Professional Documents
Culture Documents
Final Test FEM
Final Test FEM
Dr. Arianta
PROBLEM 1
A cantilever as shown in the figure below is constructed by 2 (two) CST elements. Use E =
210 GPa, = 0,30 and t = 5 mm. The force P which acts at nodes are 2X kN. Assume plane
stress conditions apply.
a. Determine the nodal displacement and the element stresses with direct stiffness method
(score 25% CO-1 SO-g, CO-1 SO-h, CO-2 SO-g, CO-2 SO-h)
b. Compare your result at point a (above) with software analysis using Abaqus and SAP2000.
Give your comment and explanation about the comparison results (score 15% CO-3 SO-j)
P
4
3
1
1Y0 mm
1 2 P
1Y0 mm
Segala bentuk kecurangan akademik (termasuk pelanggaran tata tertib ujian) dalam setiap proses pembelajaran
akan diberikan sanksi sesuai peraturan yang berlaku
UP-SPMI/FR014/R01 1
UJIAN TENGAH SEMESTER
<Ganjil> <2019/2020> - <PROGRAM STUDI TEKNIK SIPIL>
PROBLEM 2
Same data with problem 1 above
A. Determine the nodal displacement and the element stresses with direct stiffness method for
a cantilever in the figure below (score 30% CO-1 SO-g, CO-1 SO-h, CO-2 SO-g, CO-2
SO-h)
B. Compare your result at point a (above) with software analysis using Abaqus and SAP200.
Give your comment and explanation about the comparison results (score 15% CO-3 SO-j)
C. Using Abaqus and SAP2000 software, change the element into rectangular plane element
(Q4). How many the Q4 elements needed to get the same result as point A. Explain your
results (score 15% CO-3 SO-j)
P
4 3
3
5
1Y0 mm 4 2
1
P
1 2
1Y0 mm
Note:
Please fill X and Y with your two last student ID number, ex 1041160XY
Segala bentuk kecurangan akademik (termasuk pelanggaran tata tertib ujian) dalam setiap proses pembelajaran
akan diberikan sanksi sesuai peraturan yang berlaku
UP-SPMI/FR014/R01 2