You are on page 1of 1

ELECTRONICS A type of flip-flop in which the data are entered and _______________ is a secret key encryption

appear on the output on the same clock edge. technology that is used in client/server environments
What is network node dedicated to interfacing a. Set Reset Flip flop for secure authentication between computers
between the network and one or more printers? b. Edge Triggered Flip flop a.Kepberos
a. Print server c. JK Flip flop b. Kerberos
b. Lay-out Server d. D Flip flop c. Kesberos
c. Tune server d. None of the above
d. All of the above If the feedback signal (voltage or current) is applied in
such a way that it is in phase with the input signal and What is the circuit which has a purpose to quiet a
What is formed on the screen of cathode ray thus increases. It is also known as regenerative receiver in the absence of a received signal?
oscilloscope when two sine wave voltages are feedback or direct feedback a. Squilch circuit
simultaneously applied to the two sets of deflection b.Squealch circuit
plates? a. Positive Feedback c. Squelch circuit
a. Lizzajous pattern b. Negative Feedback d. Squeltch circuit
b. Lisajous pattern c. Stabilized Feedback
c .Lissajous pattern d. Impedance Feedback
d. Lizajous pattern
Refers to the process of shrinking the size and power
A type of oscillator which uses an amplifier circuit that dissipation of electronic circuits. It also involves
introduces 1800 phase shift surface mount technology
a. RC Phase Shift Oscillator a. Gull wing
b. Wien Bridge Oscillator b. Microminiaturization
c. Hartley Oscillator c. Floating Point
d. Armstrong Oscillator d. Synchronous Deviation

A type of Oscillator that is very commonly used as A non-volatile read/write random access
local oscillator in superheterodyne radio receiver semiconductor memory in which data are stored as
a. RC Phase Shift Oscillator charge on the floating gate of a certain type of FET
b. Colpitt’s Oscillator
c. Clapp Oscillator a. PROM b. Hard Disk
d. Wien Bridge Oscillator c. Flash Memory d. RAM

The measure of how “pure” or “real” an inductor is. It is a channel model in which the input and output
The higher its value in an inductor, the fewer losses alphabets x and y are discrete sets and the channel is
there are. memoryless
a. Q-factor a. The Discrete Memory Channel
b. Beta Factor b. The Discrete channel
c. Alpha Factor c.The Discrete Memoryless Chanel
d. K-factor d. None of the above

This can be defined as the ratio of output d.c. power It is a diagnostic application or device that a network
available at the load to the power rating (Volt Ampere) administrator can purchase and install on a network
of the transformer used in the rectifier circuit workstations or attach to the network media to
a. Transformer Utilization Factor monitor and capture dat packets for subsequent
b. Transformer Form Factor analysis..
c. Transformer Load Voltage Factor
d. Transformer Working Factor a. Sniffer
b. Splatter
c. Clipper
d. Clamper

You might also like