62:790.
Bellvd, A. R. 1979. The molecular biology of mam- Clermont, Y. and C. P. Leblond. 1955. Spermio-
malian spermatogenesis. Oxford Rev. Biol. genesis of man, monkey, ram and other mam-
1:159. mals as shown by the "periodic acid-Schiff"
Belly', A. R. 1982. Biogenesis of the mammalian technique. Amer. J. Anat. 96:229.
spermatozoon. In: R. P. Amann and G. E. Collins, W. J., R. W. Bratton and C. R. Henderson.
Seidel, Jr., (Ed.). Prospects for Sexing Mam- 1951. The relationship of semen production
malian Sperm. p 69. Colorado Assoc. Univ. to sexual excitement of dairy bulls. J. Dairy
Press, Boulder. Sci. 34:224.
Benoit, M. J. 1926. Recherches anatomiques, cyto- Coulter, G. H. 1980. Testicular development: its
logiques et histophysiologiques sur les voies management and significance in young beef
excretrice du testicle, chez les mammif~res. bulls. Proc. 8th Tech. Conf. p 106. Nat. Assoc.
Arch. Anat. 5:173. Anim. Breeders, Columbia.
Berndtson, W. E. 1977. Methods for quantifying Courot, M. 1967. Endocrine control of the supporting
mammalian spermatogenesis: A review. J. Anim. and germ cells of the impuberal testis. J. Reprod.
Sci. 44:818. Fertil. 2:89. p .

Berndtson, W. E. and C. Desjardins. 1974. The cycle Courot, M. 1971. Etabhssement de la spermato-
of the seminiferous epithelium and spermato- gan~se chez l'agneau (Ovis aries) Etude expari-
genesis in the bovine testis. Amer. J. Anat. mentale de son contr61e gonadotrope; impor-
MALE REPRODUCTION 399

tance des cellules de la ligu~e sertolienne. D. Sc. of the rat cauda epididymidis. Biol. Reprod.
Thesis, Univ. Paris, Paris. 26:673.
Courot, M., M.-T. Hocherean-de Reviers and R. Foote, R. H. 1969. Research techniques to study
Ortavant. 1970. Spermatogenesis. In: A. D. reproductive physiology in the male. In: Tech-
Johnson, W. R. Gomes, and N. L. VanDemark niques and Procedures in Animal Science Re-
(Ed.). The Testis. Vol. 1. p 339. Academic search, p 80. Amer. Soc. Anim. Sci., Cham-
Press, New York. paign, IL.
Curtis, S. K. and R. P. Amann. 1981. Testicular Foote, R. H. 1978. Factors influencing the quantity
development and establishment o f spermato- and quality of semen harvested from bulls,
genesis in Holstein bulls. J. Anim. Sci. 53:1645. rams, boars and stallions. J. Anim. Sci. 47(Suppl.
David, K., E. Dingemanse, J. Freud and E. Laquer. 2):1.
1935. Uber krystallinisches mannliches Hormon Foote, R. H., L. C. Gray, D. C. Young and H. O.
aus Hoden (Testosteron) wirksamer als aus Dunn. 1960. Fertility of bull semen stored
Harn oder aus Cholesterin bereitetes Andro- up to four days at 5~ in 20% egg yolk ex-
steron. Z. Physiol. Chem. 233:281. tenders. J. Dairy Sci. 43:1330.
Davidson, J. M. 1974. Hypothalamic-pituitary regula- Ford, J. J. 1982. Testicular control of defeminization
tion of puberty, evidence from animal experi- in male pigs. Biol. Reprod. 27:425.
mentation. In: The Control of Onset of Puberty. Ford, J. J. and B. D. Schanbacher. 1977. Luteinizing
p 79. hormone secretion and female lordosis behavior
de Graaf, R. 1668. A treatise concerning the gener- in male pigs. Endocrinology 100:1033.
ative organs of men. Translated by H. D. Jocelyn Foster, D. L., I. H. Mickelson, K. D. Ryan, G. A.
and B. P. SetcheU. J. Reprod. Fertil. (Suppl. Coon, R. A. Drongowski and J. A. Holt. 1978.
17):1. Ontogeny of pulsatile luteinizing hormone
D'Occhio, M. J., J. E. Kinder and B. D. Schanhacher. and testosterone secretion in male lambs. Endo-
1982a. Patterns of LH secretion in castrated crinology 102:1137.
bulls (steers) during intravenous infusion of Fournier-Delpech, S., G. Colas, M. Courot, R. Orta-
androgenic and estrogenic steroids: pituitary vant and G. Brice. 1979. Epididymal sperm
response to exogenous luteinizing hormone maturation in the ram: motility, fertilizing
releasing hormone. Biol. Reprod. 26:249. ability and embryonic survival after uterine
D'Occhio, M. J., B. D. Schanbacher and J. E. Kinder. artificial insemination in the ewe. Ann. Biol.
1982b. Relationship between serum testosterone Anim. Bioch. Biophys. 19:597.
concentration and patterns of luteinizing hor- Franchimont, P., K. Henderson, G. Verhoeven, M. T.
mone secretion in male sheep. Endocrinology Hazee-Hagelstein, C. Charlet-Renard, A. De-
110:1547. moulin, J. P. Bourguignon and M. J. Lecomte-
D'Occhio, M. J., B. D. Schanbacher and J. E. Kinder. Yerna. 1981. Inhibin: mechanisms of action
1982c. Testosterone feedback on FSH secretion and secretion. In: P. Franchimont and C. P.
in male sheep. J. Reprod. Fertil. 66:699. Channing (Ed.). Intragonadal Regulation of
Dukelow, W. R., E. C. Frederick and E. F. Graham. Reproduction. p 167. Academic Press, New York.
1960. Frequency of ejaculation in the bovine. Frankenhuis, M. T., D. G. de Rooij and M. F. Kramer.
J. Dairy Sci. 43:1335. 1980. Spermatogenesis in the pig. Proc. 9th
Dym, M. and D. W. Fawcett. 1971. Further observa- Inter. Congr. Anim. Reprod. and A.I. 5:17.
tions on the numbers of spermatogonia, sperma- Gier, H. T. and G. B. Marion. 1970. Development
tocytes and spermatids connected by inter- of the mammalian testis. In: A. D. Johnson,
cellular bridges in the mammalian testis. Biol. W. R. Gomes and N. L. Vandemark, (Ed.).
Reprod. 4:195. The Testis. Vol. 1. p 1. Academic Press,
Ewing, L. L. and B. L. Brown. 1977. Testicular New York.
steroidogenesis. In: A. D. Johnson and W. R. Glover, T. and Nicander, L. 1971. Some aspects
Gomes (Ed.). The Testis. Vol. 4. p 239. Aca- of structure and function in the mammalian
demic Press, New York. epididymis. J. Reprod. Fertil. (Suppl. 13) : 39.
Fawcett, D. W., L. V. Leak and P. M. Heidger, Jr. Graham, E. F., B. G. Crabo and M. M. Pace. 1978.
1970. Electron microscopic observations on Current status of semen preservation in the
the structural components of the blood-testis ram, boar and stallion. J. Anim. Sci. 47(Suppl.
barrier. J. Repro& Fertil. (Suppl. 10): 105. 2):80.
Flavo, R. E. and A. V. Nalbandov. 1974. Radio- Greep, R. O., H. L. Fevold and F. L. Hisaw. 1936.
immunoassay of peripheral plasma testosterone Effect of two hypophyseal gonadotropic hor-
in males from eight species using specific anti- mones on the reproductive system of the male
body without chromotography. Endocrinology rat. Anat. Rec. 65:261.
95:1466. Hafs, H. D. and M. S. McCarthy. 1979. Endocrine
FlorCruz, S. V. and K. R. Lapwood. 1978. A longi- control of testicular function. In: H. W. Hawk,
tudinal study of pubertal development in boars: C. A. Kiddy and H. C. Cecil (Ed.). Animal Repro-
Investigation of the relationship between gonadal duction, p 345. John Wiley & Sons, New York.
and epididymal development and plasma lute- Hafs, H. D., R. S. Hoyt and R. W. Bratton. 1959.
inizing hormone and testosterone profiles. Libido, sperm characteristics, sperm output,
Int. J. Androl. 1:317. and fertility of mature dairy bulls ejaculated
Foldesy, R. G. and J. M. Bedford. 1982. Biology daily or weekly for thirty-two weeks. J. Dairy
of the scrotum. 1. Temperature and androgen Sci. 42:626.
as determinants of the sperm storage capacity Hafs, H. D., R. C. Knisely and C. Desjardins. 1962.
400 AMANN AND SCHANBACHER

Sperm output of dairy bulls with varying degrees 36 farms. J. Anim. Sci. 52:1130.
of sexual preparation. J. Dairy Sci. 45:788. Josso, N., J.-Y. Picard and D. Tran. 1977. The anti-
Hale, E. B. 1966. Visual stimuli and reproductive MUllerian hormone. Rec. Prog. Horm. Res.
behavior in bulls. J. Anim. Sci. 25(Suppl.):36. 33:117.
Hale, E. B. and J. O. Almquist. 1960. Relation of Josso, N., J.-Y. Picard, J. L. Dacheux and M. Courot.
sexual behavior to germ cell output in farm 1979. Detection of anti-MUllerian activity in
animals. J. Dairy Sci. 43(Suppl.):145. boar rete testis fluid. J. Reprod. Fertil. 57:397.
Hammerstedt, R. H. 1981, Monitoring the metabolic Jost, A. 1970. Hormonal factors in the sex differ-
rate of germ cells and sperm. In: K. W. McKerus entiation of the mammalian fetus. Phil. Trans.
(Ed.). Reproductive Processes and Contraception. Roy. Soc. (London) B.259:119.
p 353. Plenum Press, New York. Jost, A. B. Vigier and J. Prepin. 1972. Freemartins
Hammerstedt, R. H., S. R. Hay and R. P. Amann. in cattle: the first steps of sexual organogenesis.
1982. Modification of ram sperm membranes J. Reprod. Fertil. 29: 349.
during epididymal transit. Biol. Reprod. 27:745. Jost, A., B. Vigler, J. Prepin and J. P. Perchellet.
Haynes, N. B. and B. D. Schanbacher. 1983. The 1973. Studies on sex differentiation in mam-
control of reproductive activity in the ram. mals. Rec. Prog. Horm. Res. 29:1.
In: W. Haresign (Ed.). Sheep Production. p 441. Keogh, E. J., V.W.K. Lee, G. C. Rennie, H. G. Burger,
Butterworths, London. B. Hudson and D. M. de Kretser. 1976. Selective
Hemsworth, P. H. and D, B. Galloway. 1979. The suppression of FSH by testicular extracts. Endo-
effect of sexual stimulation on the sperm output crinology 98:997.
of the domestic boar. Anim. Reprod. Sci. 2:387. King, E., J. C. Martin and G. Kluge. 1980. Besamungs-
Herman, H. A. 1981. Improving Cattle by the Millions. station im Landgestiit Celle - Ergebnisbericht ans
Univ. of Missouri Press, Columbia. der Saison 1979. Hannoversches Pferd 54:63.
Hochereau, M.-T., M. Courot and R. Ortavant. 1964. Koefoed-Johnsen, H. H. 1958. UndersCgelser over
Marquage des cellules germinales du b~lier saeddannelsen, p 18. Aarsbereming, Kgl. Veter-
et du taureau par injection de thymidine triti6e Landhoh~jskole, Inst. Sterilitetsforskning,
dans l'art6re spermatique. Ann. Biol. Anim. Copenhagen.
Bioch. Biophys. 4:157. Koefoed-Johnsen, H. H. 1964. Spermieproduktion
Hochereau-de Reviers, M.-T. 1981. Control of sper- hos tyre. Udskillelsen af spermier med urinen
matogonial multiplication. In: K. W. McKerns red forskellige saedopsamlingshyppigheder, p 23.
(Ed.). Reproductive Processes and Contraception. Aarsbereming. Kgl. Veter-Landhoh~jskole, Inst.
p 307. Plenum Press, New York. Sterilitetsforskning, Copenhagen.
Hochereau-de Reviers, M.-T. and M. Courot. 1978. Kratz, J. L., C. J. Wilcox, F. G. Martin and R. B.
Sertoli cells and development of seminiferous Becker. 1983. Vital statistics and reasons for
epithelium. Ann. Biot. Anim. Biochem. Biophys. disposal of United States and Canadian artificial
18:573. insemination dairy sires. J. Dairy Sol. 66:642.
Holtz, W. and D. Smidt. 1976. The fertilizing capacity Lacroix, A. and J. Pelletier. 1979. LH and testosterone
of epididymal spermatozoa in the pig. J. Reprod. release in developing bulls following LH-RH
Fertil. 46:227. treatment. Effect of gonadectomy and chronic
Hooker, C. W. 1944. The postnatal history and func- testosterone propionate pre-treatment. Acta
tion of the interstitial cells of the testis of the Endocrinol. 91:719.
bull. Amer. J. Anat. 74:1. Land, R. B. and W. R. Carr. 1975. Testis growth
Hooker, C. W. 1970. The intertubular tissue of the and plasma LH concentration following hemi-
testis. In: A. D. Johnson, W. R. Gomes and castration and its relation with female prolif-
N. L. VanDemark (Ed.). The Testis. Vol. 1. icacy in sheep. J. Reprod. Fertil. 45:495.
p 483. Academic Press, New York. Larsson, K. and S. Einarsson. 1976. Fertility of
Huggins, C. and P. V. Moulder. 1945. Estrogen pro- deep frozen boar spermatozoa. Influence of
duction by Sertoli cell tumors of the testes. thawing diluents and of boars. Acta Vet. Scand.
Cancer Res. 5:510, 17:43.
Johnson, L. and D. L. Thompson, Jr. 1983. Age Levasseur, M.-C. 1977. Thoughts on puberty. Initia-
related and seasonal variation in the Sertoli cell tion of the gonadotropic function. Ann. Biol.
population, daily sperm production, and serum Anim. Biochem. Biophys. 17:345.
concentrations of follicle stimulating hormone, Levine, J . E . , K.-Y. F. Pau, V . D . Ramirez and
lutenizing hormone and testosterone in stallions. G. L. Jackson. 1982. Simultaneous measurement
Biol. Reprod. (In press). of luteinizing hormone release in unanes-
Johnson, L., R. P. Amann and B. W. Pickett. 1980. thetized, ovariectomized sheep. Endocrinology
Maturation of equine spermatozoa. Amer. J. 111:1449.
Vet. Res. 41:1190. Lincoln, G. A. 1979. Differential control of luteinizing
Johnson, L., C. S. Petty and W. B. Neaves. 1981a. hormone and follicle-stimulating hormone by
A new approach to quantification of spermato- luteinizing hormones releasing hormone in the
genesis and its applications to germinal cell ram. J. Endocrinol. 80:133.
attrition during human spermiogenesis. Biol. Lincoln, G. A. 1981. Seasonal aspects of testicular
Reprod. 25:217. function. In: H. Burger and D. de Kretser (Ed.).
Johnson, L. A., J. G. Aalbers, J. T. Willems and The Testis. p 255. Raven Press, New York.
W. Sybesma. 1981b. Use of boar spermatozoa Lincoln, G. A. and R. V. Short. 1980. Seasonal
for artificial insemination. I. Fertilizing capacity breeding: nature's contraceptive. Rec. Prog.
of fresh and frozen spermatozoa in sows on Horm, Res. 36:1.
MALE REPRODUCTION 401

Lindner, H. R. 1959. Androgens in the bovine testis 59:559.


and spermatic vein blood. Nature (Lond) 183: Neaves, W. B. 1977. The blood-testis barrier. In:
1605. A. D. Johnson and W, R. Gomes (Ed.). The
Lindner, H. R. 1961. Androgens and related com- Testis. Vol. 4. p 126. Academic Press, New
pounds in the spermatic vein blood of domestic York.
animals. IV. Testicular androgens in the ram, Nett, T. M. and T. E. Adams. 1977. Further studies
boar and stallion. J. Endocrinol. 23:171. on the radioimmunoassay of gonadotropin-
Lino, B. F. 1971. Cell count correction factors for releasing hormone: effect of immunoreactivity
the quantitative histological analysis of the in serum. Endocrinology 101:1135.
germinal epithelium of the ram. Anat. Rec. Nicander, L. 1958. Studies on the regional histology
170:413. and cytochemistry of the ductus epididymidis
Lino, B. F. 1972. The output of spermatozoa in in stallions, rams and bulls. Acta Morphol.
rams. II. Relationship to scrotal circumference, Neerlando. Scand. 1 : 337.
testis weight, and the number of spermatozoa Niswender, G. D., L. E. Reiehert, A. R. Midgley and
in different parts of the urogenital tract. Aus- A. V. Nalbandov. 1969. Radioimmunoassay
tralian J. Biol. Sci. 25:359. for bovine and ovine luteinizing hormone.
Lino, B. F. and A.W.H. Braden. 1972. The output Endocrinology 84:1166.
of spermatozoa in rams. I. Relationship with Oh, R. and B. Tamaoki. 1970. Steroidogenesis in
testicular output of spermatozoa and the effect equine testis. Acta Endocrinol. 64:1.
of ejaculations. Australian J. Biol. Sci. 25: Orgebin-Crist, M.-C. and N. Jahad. 1978. The matura-
351. tion of rabbit epididymal spermatozoa in organ
Loomis, P. R., R. P. Amann, E. L. Squires and B. W. culture: inhibition by antiandrogens and in-
Pickett. 1983. Fertility of unfrozen and frozen hibitors of ribonuncleic acid and protein syn-
stallion spermatozoa extended in EDTA-lactose- thesis. Endocrinology 103:46.
egg yolk and packaged in straws. J. Anita. Sci. Orgebin-Crist, M.-C., B. J. Danzo and J. Davies.
56:687. 1975. Endocrine control of the development
Mann, T. 1954. The Biochemistry of Semen. Methuen and maintenance of sperm fertilizing ability
& Co., Ltd. London. in the epididymis. In: D. W. Hamilton and
Mann, T. and C. Lutwak-Mann. 1981. Male Reproduc- R. O. Greep (Ed.). Handbook of Physiology,
tive Function and Semen. Springer-Verlag, Sect. 7, Vol. V. Male Reproductive System.
Berlin. p 319. Amer. Physiol. Soc., Washington, DC.
McCuliagh, D. R. 1932. Dual endocrine activity Orgebin-Crist, M.-C., G. E. Olson and B. J. Danzo.
of testes. Science 76:19. 1981. Factors influencing maturation of sperma-
McNeilly, Judith R., A. S. McNeilly, J. S. Walton tozoa in the epididymis. In: P. Franchimont
and F. J. Cunningham. 1976. Development and C. P. Channing (Ed.). Intragonadol Regula-
and application of a heterologous radioimmuno- tion of Reproduction. p 393. Academic Press,
assay for ovine follicle-stimulating hormone. New York.
J. Endocrinol. 70:69. Ortavant, R. 1958. Le cycle spermatog6n6tique chez
Martig, R. C., J. O. Almquist and J. Foster. 1970. le b61ier. D. Sci. Thesis. Univ. Paris, Paris.
Reproductive capacity of beef bulls. V. Fer- Ortavant, R. 1977. Photoperiodic regulation of
tility and freezability of successive ejaculates reproduction in sheep. In: Management of
collected by different methods. J. Anita. Sci. Reproduction in Sheep and Goats. p 58. Amer.
30:60. Soc. Anim. Sci., Champaign, IL.
Matsuo, H., R.M.G. Nair, A. Arimura and A. V. Ortavant, R., M. Courot, and M.-T. Hochereau-de
Schally. 1971. Structure of the porcine LH- Reviers. 1977. Spermatogenesis in domestic
and FSH-releasing hormone: the proposed animals. In: H. H. Cole and P. T. Cupps (Ed.).
amino acid sequence. Biochem. Biophys. Res. Reproduction in Domestic Animals, 3rd Ed.
Comm. 43:1334. p 203. Academic Press, New York.
Maule, J. P. 1962. The Semen of Animals and Arti- Pace, M. M., J. J. Sullivan, F. I. Elliott, E. F. Graham
ficial Insemination. Commonwealth Agtic. and G. H. Coulter. 1981. Effects of thawing
Bureaux, Farnham Royal. temperature, number of spermatozoa and sper-
Meyer, A. W. 1938. The discovery and the earliest matozoal quality on fertility of bovine sperma-
representation of spermatozoa. Bull. Inst. Hist. tozoa packaged in .5-ml French straws. J. Anim.
Med. 6:89. Sci. 53:693.
Midgley, A. R., Jr., G. D. Niswender and J. Sri Ram. Parrott, R. F. and R. V. Davies. 1979. Serum gonado-
1969. Hapten-radioimmunoassay: a general pro- trophin levels in prepubertally castrated male
cedure for the estimation of steroidal and other sheep treated for long periods with propionated
haptenic substances. Steroids 13:731. testosterone, dihydrotestosterone, 19-hydroxy-
Monahan, M., J. Rivier, R. Burgus, M. Amoss, R. testosterone or oestradiol. J. Reprod. Fertil.
Blackwell, W. Vale and R. Guillemin. 1971. 56:543.
Synth/:se totale par phase solide d'un d6capeptide Paufler, S. K. and R. H. Foote. 1969. Sperm retention
qui stimule la s~cr&ion des gonadotropines and resorption in sexually active rabbits after
hypophysaires LH et FSH. C.R. Acad. Sci. (Paris) epididymal ligatures. Proc. Soc. Exp, Biol. Med.
273:508. 131:1179.
Neaves, W. B. 1973. Permeability of Sertoli cell tight Pickett, B. W. and W. E. Berndtson. 1974. Preservation
junctions to lanthanum after ligation of ductus of bovine spermatozoa by freezing in straws:
deferens and ductus efferentes. J. Cell Biol. a review. J. Dairy Sci. 57:1287.
402 AMANN AND SCHANBACHER

Pickett, B. W. and J. L. Voss. 1973. Reproductive Amer. J. Physiol. 242:201.


management of the stallion. Colo. State Univ. Schanbacher, B. D. 1982b. Hormonal interrelation-
Gen. Series Bull. no. 934. ships between hypothalamus, pituitary and
Pickett, B. W., W. E. Berndtson and J. J. Sullivan. testis of rams and bulls. J. Anim. Sci. 55 (Suppl.
1978. Influence of seminal additives and pack- 2):56.
aging systems on fertility of frozen bovine Schanbacher, B. D. and M. J. D'Occhio. 1982. Valida-
spermatozoa. J. Anita. S ci. 47(Suppl. 2):12. tion of a direct radioimmunoassay for testoster-
Pickett, B. W., J. L. Voss, E. L. Squires and R. P. one in unextracted serum from five species:
Amann. 1981. Management of the stallion application to study of the hypothalamic-
for maximum reproductive efficiency. Colo. pituitary-gonadal axis in males. J. Androl.
State Univ. Gen. Series Bull. no. 1005. 3:45.
Polge, C., A. Smith and A. S. Parkes. 1949. Revival Schanbacher, B. D. and J. J. Ford. 1977. Gonado-
of spermatozoa after vitrification and dehydra- tropin secretion in cryptorchid and castrate
tion at low temperatures. Nature (London) rams and the acute effects of exogenous steroid
164:666. treatment. Endocrinology 100:387.
Ramirez, V. D. and S. M. McCann. 1963. A compari- Schanbacher, B. D. and J. J. Ford. 1979. Photo-
son of the regulation of luteinizing hormone periodic regulation of ovine spermatogenesis:
(LH) secretion in immature and adult rats. relationship to serum hormones. Biol. Reprod.
Endocrinology 72:452. 20:719.
Ravault, J. P., M. Blanc, R. Ortavant, J. Pelletier Schanbacher, B. D., M. J. D'Occhio and T. W. Gettys.
and M. M. de Reviers. 1980. Variations circa- 1983. Pulsatile luteinizing hormone secretion
diennes et circannuelles de la s~cr&ion de pro- in the castrate male bovine: effects of testoster-
lactine, LH et FSH chez les animaux domestiques one or estradiol replacement therapy. J. Anim.
males. In: R. Ortavant and A. Reinberg. Rythmes Sci. 56:132,
et Reproduction. p 115. Masson, Paris. Schoenfeld, H. 1901. La Spermatog~n~se chez le
Regaud, C. 1901. l~tude sur la structure des tubes tareau et chez les mammif&es en g~n&al. Arch.
s6minif~res et sur la spermatog~n~se chez les de Biol, (Liege), 18:1.
mammiferes. Arch. Anat. Micr. 4:101. Setchell, B. P. 1978. The Mammalian Testis. Cornell
Ritz~n, E. M., V. Hansson and F. S. French. 1981. Univ. Press, Ithaca.
The Sertoli cell. In: H. Burger and D. de Kretser Setchell, B. P. 1980. The functional significance of
(Ed,). The Testis. p 171. Raven Press, New the blood-testis barrier. J. Androl. 1: 3.
York. Setchell, B. P., R. V. Davies and S. J. Main. 1977.
Saacke, R. G. and J. O. Almquist. 1964. Ultrastruc- Inhibin. In: A. D. Johnson and W. R. Gomes
ture of bovine spermatozoa. I. The head of (Ed.). The Testis. Vol. 4. p 189. Academic
normal, ejaculated sperm. Amer. J. Anat. 115: Press, New York.
143. Shannon, P. 1972. The effect of egg yolk level and
Salamon, S. 1962. Studies on the artificial insemina- dose rate on conception rate of semen diluted
tion of Merino sheep. Ill. The effect of frequent in caprogen. Proc. 7th Inter. Congr. Anim.
ejaculation on semen characteristics and fer- Reprod. and A.I. 2:1441.
tilizing capacity. Australian J. Agr. Res. 13: Siguoret, J. P. 1970. Reproductive behavior of pigs.
1137. J. Reprod. Fertil. (Suppl. 11):105.
Salamon, S. and R. J. Lightfoot. 1970. Fertility of Smith, P. E. 1927. The disabilities caused by hypo-
ram spermatozoa frozen by the pellet method. physectomy and their repair. J. Amer. Med.
Ill. The effects of insemination technique, Assoc. 88:158.
oxytocin and relaxin on lambing. J. Reprod. Steinberger, A. 1981a. The Sertoli cell and its role
Fertil. 22:409. in spermatogenesis. In: G. Frajese, E.S.E. Hafez,
Salisbury, G. W. and N. L. VanDemark. 1961. Physiol- C. Conti and A. Fabbrini (Ed.). Oligozoospermia:
ogy of Reproduction and Artificial Insemination Recent Progress in Andrology. p 35. Raven Press,
of Cattle. W. H. Freeman and Co., San Francisco. New York.
Salisbury, G. W., N. L. VanDemark and J. R. Lodge. Steinberger, A. 1981b. Regulation of inhibin secretion
1978. Physiology of Reproduction and Artificial in the testis. In: P. Franchimont and C.P.
Insemination of Cattle (2rid Ed.). W. H. Freeman Channing (Ed). Intragonadal Regulation of
and Co., San Francisco. Reproduction. p 283. Academic Press, New York.
Schanbacher, B. D. 1979a. Relationship of in vitro Swierstra, E. E. 1968a. Cytology and duration of the
gonadotropin binding to bovine testes and cycle of the seminiferous epithelium of the boar;
the onset of spermatogenesis. J. Anita. Sci. duration of spermatozoan transit through the
48:591. epididymis. Anat. Rec. 161 : 171.
Schanbacher, B. D. 1979b. Testosterone secretion Swierstra, E. E. 1968b. A comparison of spermatozoa
in cryptorchid and intact bulls injected with production and spermatozoa output of York-
gonadotropin-releasing hormone and luteinizing shire and Lacombe boars. J. Reprod. Fertil.
hormone. Endocrinology 104: 360. 17:459.
Schanbacher, B. D. 1979c. Increased lamb production Swierstra, E. E. 1971. Sperm production of boars
with rams exposed to short day lengths during as measured from epididymal sperm reserves
the nonbreeding season. J. Anim. Sci. 49:927. and quantitative testicular histology. J. Reprod.
Schanbacher, B. D. 1982a. Responses of ram lambs Fertil. 27:91.
to active immunization against testosterone Swierstra, E. E., M. R. Gebauer and B. W. Pickett.
and luteinizing hormone-releasing hormone. 1974. Reproductive physiology of the stallion.
MALE REPRODUCTION 403

I. Spermatogenesis and testis composition. lease in hemicastrated prepubertal rams and


J. Reprod. Fertil. 40:113. its relationship to testicular development. J.
Turner, T. T. and D. M. Cesarini. 1981. The effect Endocrinol. 84:141.
of an aldosterone antagonist on the sperm Watson, P. F. 1979. The preservation of semen in
concentrating ability of the rat epididymis. mammals. Oxford Rev. Biol. 1:283.
Biol. Reprod. 24(Suppl~ 1):45A. Wettemann, R. P., M. E. Wells, 1. T. Omtvedt, C. E.
Turner, T. T., D.D'Addario and S. S. Howards. 1978. Pope and E. J. Turman. 1978. Influence of
Further observations on the initiation of sperm elevated ambient temperature on reproductive
motility. Biol. Reprod. 19:1095. performance of boars. J. Anita. Sci. 42:664.
VanDemark, N. L. 1956. Quantitative aspects of Willett, E. L. and J. I. Ohms. 1957. Measurement
semen production in bulls. Proc. 3rd Inter. of testicular size and its relation to produc-
Congr. Anim. Reprod. and A.I., Plenary Papers: tion of spermatozoa by bull~ J. Dairy Sci. 40:
80. 1559.
VanDemark, N. L. and U. D. Sharma. 1957. Prelimi- Wilson, J. D. and P. K. Siiteri. 1973. Developmental
nary fertility results from the preservation pattern of testosterone synthesis in the fetal
of bovine semen at room temperatures. J. Dairy gonad of the rabbit. Endocrinology 92:1182.
Sci. 40:438. Wolf, F R., J. O. Almquist and E. B. Hale. 1965.
van der Molen, H. J. and F.F.G. Rommerts. 1981. Prepubertal behavior and puheral charac
Testicular steroidogenesis. In: H. Burger and teristies of beef bulls on high nutrient allowance.
D. de Kretser (Ed.). The Testis. p 213. Raven J. Anita. Sci. 24:761.
Press, New York. Yallow, R. S. and S. A. Berson. 1960. Immunoassay
van Straaten, H.W.M. and C.J.G. Wensing. 1978. of endogenous plasma insulin in man. J. Clin.
Leydig cell development in the testis of the Invest. 39:1157.
pig. Biol. Reprod. 18:86. Young, W. C. 1931. A study of the function of the
yon Ebner, V. 1888. Zur Spermatogenese bie den epididymis. III. Functional changes undergone
S~ugethieren. Arch. Mikr. Anat., 31: 236. by spermatozoa during their passage through
Waites, G.M.H. and R. T. Gladwell. 1982. Physio- the epididymis and vas deferens in the guinea
logical significance of fluid secretion in the pig. J. Exp. Biol. 8:151.
testis and blood-testis barrier. Physiol. Rev. Zaneveld, L. J. and R. Chatterton. 1982. Biochemistry
62:624. of Mammalian Reproduction. John Wiley & Sons,
Walton, J. S., J. D. Evins and G.M.H. Waites. 1978. New York.
Feedback control of follicle-stimulating hor- Zirkin, B. R., L. L. Ewing, N. Kromann and R. C.
mone in pre- and post-pubertal rams as revealed Cochran. 1980. Testosterone secretion by rat,
by hemicastration. J. Endocrinol. 77:75. rabbit, guinea pig, dog, and hamster testes
Walton, J. S., J. D. Evins, M. A. Hillard and G.M.H. perfused in vitro: correlation with Leydig cell
Waites. 1980. Follicle-stimulating hormone re- ultrastructure. Endocrinology 106:1867.

You might also like